2002 GMC SIERRA Complaints

I HAVE A 2002 GMC TRUCK. AT 38,000 MILES THE CLUTCH WENT OUT COMPLETELY. THE MECHANIC TOLD ME THE CLUTCH PLATE WAS OK BUT THE 2 HYDRAULIC CYLINDERS NEEDED TO BE REPLACED.

AT SLOW SPEEDS (BELOW 10 MPH) THE ANTI LOCK BRAKES MESS UP AND TRUCK CAN NOT BE STOPPED. WOULD HAPPEN ONCE IN A WHILE, NOW IT HAPPENS EVERY TIME I TRY TO STOP. ALMOST RAN INTO SEVERAL PEOPLE. I CAN NOT BELIEVE THIS PROBLEM HAS NOT BEEN A RECALL CONSIDERING THAT ALL THE PEOPLE I HAVE TALKED TO THAT HAVE HAD THE SAME PROBLEM AND THAT I AM SURE THERE HAS HAD TO BEEN SEVERAL ACCIDENTS INVOLVING THIS. A DEALER TOLD ME TO PULL THE ANTI-LOCK FUSE UNTIL I GET IT FIXED WHICH I HAVE. TRUCK NOW STOPS BUT I NO LONGER HAVE ANTI-LOCK BRAKES. *JB

I HAVE A 2002 GMC SIERRA WITH ABS WHICH FALSELY ACTIVATES AT SLOW SPEEDS. MANY FRIENDS HAVE HAD SIMILAR COMPLAINTS, ONE OF WHICH CONNECTED ME TO YOU FOLKS. THE SITUATION IS AS KNOWN IN PE05020. THE "FIX" IS TEMPORARY AND TYPICALLY LASTS 9 - 12 MONTHS. *NM

DT: THE FRONT AND REAR ROTORS FELL APART. THE MECHANIC HAD TO REPLACE THE ROTORS AT 47,000 MILES. HE SAID IT WAS A COMMON PROBLEM. THE CONSUMER WENT TO THE DEALER AND THEY SAID IT WAS NORMAL. THE CONSUMER SENT LETTERS TO GMC AND THEY ARE RETURNING LETTERS. *AK *JB

DT: CALLER COMPLAINED ABOUT TRANSMISSION FAILURE. WHILE PULLING AWAY FROM A STOP SIGN HEARD A NOISE AND COULD NOT GET VEHICLE TO MOVE. FINALLY, GOT IT OFF THE ROAD, BUT WAS UNABLE TO MOVE FORWARD OR BACKWARD. CALLER SAID THE ORIGINAL OWNER HAD THE SAME PROBLEM. MANUFACTURER WANTED DEALER TO EVALUATE THE PROBLEM AND CALL THEM BACK, AND FOR THE CALLER TO PAY FOR REPAIRS. . DEALER HAD NOT COME SEEN THE VEHICLE. *AK

DT: CONSUMER STATED BRAKE FAILURE RESULTED IN EXTENDED STOPPING DISTANCE. TOOK TO A DEALER FOR THIS ISSUE 3 TIMES. DEALER'S GENERAL MANAGER SAID THERE WAS SOME TYPE OF PROBLEM BUT HE DID NOT KNOW WHAT CAUSED IT. NO REPAIRS OR PARTS REPLACED. *AK ON OCT 18, 2004 THE REAR ROTORS WERE TURNED. EVEN AFTER THE ROTORS WERE TURNED THE BRAKES STILL PERFORMED POORLY. THE RIGHT FOG LIGHT FELL OFF WHILE DRIVING. *NM

THIS COMPLAINT IS TO SUPPORT INVESTIGATION PE05020 1 - EVENTS LEADING TO FAILURE: MY TRUCK HAS BEEN DRIVEN IN NY STATE SINCE IT WAS PURCHASED IN LATE 2001. IT HAS BEEN PROPERLY MAINTAINED AND SERVICED. 2 - FAILURE AND ITS CONSEQUENCES: AFTER 40,000 MILES, EVERY TIME I CAME TO A STOP THE ANTI-LOCK BRAKES WOULD KICK IN (UNDER 10 MPH IN COMPLETELY DRY CONDITIONS). THIS MADE THE VEHICLE EXTREMELY DIFFICULT IF NOT IMPOSSIBLE TO STOP. I ALMOST BECAME INVOLVED IN AN ACCIDENT ON 3 OR 4 SEPARATE OCCASIONS UNTIL I PULLED THE FUSE FOR THE ABS SYSTEM. PULLING THE FUSE DISABLES THE SYSTEM SO I'M NOW DRIVING WITHOUT ANTI-LOCK BRAKES. CERTAINLY BETTER THAN THE ALTERNATIVE. 3 - CORRECTIVE MEASURES AND AVAILABILITY OF PARTS I BROUGHT THE VEHICLE IN FOR SERVICE TO PATRICK GMC IN ROCHESTER, NY. PAID $85.73 TO HAVE IT DIAGNOSED. THEY INDICATED BOTH FRONT SPEED SENSORS WERE BAD AND BOTH HUB ASSEMBLIES WOULD NEED TO BE REPLACED AT A COST OF $432 PER SIDE PLUS TAX. THE SENSOR ITSELF IS NOT AVAILABLE - IT MUST BE PURCHASED WITH AN ENTIRE HUB ASSEMBLY. I DID NOT HAVE THE WORK DONE AND CONTINUE TO DRIVE THE VEHICLE WITH THE ABS FUSE PULLED. THE VEHICLE IS UNSAFE TO DRIVE IN ANY OTHER CONDITION (EXCEPT IF THE HUBS WERE REPLACED). THE DEFECTIVE PARTS ARE STILL ON MY TRUCK. *NM

I HAVE A 2002 GMC SIERRA 1500 EXTENDED CAB TRUCK WITH FIRESTONE WILDERNESS AT TIRES WHICH CAME WITH THE VEHICLE. ABOUT 12:15 AM I WAS DRIVING EASTBOUND ON I-70 JUST WEST OF JUNCTION CITY WHEN I HEARD A LOUD SOUND FROM THE REAR OF MY TRUCK, AND WAS BARELY ABLE TO MAINTAIN CONTROL. AT THIS POINT IT WAS ABOUT 85F, BUT FOR A GOOD PART OF THE DAY I HAD BEEN DRIVING IN 100+F HEAT (SINCE ABOUT 5 PM, WITH A BREAK IN DRIVING FROM ABOUT 8:30 PM TO 10:30 PM). I PULLED OVER, AND FOUND THAT THE TREADS FROM MY LEFT REAR TIRE HAD COMPLETELY SEPARATED FROM THE SIDEWALL. I PUT THE SPARE TIRE ON AND DROVE THE REST OF THE WAY HOME (ABOUT 150 MILES). RIGHT NOW MY TIRE IS IN 3 PIECES: 2 SIDEWALLS STILL ON THE RIM, AND THE TREAD IS A SEPARATE PIECE, STILL IN A COMPLETE CIRCLE. FORTUNATELY I THINK THE DAMAGE IS LIMITED TO THE TIRE (WHICH MEANS I'M GOING TO HAVE TO REPLACE ALL 4 TIRES), AND POSSIBLY THE RIM OF THE ONE TIRE. RIGHT NOW I HAVE ALL THE PARTS, AND WILL TRY AND KEEP THEM WHEN I HAVE THE TIRES REPLACED.

ANTI LOCK BRAKES WOULD ACTIVATE FOR FOR NO REASON AT ALL ONCE AND A WHILE AT SLOW SPEEDS CONDITION GOT WORSE UNTIL I COULD NOT STOP FOR A STOP SIGN AND ALSO HIT A CURB I HAD TO REMOVE THE FUSE TO DISABLE THE ANTI LOCK BRAKES TO AVOID A BAD CRASH.

GMC SIERRA 2002 THE VEHICLE'S ANTILOCK BRAKING SYSTEM ENGAGED WHILE BEING DRIVEN ON DRY PAVEMENT. *SC AS A RESULT I TOOK THE TRUCK CONSIDERABLE TIME AND DISTANCE TO COME TO A COMPLETE STOP. THIS BRAKING PROBLEM HAD BEEN OCCURRING REPEATEDLY OVER THE PAST 6 MONTHS. *NM