2000 GMC SIERRA Complaints

PULLED ON TO ROAD WHILE TOWING BOAT AND COULD NOT STOP. BRAKE PEDDLE TO FLOOR. USED EMERGENCY BRAKE TO STOP. REPLACED SOME LINES AND PROBLEM RE-OCCURRED. *JS

AS I WAS APPROACHING A STOP SIGN AT 30 MPH, I WENT TO APPLY THE BRAKES AND THE BRAKE PEDAL WENT TO THE FLOOR BOARD. I PUMPED THE BRAKES A COUPLE TIMES TO REGAIN PEDAL PRESSURE WITH NO LUCK. I WAS LUCKY THAT NO OTHER CARS WERE AT THE INTERSECTION OR ELSE THERE WOULD HAVE BEEN AN ACCIDENT FOR SURE. I MADE A QUICK RIGHT HAND TURN AND USED EMERGENCY BRAKE TO STOP. THERE WAS A PUDDLE OF BRAKE FLUID COMING FROM THE ABS MODULE UNDERNEATH THE DRIVERS SIDE DOOR. UPON FURTHER INSPECTION, THE BRAKE LINE RUPTURED DUE TO RUST AND CORROSION. I AM RELIEVED THAT NO ONE WAS AT THE INTERSECTION AND THAT I DID NOT HAVE MY WIFE AND 3 KIDS IN THE VEHICLE AT THE TIME THE BRAKES WENT OUT. I HAVE OWNED MANY VEHICLES AND NEVER HAD A SINGLE VEHICLE WHERE METAL BRAKE LINES HAVE RUSTED OUT. I HAVE OWNED THIS TRUCK FOR 10 YEARS AND NOW QUESTION GM AND THEIR QUALITY AND INTEGRITY. AT THIS POINT, I PROBABLY WON'T BUY ANOTHER GM TRUCK BECAUSE THEY RUST OUT IN LESS THAN 10 YEARS AND MY FAMILY'S LIFE WAS AT STAKE FOR A DESIGN/QUALITY FLAW. I NOW HAVE TO SPEND $1000+ DOLLARS TO REPLACE ALL BRAKE LINES ON MY TRUCK WHEN GM COULD HAVE INSTALLED STAINLESS STEEL BRAKE LINES IN THE FIRST PLACE. DISAPPOINTED GMC TRUCK OWNER. *TR

WHILE DRIVING IN TOWN I NOTICED MY BRAKE PEDAL WAS FEELING SOFT, THE NEXT TIME I DEPRESSED THE PEDAL, IT WENT ALL THE WAY TO THE FLOOR AND THE VEHICLE WOULD NOT STOP AT ALL. I COASTED INTO A PARKING LOT AND USED THE EMERGENCY BRAKE TO COMPLETE THE STOP. I LOOKED UNDER THE VEHICLE BY THE DRIVERS SIDE DOOR AND WITNESSED THE FLUID DRIPPING OUT OF THE BRAKE LINES. THE CAR WAS TOWED TO A LOCAL MECHANIC, WHERE HE DISCOVERED ALL FOUR LINES HAD FAILED AT A POINT WHERE ALL THE LINES WERE HELD TOGETHER BY A MOUNTING BRACKET, JUST UNDER THE DRIVER'S SIDE, AND MOUNTED TO THE FRAME. HAD I BEEN AT HIGHER SPEEDS AND HAD TO MAKE A QUICK STOP THE OUTCOME WOULD HAVE BEEN MUCH WORSE. *TR

I OWN A 2000 GMC SIERRA CREW CAB SHORT BOX 4 BY 4. I WAS DRIVING DOWN THE ROAD AND HEARD A GRINDING SOUND, SO I THOUGHT TO LIMP IT HOME. BAD IDEA, I WAS THE TWO BOLTS THAT HOLD YOUR CALIPER ON, SO THAT IS YOUR WHOLE BRAKE SYSTEM, WELL IT MADE MY WHEEL LOCK UP AND CAUSED ME TO LOOSE CONTROL AND HIT THE CURB WHERE I BENT MY RIM AND POPPED MY TIRE, SO I REPLACED THE TWO BOLTS ON DRIVER BACK SIDE AND CHECKED THE PASSENGER BACK SIDE AND THOSE TWO BOLTS WHERE LOOSE. VERY SCARY. SO I TIGHTEN THEM BOTH AND LIKE I SAID REPLACED THE OTHER TWO ON THE DRIVER SIDE. WHEN I SEEN THE WAY IT WAS SET UP I WAS SHOCKED BECAUSE IT WAS NOT A GOOD IDEA AND NEVER SEEN CALIPERS BOLTED LIKE THAT, THIS HAPPENED THREE MONTHS AGO WELL TODAY I WAS DRIVEN AND HEARD THE SAME NOISE AGAIN AND BEFORE I COULD STOP ALL THE WAY MY TIRE LOCKED UP AGAIN BUT THIS TIME I WAS IN CONTROL AND STOPPED OK. I AM FREAKING OUT BECAUSE I HAVE A FIVE YEAR OLD SPECIAL NEEDS DAUGHTER AND DON'T WANT HER TO BE IN MY TRUCK IF IT DECIDES TO LOCK UP AND FLIP.SO I WENT TO THE SAME AUTO SHOP AND HAD IT REPLACED AGAIN. LIKE I SAID I SEEN A LOT OF BRAKE SYSTEMS AND THIS WAY THEY HAVE IT IS NOT SAME AND I IMAGINE HAS CAUSED DEATHS, IF NOT YET IT WILL, IT ABOUT MADE ME ROLL AND SCREWED UP MY RIMS AND NEW TIRES, I DON'T KNOW IF I SHOULD SELL IT BECAUSE I DO NOT HAVE MONEY TO GET THEM ALL REPLACED. SO IM GOING TO SEE IF THERE IS A RECALL AND IF NOT THERE NEEDS TO BE. MY MOM HAVE A 2004 SILVERADO CHEVY AND I OWNED A 2002 BEFORE AND BOTH TRUCKS BRAKE SYSTEM ARE DIFFERENT. I WANT TO KNOW WHY THEY ARE LIKE THIS AND WHY THEY CHANGE A GOOD THING. I HOPE THIS WAS HELPFUL. SO IF YOU HEAR GRINDING IN TIRES MAKE SURE YOU STOP AND GET IT TOWED. *TR

THE BRAKES IN MY GMC PICKUP TRUCK FAILED DUE TO SEVERELY RUSTED STEEL BRAKE LINES. TWO LINES BURST , ONE AFTER THE OTHER , AS I PUMPED THE BRAKE PEDAL TO STOP THE TRUCK. AN INSPECTION REVEALED EXTENSIVE AND PREMATURE RUST THROUGHOUT THE BRAKE LINE SYSTEM, REQUIRING REPLACEMENT OF ALL OF THE BRAKE LINES. *TR

TRAVELLING TO WORK ONE MORNING ON A BUSY, WELL TRAVELED ROAD I WAS APPROACHING A TRAFFIC LIGHT. I WAS DRIVING APPROXIMATELY 40 MPH. THERE WAS A FEW CARS AHEAD OF ME AND WE ALL HAD TO STOP FOR THE RED LIGHT. AS I APPLIED THE BRAKE AND STARTED TO SLOW DOWN SUDDENLY THE BRAKE PEDAL WHEN TO THE FLOOR AND I REALIZED I HAD LOST THE BRAKES. REALIZING THAT I WAS GOING TO REAR END THE CARS IN FRONT OF ME I WAS FORCED TO SHIFT TO 1ST GEAR ON THE AUTOMATIC TRANSMISSION AND SWERVE TO THE RIGHT OFF THE SIDE OF THE ROAD. I CAME CLOSE TO HITTING SOME HUGE TREES AND RUNNING INTO A DITCH. AFTER MY NERVES SETTLED DOWN I SAFELY PULLED OUT OF THE EMBANKMENT AND SLOWLY DROVE THE TRUCK TO A SAFE OPENING VERY CLOSE BY. I STARTED TROUBLESHOOTING MY BRAKES AND FOUND A LEAK UNDER THE TRUCK BEHIND THE FRONT DRIVERS SIDE TIRE. I LOOKED CLOSER AND FOUND THAT ONE OF MY BRAKE LINES HAD BURST OPEN. LOOKING AT THE BRAKE LINES REVEALED THEY WERE ALL RUSTED BADLY. I HAD MY TRUCK TOWED HOME. AS WE WERE DRIVING HOME THE TOW TRUCK DRIVER TOLD ME THAT THESE TRUCKS HAVE A STRONG HISTORY OF RUST PROBLEMS OF THE BRAKE LINES AND OTHER AREAS. AFTER UNLOADING THE TRUCK I WENT ONLINE AND STARTED READING ABOUT THE RUST PROBLEMS ON THESE VEHICLES. I WAS SHOCKED AT THE AMOUNT OF PEOPLE HAVING THE SAME PROBLEMS. I CANNOT UNDERSTAND WHY THERE HAS NOT BEEN A RECALL ON AN ISSUE SO IMPORTANT AS BRAKE LINES RUSTING OUT. I AM WONDERING IF SOMEONE HAS TO GET KILLED BEFORE SOMETHING IS DONE ABOUT IT. I ENCOURAGE ANYONE WHO OWNS A 1999-2000 GMC OR CHEVY PICK UP TRUCK TO CHECK YOUR BRAKE LINES AND IF THEY ARE RUSTING (WHICH ALMOST ALL ARE) TO FILE A COMPLAINT WITH THE NHTSA.DOT.GOV/VEHICLECOMPLAINT.

WHILE DRIVING WEST ON CENTRAL AVENUE IN PEDAL, I APPLIED THE BRAKE PEDAL TO SLOW THE VEHICLE TO MAKE A RIGHT TURN ONTO STEVENS STREET. I FELT NO RESISTANCE AND LOOKED DOWN TO SEE IF I HAD MISSED THE BRAKE PEDAL SOMEHOW, BUT IT HAD PUSHED WITH NO RESISTANCE TO THE FLOOR. PUMPING THE BRAKES REPEATEDLY, I WAS ABLE TO OBTAIN A SMALL AMOUNT OF BRAKING AND MADE THE TURN ON STEVENS. STOPPING AT DEEP SOUTH CYCLES, I TOLD THE MECHANIC WHAT HAD OCCURRED AND HE NOTICED THE REAR WHEELS WERE VERY HOT, INDICATING REAR BRAKE LOCKUP. INDEED, AT THAT TIME THEY WERE STILL LOCKED UP. WE CHECKED THE EMERGENCY BRAKE TO SEE IF IT WAS APPLIED AND IT WASN'T. THE BRAKE FLUID LEVEL WAS THE PROPER LEVEL, ALSO. AFTER THE BRAKES HAD COOLED DOWN I DROVE THE TRUCK A SHORT DISTANCE TO A REPAIR SHOP ON CENTRAL AVENUE WHERE THEY REPLACED THE REAR BRAKE CALIPERS AND PADS. THEY STATED THAT THE REAR ROTORS HAD TURNED BLUE FROM THE HEAT, AND ADDED THAT THEY "HAD SEEN A LOT OF FAILURES OF GMC BRAKE CALIPERS." *TR

BRAKE LINE LEAK FROM RUST HOLE IN BRAKE LINE BELOW DRIVERS SIDE DOOR. ALMOST HIT THE VEHICLE AHEAD OF ME. I HAVE GM VEHICLES THAT ARE MUCH OLDER THAN THIS ONE AND NEVER HAD THIS HAPPEN BEFORE. 1977 CHEVY, ETC. I FEEL A RECALL IS IN ORDER, I HAVE READ ON THE INTERNET ABOUT OTHER PEOPLE HAVING THE SAME PROBLEM THAT DIDN'T END AS WELL I DID. *TR

TL* THE CONTACT OWNS A 2000 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE ABS AND HYDRAULIC BRAKES FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS BUT THE DEALER WAS UNABLE TO DIAGNOSE THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. *TR

EXHAUST MANIFOLD BOLTS FRONT AND BACK ON BOTH SIDES BROKE OFF , THIS IS COMMON PROBLEM ON THIS TRUCK. *TR