2004 GMC SIERRA Complaints

TRAVELING SOUTH, NY RT. 12. ATTEMPTED TO SLOW FOR A RIGHT TURN. SIGNAL ON, TOWING AN EMPTY TRAILER APPROX WEIGHT 2000 LBS. APPLIED THE SERVICE BRAKE FOR THE TURN, PEDAL WENT TO FLOOR, NO BRAKES. LUCKILY NO INCIDENT. EXAMINED THE UNDERNEATH AND FOUND THAT THE STEEL BRAKE LINES WERE ROUTED OVER THE FRAME ON THE DRIVER SIDE (UNDERNEATH BODY UNDER THE DRIVER DOOR.) WHEN BRAKE LINE(S) FAILED, THERE WERE NO SIGN OF ANY BRAKING ABILITY. BOTH THE FRONT AND REAR BRAKE SYSTEMS WERE INOPERABLE. THE LINES HAD RUSTED THROUGH FROM APPARENTLY ROAD SALT OR (?), CREATING A VERY DANGEROUS SITUATION. SINCE THE INCIDENT I HAVE SPOKE WITH SEVERAL OTHER DRIVERS WHO HAVE EXPERIENCED THE SAME FAILURE. *TR

BRAKE LINES HAD RUSTED OUT AND BURST SO THE BRAKES FAILED TO STOP THE TRUCK. TRUCK WAS ON A DOWN HILL INCLINE AND WENT THROUGH A STOP LIGHT (FORTUNATELY IT WAS LATE AT NIGHT AND THERE WAS NO CROSSING TRAFFIC.) HAD TO REPLACE ALL THE BRAKE LINES. *TR

THE SPEEDOMETER,OIL PRESSURE GAUGE, ALT METER, FUEL GAUGE HAVE ALL FAILED OVER THE LAST SEVERAL YEARS. NONE OF THEM READ CORRECTLY. *TR

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT THE SPEEDOMETER WOULD EITHER DISPLAY AN INACCURATE SPEED READING OR BECOME COMPLETELY INOPERABLE. THE CONTACT INDICATED THAT THE DEFECT WAS DIAGNOSED BY THE DEALER AND THE CONTACT WAS INFORMED THAT A NEW INSTRUMENT PANEL CLUSTER NEEDED TO BE INSTALLED TO REMEDY THE DEFECT. NO REPAIRS WERE PERFORMED ON THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 83000.

WHILE DRIVING, NEEDED TO SLOW DOWN FOR TRAFFIC LIGHT AND THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO STILL DRIVE IT, AS THE BRAKES WOULD STOP THE TRUCK EVENTUALLY. CAUSE WAS THE RUSTED REAR BRAKE LINE THAT RUPTURED. COST TO FIX WAS $400.00 IN ADDITION, ON 12.27.13, I HAD THE FRONT WHEEL BEARING REPLACED AT A COST OF $525.00. THE TRUCK ONLY HAS 66,600 MILES ON IT. *TR

I WAS I 91 SOUTH HEADING IN TO HARTFORD CT, TRAFFIC WAS HEAVY AND AS A RESULT I WAS TRAVELING APPX 20 MPH AS I ENTERED THE RAMP EXIT LANE. I STEPPED ON BRAKE PEDAL AND THE PEDAL WENT TO THE FLOOR, FORTUNATELY I WAS ABLE TO VEER INTO THE BREAKDOWN LANE AND AVOID HITTING OTHER CARS. I SLOWLY MADE IT TO MY PLACE OF EMPLOYMENT AND LATER HAD THE TRUCK TOWED HOME. AS IT TURNS OUT I DISCOVERED THE ALL BRAKE LINES HAD CORRODED AND HAD TO BE REPLACED. I CONTACTED GM AS I THOUGHT IT VERY UNUSUAL FOR ALL BRAKES LINES TO BE SO SEVERELY CORRODED. THEY ATTRIBUTED THE SEVERE CORROSION TO THE FACT THAT THE TRUCK WAS 10 YEARS OLD AND REFUSED TO COVER THE EXPENSE AND CONSIDERED THE CASE CLOSED. BY DOING A SIMPLE INTERNET SEARCH I FOUND THAT THIS SAME PROBLEM IS QUITE COMMON AND MY MECHANIC ALSO INFORMED THAT GM ( POSSIBLY AS A RESULT OF THIS BEING A COMMON ISSUE) HAS MADE A AVAILABLE A BRAKE LINE REPLACEMENT KIT. *TR

TL* THE CONTACT OWNS A 2004 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING LESS THAN 10 MPH, THE ABS ENGAGED INDEPENDENTLY. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). IN ADDITION, THE CONTACT LSO STATED THAT THE PASSENGER'S SIDE TAILGATE BECAME FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40000. *TR

TL* THE CONTACT OWNS A 2004 GMC SIERRA DENALI. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WAS ABLE TO BE FULLY DEPRESSED BUT DID STOP THE VEHICLE. THE VEHICLE WAS DOWNSHIFTED AND THE PARKING BRAKE WAS APPLIED WHEN THE BRAKE WARNING LAMP ILLUMINATED. THE VEHICLE WAS LEFT TO BE TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 41,000.

TL* THE CONTACT OWNS A 2004 GMC SIERRA. THE CONTACT STATED THAT WHILE REVERSING INTO HER RESIDENTIAL GARAGE, THE BRAKES FAILED. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE, SHE NOTICED THAT ONE OF THE BRAKE LINES HAD FRACTURED AND ALL THE REST OF THE BRAKE LINES WERE COMPLETELY CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 78,000.

AFTER EXITING ONTO THE HIGHWAY AND ATTEMPTING TO BRAKE TO MAKE A RIGHT TURN I EXPERIENCED CATASTROPHIC BRAKE FAILURE. WHEN THE BRAKE PEDAL WAS APPLIED THERE WAS NO PRESSURE, AND THE PEDAL WENT STRAIGHT TO THE FLOOR. NO WARNING LIGHTS OR SENSORS WERE ACTIVATED BEFORE THE TOTAL BRAKE FAILURE. THE VEHICLE WAS TOWED TO A LOCAL GMC DEALERSHIP. THE DEALERSHIP ADVISED ME THAT THE BRAKE LINE "BLEW OUT" FROM THE FRONT LEFT CALIPER BECAUSE OF RUST. I RESEARCHED SUCH PROBLEMS AND FOUND THAT SIMILAR COMPLAINTS WERE NUMEROUS AND THAT THE NHTSA HAD INITIATED AN INQUIRY/INVESTIGATIONS INTO EXCESSIVE RUST ON BRAKE COMPONENTS OF GMC VEHICLES CAUSING THIS TYPE OF TOTAL BRAKE FAILURE. *TR