2003 GMC SIERRA 1500 Complaints

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. THE VEHICLE WAS TAKEN TO A STATE INSPECTION STATION WHERE THE CONTACT WAS INFORMED BY THE TECHNICIAN THAT THE BRAKE LINES EXHIBITED SEVERE RUST. THE DEALER WAS NOTIFIED OF THE FAILURE BUT BECAUSE THE VEHICLE WAS OUTSIDE OF WARRANTY, THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE CONTACT STATED THAT THE MAIN FRAME ALSO EXHIBITED RUST AND CORROSION. THE CONTACT WAS IN THE PROCESS OF TAKING THE VEHICLE TO AN INDEPENDENT MECHANIC FOR REPAIR. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 72,000.

TRAVELING TO WORK AND VEHICLE CUT OUT INFRONT OF MY TRUCK. APPLIED BRAKES TO AVOID COLLISION AND HEARD POP AND BRAKE PEDAL WENT TO FLOOR. UPON ARRIVING AT WORK A FEW MOMENTS LATER FOUND REAR BRAKE LINE CORRODED AND PERFORATION WENT THROUGH CAUSING LEAK. REPLACED THE REAR BRAKE LINE TO CORRECT BUT BRAKES STILL INOP. OLD PIECE OF CORRODED LINE IS AVAILABLE. *TR

ON SEPTEMBER 29, 2010, I WAS DRIVING MY TRUCK ON RT. 66 WEST APPROACHING LINDEN VA. AT APPROXIMATELY 65 MPH WHEN TRAFFIC BEGAN TO STOP ABRUPTLY BECAUSE OF ROADWORK. I WAS IN THE LEFT LANE AND APPLIED MY BRAKES. AT THIS TIME MY BRAKE PEDAL WENT TO THE FLOOR. I HAD BEGUN MY STOP FAR ENOUGH AWAY FROM TRAFFIC AHEAD OF ME THAT I WAS ABLE TO SLOW DOWN WITHOUT HITTING ANYONE IN FRONT OF ME. I MOVED MY TRUCK OVER TO THE RIGHT SHOULDER, THEN ONTO THE RAMP FOR THE LINDEN VA. EXIT AND THEN PARKED ON THE SHOULDER THERE. WHEN I GOT OUT OF THE TRUCK I FOUND A PUDDLE OF BRAKE FLUID QUICKLY FORMING UNDER MY TRUCK, BELOW THE LEFT FRAME RAIL BEHIND THE LEFT FRONT WHEEL. WHEN I LOOKED UP TO SEE WHERE THE FLUID WAS COMING FROM, I FOUND THE LEAK COMING FROM A BUNDLE OR FOUR BRAKE LINES, THAT WERE HEAVILY CORRODED, THAT RAN BESIDE THE FRAME RAIL. AT THIS TIME I MADE ARRANGEMENTS TO HAVE THE TRUCK TOWED TO MY RESIDENCE. AT THE TIME I WAS TOWING A SINGLE AXLE UTILITY TRAILER. THE TRUCK HAS NOT YET BEEN REPAIRED. THIS TRUCK IS A 2003 GMC SIERRA 1500 HD CREW CAB SHORT BED, 8600 GVW. IT IS NEARLY IDENTICAL IN EQUIPMENT TO A 2500 HD CREW CAB SHORT BED. I PURCHASED THIS VEHICLE NEW. *TR

NO EVENTS LEADING UP TO FAILURE. FAILURE, NO POWER ASSIST TO LEFTHAND TURNS. POSSIBLE LOSS OF CONTROL OF TRUCK. 9-30-09 DEALER REPLACED POWER STEERING ASSEMBLE PT# 88965789 S/GR REM 6.508. 9-13-10 NO EVENT LEADING TO FAILURE LOSS OF POWER ASSIST FOR LEFTHAND TURNS POSSIBLE LOSS OF CONTROL OF TRUCK. DEALER REPLACED POWER STEERING ASSEMBLE PT# 88965789 S/GR REM 6.508 THIS HAS HAPPENED TWICE NOW ON THIS TRUCK. *TR

WHILE DRIVING HOME FROM WORK, I TRIED TO STOP AT A STOP LIGHT. PUSHED THE BRAKE PEDAL AND IT WENT TO THE FLOOR. GOT IT STOPPED BY USING THE PARKING BRAKE. SERVICE BRAKE LIGHT ON. AFTER PARKING THE TRUCK, NOTICED LIQUID ON DRIVEWAY. TRACED THE LIQUID BACK TO A RUSTED BRAKE LINE. *TR

I OWN A 2003 GMC SIERRA 1500 HD. THIS PAST WINTER I ALMOST HIT A SNOW PLOW DUE TO A BRAKE LINE RUPTURE. UPON INSPECTION IT WAS FOUND THAT ALL THE BRAKE LINES WERE SEVERELY RUSTED AND VERY BRITTLE. I HAD THE ONE LINE REPLACE WHICH COST ME NEARLY $300. NO THIS PAST WEEK ANOTHER RUPTURE ALMOST CAUSED ME TO REAR END ANOTHER VEHICLE. THIS TIME I'M GOING TO HAVE TO REPLACE EVERY LINE IN THE BRAKING SYSTEM. ALSO THE ABS SYSTEM KICKS IN WHEN TRAVELING AT SLOWER SPEEDS (5-10 MPH). THE CAUSE OF THIS IS UNKNOWN TO ME AT THIS TIME. UPON DOING A LITTLE RESEARCH ONLINE I FIND THAT THERE ARE THOUSANDS OF PEOPLE WITH THE SAME MODEL AND NEARLY THE SAME YEAR VEHICLES, HAVING EXACTLY THE SAME PROBLEMS. THEN I FIND ON YOUR SITE WHERE YOU HAVE STARTED AN INVESTIGATION INTO THE PROBLEM. NHTSA ACTION NUMBER: PE10010 THIS TRUCK HAS BEEN VERY WELL TAKEN CARE OF AND THERE IS NO EXCUSE FOR THESE LINES TO BE FAULTY IN ONLY 6-7 YEARS TIME. IT'S LIKELY TO COST ME NEARLY A $1,000 TO HAVE ALL OF THESE LINES CHANGED. MY QUESTION IS IF THE NHTSA FINDS GM RESPONSIBLE FOR THESE FAULTY LINES AND THEY ISSUE A RECALL, WILL I BE REIMBURSED FOR HAVING ALREADY PAID FOR THE REPAIR? *TR

2003 GMC TRUCK FAILED SAFETY INSPECTION DEW TO EXTREMELY RUSTED BRAKE LINES. *TR

HAD DEALERSHIP REPLACE DRIVER SIDE FRONT WHEEL BEARING BECAUSE IT WAS MAKING A GRINDING NOISE. A COUPLE MONTHS LATER THE FRONT BRAKE PADS AND ROTORS WERE REPLACED. AFTER THE BRAKES WERE SERVICED, I STARTED NOTICING THAT THE BRAKES WERE PULSATING, WHICH WAS FELT IN THE PEDAL, AT LOW SPEEDS. TOOK VEHICLE TO THE DEALERSHIP AND THEY SAID DURING THE TEST DRIVE THAT THE ABS SYSTEM WAS ACTIVATING UNNECESSARILY. THEY THEN PUT IT ON THE DIAGNOSTIC MACHINE FOR SOME REASONS. I WAS TOLD I NEEDED TO REPLACE BOTH WHEEL ABS SENSORS. THE DEALERSHIP SAID THAT THE ABS HAS NOTHING TO DO WITH THE BRAKE PADS AND ROTORS. WHEN THE PADS AND ROTORS WERE REPLACED, AGAIN THE VEHICLE WAS PUT ON THE DIAGNOSTIC MACHINE, BUT DIDN'T PICK UP THAT THE SENSORS WERE FIRING. I'M DOUBTING IT IS COINCIDENCE THAT THESE THINGS ARE HAPPENING AT RANDOM. THERE HAS TO BE SOME KIND OF CORRELATION BETWEEN THE WHEEL BEARING BEING REPLACED, THE PADS AND ROTORS BEING REPLACED, AND NOW THE SENSORS NEEDING TO BE REPLACED. MY VEHICLE IS A 2003 GMC SIERRA AND HAS 47000 MILES ON IT. ALL THIS HAPPENED WITHIN THE LAST 6 MONTHS AND 1500 MILES. *TR

MY 2003 GMC SIERRA 1500 SPEEDOMETER DOESN'T WORK. IT SHOWS HIGH SPEEDS AFTER THE TRUCK IS SHUT OFF. IT SEEMS TO WORK IN WARM WEATHER BUT DOESN'T WORK IN COLD WEATHER. NOT SURE WHEN THE SPEEDOMETER IS ACCURATE. *TR

LOST APPROXIMATELY 80% OF BRAKING POWER IN A 2003 GMC SIERRA 1500 WITH 60,000 MILES. SMALL LEAK DEVELOPED IN THE METAL BRAKE LINES. THERE WAS NO SENSOR INDICATION THAT FLUID WAS LOW DESPITE BRAKE FLUID BEING ONE QUART LOW. *TR