2019 GMC SIERRA 1500 Complaints

After a really bad cold snap noticed oil spots on my driveway, after further inspection noticed the oil cooler lines were leaking from the crimps. Got in contact with GM because there was a customer satisfaction program for my year model- N212326940- they told me it did not apply to my truck but it is a know issue, and now I’m having to come out of pocket for it.

catastrophic engine failure to due connecting rod bearings spun on the crankshaft damaging the crank and sending bearing material throughout the oil galleries

Catastrophic engine failure. Engine failed while driving and lost all oil pressure. Nearly cause accident

While pulling a small trailer to go hunting, the engine just lost all power while merging onto the freeway. I had to pull over to the shoulder in high speed traffic because the truck had no power and had an odd clanking sound. When I took it to the dealer for repair, they stated that the lifter failed and also damaged the cam. This required a full engine rebuild. When the dealer went to test drive the truck with the new parts, ANOTHER lifter failed and also affected the cam again which required another rebuild.

On January 15, 2026, my wife was driving our 2019 GMC 1500 Sierra Denali and the lights on the dash came on with the truck losing power. I made to my wife later in the day and was able to drive the truck to the dealership only achieving 15mph for about 5 miles. The Mike Bell Chevrolet Dealership in Carrolton GA stated that my engine was knocking and needed to be replaced. I took my truck the John Thornton Buick GMC dealership on January 22 to get a second opinion and they stated the exact same thing stating the engine needs to be replaced. The dealership is stating the remanufactured replacement issue is over $10,900. My truck has over 271,000 miles.

This vehicle shudders and vibrates during shifting and acceleration at different speeds. Transmission shifts out of gear quite often leaving me stranded at times trying to make it safely out of traffic.

The contact owns a 2019 GMC Sierra 1500. The contact stated that while driving at various speeds, the braking system had erroneously activated, causing the vehicle to abruptly stop in the middle of the road. The vehicle was towed to the local dealer, who diagnosed that the failure was caused by an engine malfunction of the number six cylinder. The vehicle was repaired. No further information was available. After retrieving the vehicle, the contact was driving approximately 10 MPH when the failure reoccurred and the braking system erroneously activated, causing the vehicle to abruptly stop. During the incident, the driver's head slammed into the steering wheel, causing a head laceration. No medical treatment was required. The vehicle was towed back to the dealer. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 120,000.

My vehicle recently experienced a sudden flashing check engine light, severe misfiring, and rough engine operation, creating an unsafe driving condition. An inspection by an authorized GMC dealership, Serra Buick GMC Champaign, confirmed a failed deactivating valve lifter on Cylinder 5, documenting that the lifter ceased movement after a single engine rotation. The dealership advised that the failure necessitates replacement of all lifters and extensive internal engine components, at an estimated cost of $5,650.75. This defect is not isolated, unforeseeable, or the result of consumer misuse. It is directly associated with General Motors’ Active Fuel Management (AFM) system, which has been widely reported to cause: •Premature lifter collapse •Camshaft damage •Severe engine misfires •Loss of power while driving •Catastrophic engine failure

IntelliBeam will sometimes allow me to activate the system but will turn itself off and not allow it to be reactivated until the power is cycled. Other times it will not activate at all. This is on a dark backroad with no traffic.

While driving in traffic in March 2025, the vehicle experienced a sudden and complete engine failure, creating an unsafe condition. Subsequent diagnosis confirmed failure of the camshaft and lifters, requiring full engine replacement. General Motors declined to cover this repair. However, this failure is consistent with widely reported camshaft and lifter issues affecting other GMC and GM vehicles equipped with the same 6.2L engine platform. Due to the unavailability of replacement engines through GM, I was forced to wait several months for an engine sourced through Jasper Engines. During this time, the vehicle was inoperable, resulting in over $10,000 in out-of-pocket expenses, including extended rental vehicle costs. The engine replacement was completed by Camden Automotive and Diesel in Camden, South Carolina, who maintain all service and maintenance records related to this repair.