2002 GMC SIERRA 1500 Complaints

1. BRAKES WERE FULLY OPERATIONAL AFTER THE INITIAL RECALL WAS COMPLETED (10/13/05). RECENTLY, JANUARY 2010, MY ANTI-LOCK BRAKE SYSTEM HAS TRIGGERED AT LOW SPEEDS UNDER 10 MPH CAUSING MY TRUCK TO NOT COME TO A COMPLETE STOP. THIS IS THE SAME PROBLEMS I WAS HAVING PRIOR TO THE INITIAL RECALL. RELEASING THE BRAKES AND REAPPLYING THE BRAKES HAVE WORKED TO STOP THE VEHICLE SO FAR. 2. THE FAILURE HAPPENS ABOUT 1 IN 5 STOPS DEPENDING ON THE SPEED OF THE VEHICLE. I HAVE NEARLY HIT SEVERAL CARS IN PARKING LOTS, BECAUSE OF THE SLOW SPEED DURING PARKING. 3. GM HAD A RECALL 4 YEARS AGO ON THE WHEEL SPEED SENSOR (05V379000) ALL THEY DID WAS CLEAN AND LUBRICATE THE UNIT. NOT ADEQUATE ENOUGH, SINCE I AM HAVING THE SAME PROBLEM OVER AGAIN. *TR

2002 GMC SIERRA PU ANTI LOCK BRAKES FAILED IN 2005. CLOSE ENCOUNTER WHEN BRAKES FAILED TO STOP VEHICLE. BRAKES WERE REPAIRED UNDER WARRANTY. BRAKE FAILURE AGAIN IN 2009 AND PAID OUT OF POCKET TO HAVE REPAIRED. SAME BRAKE FAILURE FOR THIRD TIME. 2010 ANTI-LOCK BRAKES CURRENTLY DISCONNECTED. *TR

BRAKE LINES RUSTED THROUGH OUT TRUCK, FAILED SAFETY INSPECTION DUE TO RUSTED LINES. *TR

2002 GMC SIERRA, CONCERNING ABS. AT LOW SPEEDS ( LESS THAN 5MPH) BRAKES RELEASE, WILL NOT HOLD..RECALL IN 2005, WAS FINE ,LASTED 2 YEARS, THEN SAME THING, VIRTUALLY NO BRAKING AT LOW SPEEDS, DEALER SAID IT COULD BE $400 OR $500 TO FIX, I DON'T THINK SO. I ASKED HIM TO PULL THE FUSE, REFUSED, FOUND LOCATION OF FUSE AND YANKED IT AND THE TRUCKS BRAKES WORK FINE. THIS IS A DANGEROUS SITUATION AND SHOULD BE FIXED PERMANENTLY BY GMC. *TR

TL*THE CONTACT OWNS A 2002 GMC SIERRA 1500. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH IN RAINY WEATHER CONDITIONS AND PRESSURE WAS APPLIED TO THE BRAKE PEDAL, FOLLOWED BY AN ACTIVATION OF THE ANTI-LOCK BRAKE SYSTEM. THE FAILURE OCCURRED AT EXTREMELY LOW SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE FAILURE WAS CONTRIBUTED TO SEVERE CORROSION IN THE ANTI-LOCK BRAKE SENSOR. THERE WAS A PRIOR RECALL REPAIR UNDER NHTSA 07E106000 (WHEELS:CAP/COVER/HUB). HOWEVER, THE REMEDY FAILED TO CORRECT THE SAFETY RELATED DEFECT. THE VEHICLE HAS NOT BEEN REPAIRED FOR THE MALFUNCTION. THE FAILURE MILEAGE WAS 34,000. THE STEERING SHAFT WAS REPLACED. UPDATED 02/18/10

TL* THE CONTACT OWNS A 2002 GMC SIERRA 1500. WHILE MAKING A LEFT TURN THE STEERING COLUMN LOCKED WITHOUT PRIOR WARNING. AFTER COMPLETING THE TURN, SHE WAS ABLE TO UNLOCK THE STEERING COLUMN. SHE TOOK THE VEHICLE TO THE DEALERSHIP, AND SHE WAS IN THE PROCESS OF HAVING THE POWER STEERING GEAR BOX REPLACED . THE CURRENT MILEAGE WAS 77,596. THE FAILURE MILEAGE WAS 77,483.

MY ISSUE WITH MY 2002 GMC SIERRA 1500 REGULAR CAB LONG BED IS RELATED TO AN ABS WHEEL SENSOR RECALL. I HAD MY TRUCK SERVICED IN DEC 2005 FOR THE RECALL PROBLEM. THE NATURE OF THE PROBLEM IS CORROSION AT THE ABS WHEEL SENSOR WHICH CAUSES THE ABS BRAKING SYSTEM TO ACTIVATE AT LOW SPEEDS WHEN STOPPING WHICH IN TURN INCREASES THE STOPPING DISTANCE. THIS IS A SAFETY ISSUE THAT CANNOT BE NEGLECTED. I HAD GONE TO THE BOB ROSS BUICK/GMC DEALERSHIP IN CENTERVILLE, OH ON 4/30/2009 ' ORIGINAL DEALER WHERE I PURCHASED THE TRUCK. THEY PERFORMED AN INSPECTION FOR $64.95 PLUS TAX AND 10% SHOP SUPPLIES CHARGE. THEY TOLD ME THAT SINCE THE TRUCK WAS ALREADY SERVICED FOR THE RECALL, THAT I AM NOT COVERED TO RE-REPAIR/REWORK THE TRUCK FOR THE RECURRENCE OF THE PROBLEM. I CONTACTED GM CUSTOMER CARE AND WORKED WITH A REPRESENTATIVE NAMED AL AND THEN AFTER HE SAID HE COULDN'T DO ANYTHING FOR ME FROM GM CORPORATE I WAS CONNECTED TO GM DISTRICT SPECIALIST DONALD HOWELL (1-800-790-5700 X41958). DONALD ALSO EVENTUALLY SAID THAT GM WOULD NOT HELP WITH GETTING THE WORK PERFORMED. THE SERVICE REQUEST # FOR MY CASE IS 71-758818423. MY REQUIREMENT FOR RESOLUTION IS THAT GM REPAIRS THE ISSUE AT NO COST TO ME, MOST PREFERABLY BY REPLACING THE ABS WHEEL SENSORS WITH NEW ONES LESS LIKELY TO CORRODE. I'M SURE THAT THE NEW PRODUCT DESIGN HAS THE CORROSION ISSUE IN MIND AND HAS FOUND A WAY TO AVOID IT. AS THE REPAIR HISTORY OF MY VEHICLE SHOULD STATE, THE ABS WHEEL SENSORS WERE CLEANED AND THEN SPRAY PAINTED WITH A 'CORROSION RESISTANT PAINT' TO FIX THE ISSUE IN DEC 2005. AS AN AUTOMOTIVE ENGINEER WHO WORKED FOR GM/DELPHI FOR 14 YEARS OF MY PROFESSIONAL CAREER, I KNOW THAT WHAT WAS PERFORMED PREVIOUSLY IS NOT A PERMANENT FIX. I ALSO AM WILLING TO BET THAT I AM NOT THE ONLY CUSTOMER WITH RECURRENCE OF THIS ISSUE. HAD IT BEEN FIXED CORRECTLY THE FIRST TIME ' WITH NEW ABS SENSORS - THEN THE PROBLEM WOULD NOT HAVE RECURRED. I SHOULD ALSO BE REIMBURSED FOR THE $76.46 I HAD TO SPEND FOR DIAGNOSIS. *TR

GMC 2002 SIERRA ABS TRIGGERED AT LOW SPEED. UNABLE TO STOP WITHIN REASONABLE DISTANCE. HAPPENING 90% OF THE TIME NO LONGER ABLE TO SAFELY DRIVE THIS VEHICLE. NO CORRECTIVE ACTION TAKEN YET. *TR

UNDER THE DRIVER AND PASSENGER DOORS THE BODY HAS RUSTED THROUGH. THIS IS THE ONLY SPOT ON THE ENTIRE TRUCK THAT HAS RUST. I TOOK IT TO THE DEALER THAT I ORIGINALLY PURCHASED IT FROM AND WAS TOLD THAT SINCE IT HAD 103,000 MILES IN IT THEY WERE UNABLE TO HELP. *TR

BRAKE LINE FAILURE DO TO EXCESSIVE RUST. ALL BRAKE LINES HAD TO BE REPLACED AS THEY WE ALL RUSTED EXCESSIVELY. *TR