2002 GMC SIERRA 1500 Complaints

TL*THE CONTACT OWNS A 2002 GMC 1500. THE CONTACT HEARD A LOUD GRINDING NOISE WHEN THE BRAKE PEDAL WAS DEPRESSED. HE NOTICED THAT THE FRONT BRAKES WERE RUSTED VERY BADLY. THE REAR BRAKES WERE RUSTED AS WELL, BUT NOT AS BADLY AS THE FRONT BRAKES. THE DEALER STATED THAT THERE WERE NO RECALLS; THEREFORE, THEY COULD NOT ASSUME LIABILITY FOR THE FAILURE. THE FAILURE MILEAGE WAS 48,000 AND CURRENT MILEAGE WAS 50,800. UPDATED 01/07/09 *BF UPDATED 01/07/09. *JB

THE GASOLINE GAUGE ON MY 2002 GMC SIERRA PICKUP DOES NOT READ CORRECTLY AFTER IT REACHES THE 1/4 LEVEL. *TR

TL*THE CONTACT OWNS A 2002 GMC SIERRA 1500. THE CONTACT BEGAN EXPERIENCING FAILURES WITH THE VEHICLE WHILE DRIVING 20 MPH. HE TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THERE WAS A LEAK COMING FROM THE BRAKE LINE, WHICH CAUSED DIFFICULTY WHEN BRAKING. THE DEALER ALSO STATED THAT THE FUEL LINE WAS RUSTED AND NEEDED TO BE REPLACED. THROUGH RESEARCH, THE CONTACT FOUND NUMEROUS COMPLAINTS ON THIS VERY SAME FAILURE FOR HIR YEAR, MAKE, AND MODEL VEHICLE. HE BELIEVED IT WAS DUE TO A MANUFACTURER DEFECT. THE VEHICLE HAS BEEN REPAIRED; HOWEVER, THE CONTACT BELIEVES A RECALL SHOULD BE ISSUED. THE CURRENT AND FAILURE MILEAGES WERE 50,100. UPDATED 09/29/08. *LJ UPDATED 09/29/08. *JB

THE SPARE TIRE HOIST FAILED CAUSING MY SPARE TIRE TO FALL OFF. LUCKILY THIS HAPPENED IN MY DRIVEWAY. IF THIS HAD HAPPENED ON THE ROAD IT COULD HAVE CAUSED A FATALITY TO ANYONE BEHIND ME. THE CABLE APPEARS TO BE THE SAME MATERIAL THAT THE TAILGATE CABLES WERE MADE OF. THE CABLES WERE ALREADY RECALLED BY GM. *TR

TL*THE CONTACT OWNS A 2002 GMC SIERRA 1500. WHILE DRIVING 5 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WHEN IT WAS DEPRESSED. THE VEHICLE WOULD THEN EXPERIENCE UNWANTED ABS ACTIVATION. THE CONTACT CALLED THE DEALER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK). A TECHNICIAN STATED THAT HIS VEHICLE WAS INCLUDED IN THE RECALL, BUT THEY WOULD ONLY ASSUME RESPONSIBILITY FOR REPAIRING THE RELUCTOR RING. THE CONTACT WOULD HAVE TO PAY FOR THE HUB ASSEMBLY REPAIR AT THE COST OF $800. THE VEHICLE HAS NOT BEEN REPAIRED. HE CALLED THE MANUFACTURER ON NUMEROUS OCCASIONS AND IS STILL WAITING FOR A RESPONSE. THE FAILURE AND CURRENT MILEAGES WERE 52,500.

ABS ACTIVATING AT LOW SPEEDS WAS BROUGHT IN UNDER WARRANTY AND REPAIRED ONCE ALREADY. PROBABLY 2004. NOW SAME THING AGAIN 2008. VERY DANGEROUS WHEN YOU STEP ON BRAKE AND ABS ACTIVATES FOR NO REASON (OTHER THAN POOR DESIGN) AT LOW SPEED AND INCREASES YOUR STOPPING DISTANCE BY 10 PLUS FEET. *TR

THE ABS SYSTEM HAS AN OPEN SHORT BETWEEN THE ABS PUMP AND THE ABS MODULE. THESE COMPONENTS ARE LOCATED UNDER THE VEHICLE MOUNTED TO THE FRAME RAIL. THIS IS SAFETY RELATED EQUIPMENT AND WAS MOUNTED IN A HIGHLY CORROSIVE SPOT, SUBJECT TO ROAD SALT AND WATER. *TR

SIMILAR TO NHTSA: 05V161000 MY 2002 GMC SIERRA WITH AUTOMATIC TRANNY EXPERIENCES THE VERY SAME PREMATURE PARKING BRAKE WEAR. WEAR IS UNEVEN AND JUST IN 2 LITTLE PLACES INSTEAD OF EVEN WEAR ON WHOLE SHOE. BRAKE WEARS VERY QUICKLY THEN WILL NOT HOLD PUTTING UNDUE STRESS AND CAUSING FAILURE OF PARKING PAWL IN AUTOMATIC TRANNY. GM REFUSED TO DO ANYTHING. GM WILL NOT FIX MY VEHICLE OR APPLY RECALL SINCE I DO NOT HAVE MANUAL TRANNY. IF ANYTHING, AUTOMATIC TRANNY IS WORSE SINCE IT DAMAGES TRANNY DUE TO STRESS ON PAWL SINCE PARKING BRAKE DOES NOT HOLD VEHICLE. WHEN BRAKE SHOES WERE REPLACED, THEY WORKED FOR VERY SHORT PERIOD OF TIME. $250 TO REPLACE AND I WAS TOLD IT WAS A KNOWN PROBLEM AND I WOULD BE WASTING MY MONEY BECAUSE THEY WOULD WEAR OUT QUICKLY AGAIN. ODD THAT SHOES WEAR WHEN VEHICLE TYPICALLY IS NOT MOVING WHEN BRAKE IS APPLIED OR RELEASED. *TR

SINCE PURCHASING MY 2002 SIERRA PICKUP WITH A 5.3L V-8 I HAVE NOTICED A TICKING SOUND WHEN YOU FIRST START UP THE VEHICLE. WORSE WHEN IT IS COLD OUT. AFTER A FEW MINUTES IT STOPS. I HAVE HAD THE DEALER LOOK AT IT IN THE PAST AND THEY DIDN'T SEEM TOO CONCERNED WITH IT AND OR SAID NO NOISE WAS FOUND. I CALLED GMC AND THEY ISSUED ME AN EXTENDED WARRANTY FOR 5 YEARS OR 100,000 MILES. WITH APPROXIMATELY 68,000 MILES ON THE TRUCK NOW THE NOISE IS GETTING WORSE AND IS QUITE LOUD WHEN YOU START IT UP IN THE MORNING. IT ALSO TAKES LONGER TO DISAPPEAR NOW. WHEN YOU START TO DRIVE IT, IT IS QUITE LOUD AND YOU WONDER IF IT IS DOING DAMAGE. IT SOUNDS LIKE A HYDRAULIC LIFTER NOT GETTING OIL. AFTER IT WARMS UP IN A FEW MINUTES IN DISAPPEARS. *TR

2002 GMC SIERRA WITH AUTOMATIC TRANSMISSION HAS BOTH THE ABS PROBLEMS THAT HAVE A RECALL ONLY ALONG EAST COAST STATES AND THE PARKING BRAKE PROBLEM THAT HAS A RECALL FOR MANUAL TRANSMISSIONS. *TR