2003 GMC SIERRA 1500 Complaints

2003 GMC SIERRA 1500 PU TRUCK - CORRODED AND FAILING HYDRAULIC BRAKE LINES. THIS TRUCK WAS PURCHASED NEW BY ME IN OCTOBER 2003, AND NOW HAS ONLY 23,700 MILES ON IT. A LINE NEAR THE FUEL TANK, WHICH FEEDS THE REAR WHEEL CALIPERS, RUSTED THROUGH IN JANUARY 2009. OTHER LINES IN NUMEROUS LOCATIONS ALSO SHOW SIGNS OF CORROSION WHICH WILL LEAD TO FUTURE FAILURES. MECHANICS IN THIS AREA TELL ME THIS IS VERY COMMON, EVEN ON SOME NEWER GMC (AND SIMILAR CHEVROLET) VEHICLES. SOME OF THESE MECHANICS REPLACE THE FAULTY LINES WITH TUBING WHICH IS MORE CORROSION-RESISTANT THAN PROVIDED BY THE MANUFACTURER. A COUPLE OF WEEKS AGO, ONE OF THE REAR, REAR WHEEL EMERGENCY BRAKE CABLES ON THIS VEHICLE ALSO FAILED DUE TO CORROSION, AND THE OTHER ONE SHOWED SIGNS OF THE SAME FAILURE IMPENDING. BOTH WERE REPLACED. A SERIOUS, FUNDAMENTAL AND COMPOUND HAZARD EXISTS UNDER THIS SCENARIO. THE MANUFACTURER SHOULD BE REQUIRED TO RECALL THEE VEHICLES AND REPLACE ALL CRITICAL BRAKE COMPONENTS SUBJECT TO CORROSIVE FAILURES WITH CORROSION-PROOF (OR AT LEAST HIGHLY CORROSION-RESISTANT) PARTS. *TR

2003 GMC SIERRA - INTERMEDIATE STEERING SHAFT. SECOND FAILURE OF THE STEERING SHAFT, TRUCK HAS ONLY 56,000 MILES. ORIGINAL EQUIPMENT SHAFT FAILED AT 26,000 MILES AND WAS REPLACED UNDER WARRANTY. HUNDREDS OF SIMILAR COMPLAINTS IN VARIOUS GM TRUCK INTERNET FORUMS. A NEW, IMPROVED REPLACEMENT PART IS NOW AVAILABLE, GM PART #19153614. THERE NEEDS TO BE A RECALL TO FORCE GM TO REPLACE THE FIRST GENERATION PART. *TR

MY 2003 GMC 1500 EXTENDED CAB PICKUP'S INSTRUMENT CLUSTER IS NOT WORKING. SPEEDOMETER DOESN'T EVEN WORK. THIS IS NOT SAFE. I HAVE TO PARK MY TRUCK, OR EVEN GET IT TAKEN FOR SPEEDING. NOT TO MENTION IF THERE IS AN ACCIDENT BECAUSE GM HAS A FAULTY PART. THAT IS NOT FAIR. I AND THOUSANDS OF OTHERS HAVE COMPLAINED TO THEM BUT NO SOLUTION. PLUS I HAVE LESS THAN 70,000 MILES ON MY TRUCK. *TR

MY SPEEDO WAS ACTING ERRATICALLY AND FINALLY HAS STOP WORKING AT ALL. IT HAPPENED OUT OF NOWHERE AND I AM HEARING ALOT OF COMPLAINTS FROM FRIENDS AND THE COMPANY I WORK FOR WHO HAS SEVERAL OF THESE VEHICLES THEY ARE ALL GOING BAD. MY VEHICLE IS 03 GMC SIERRA AND MOST THE OTHERS I KNOW OF ARE SIMILAR TRUCKS AND SUVS. I HAVE BEEN PULLED OVER FOR SPEEDING TWICE NOW BUT HAVE NEVER BEEN PULLED OVER FOR SPEEDING UNTIL MY SPEEDO QUIT WORKING. I WOULD LIKE TO SEE A RECALL I HERE THIS IS A EXPENSIVE PROBLEM TO FIX . *TR

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500 HD. THE CONTACT STATED THAT THE HEATER ACTIVATES AUTOMATICALLY AND DOES NOT SHUT OFF AFTER THE VEHICLE HAS BEEN TURNED OFF. SHE MUST OPEN THE HOOD AND REMOVE THE FUSE FROM THE FUSE BOX TO TURN OFF THE HEAT. BEFORE THE VEHICLE IS RESTARTED, SHE MUST REINSTALL THE FUSE IN THE FUSE BOX ONCE AGAIN. THE DEALER WAS AWARE OF THE ISSUE AND STATED THAT THERE WAS ONLY A TSB FOR THIS FAILURE AND NO RECALL. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR COSTS. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 95,000.

THE INSTRUMENT CLUSTER ON A 2003 GMC SIERRA 1500 PICKUP TRUCK FAILS UNEXPECTEDLY. THERE ARE PROBLEMS WITH THE STEPPER MOTORS AND THE MANUFACTURER KNOWS ABOUT IT. CERTAINLY, ONE HAS TO KNOW THE SPEED THEY ARE TRAVELING,ESPECIALLY IN SCHOOL AND CONSTRUCTION ZONES. MARK THESE WORDS "SOMEONE IS GOING TO GET KILLED" THERE ARE SEVERAL COMPLAINTS FILED WITH THE MANUFACTURER AND YOU AND YET NOTING IS DONE TO CORRECT THE PROBLEM. IS IT GOING TO HAVE TO TAKE A FATALITY BEFORE A RECALL IS ISSUED. NO WONDER THE CAR COMPANIES ARE IN SO MUCH TROUBLE!!! *TR

2003 GMC SIERRA 1500 SPEEDOMETER FAILED -- DRIFTED FULLY UPSCALE. NO PRECURSOR - WAS DRIVING STEADY AT 45 MPH. 93000 MILES ON VEHICLE. FIRST TIME FAILURE - BUT IT IS A HARD FAILURE - READING >120 MPH WITH CAR SHUTOFF IN DRIVEWAY. I ADJUSTED MY SPEED DOWN TO BE BELOW WHAT I HOPED WOULD MEET THE SPEED LIMIT. IT APPEARS GMC HAS ISSUED SERVICE NOTICES ON THIS ... I FOUND THE FOLLOWING ON THE INTERNET: SUBJECT:BULLETIN GMP07-174 - SPECIAL COVERAGE ADJUSTMENT #07187 --- SOME CUSTOMERS OF 2003-2004 MODEL YEAR CADILLAC ESCALADE, ESCALADE ESV, AND ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, AND TAHOE; AND GMC SIERRA, ENVOY, YUKON, AND YUKON XL VEHICLES HAVE REPORTED THAT THE INSTRUMENT PANEL (IP) CLUSTER GAUGES STICK, FLUTTER, OR BECOME INOPERATIVE. THIS MAY CAUSE INACCURATE READINGS, INCLUDING THE SPEEDOMETER AND FUEL GAUGE. *TR

2003 GMC 1500 SERIES PICKUP TRUCK...WON'T STOP SLOW SPEED ANTI-LOCK BRAKE FAILURE. *TR

TL*THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHENEVER THE VEHICLE IS DRIVEN AT ANY SPEED, THE CONTACT FEELS BUMPING OR BANGING IN THE STEERING WHEEL. THE VEHICLE WAS REPAIRED BY THE DEALER; HOWEVER, THE FAILURE PERSISTS. THE FAILURE MILEAGE WAS 16491 AND CURRENT MILEAGE IS 36,000. UPDATED 10/14/08 *BF THE DEALER REPLACED THE STEERING SHAFT TWICE. UPDATED 10/23/08. *JB

SPEEDOMETER AND INSTRUMENT CLUSTER SHUT OFF ON ITS OWN ALL GUAGES AND WARNING LIGHTS FAIL. *TR