2002 GMC SIERRA 1500 Complaints

COMPLETE EMERGENCY BRAKE FAILURE. THE E-BRAKE DOES NOT HOLD ON EVEN A SLIGHT INCLINE. FURTHER RESEARCH SHOWS THAT THIS IS A COMMON COMPLAINT BY GMC TRUCK OWNERS ON THE INTERNET. THERE WAS A RECALL FOR THE VEHICLES WITH MANUAL TRANSMISSIONS, BUT NOT VEHICLES WITH AUTOMATIC TRANSMISSIONS. THIS DOES NOT MAKE SENSE... *TR

AT 68,994 MILES MY TRUCK LOST 2ND GEAR, DRIVE, OVERDRIVE AND REVERSE. A NEW REACTION SHELL WAS INSTALLED. AT 90,027 MILES AND 360 DAYS LATER THE SAME PROBLEM OCCURRED AND A BEAST HEAVY DUTY REACTION SHELL WAS AVAILABLE AND INSTALLED. *JB

PARKING BRAKE ON 2002 GMC FAILED REPEATEDLY. THE PARKING BRAKE PEDAL WENT TO THE FLOOR. FIRST TOLD THIS WAS NORMAL. SECOND COMPLAINT BRAKES WERE ADJUSTED. THIRD COMPLAINT CAUSE WAS FOUND. THE BRAKE FAILED TO COMPLETELY RELEASE. THE BRAKE WORE OUT PREMATURELY AND OVERHEATED. THE PROBLEM CONTINUED AFTER REPEATED ATTEMPTS TO REPAIR. THE REAR AXLES NEEDED REPLACEMENT DUE TO OVERHEATING/DAMAGE TO SEALS AND BEARINGS. USE OF FOUR WHEEL DRIVE WITH REAR BRAKES LOCKED TRANSFERRED TORQUE TO FRONT STEERING KNUCKLE WHICH REQUIRED REPLACEMENT. A WARPED REAR BRAKE BACKING PLATE HAS BEEN REPLACED DUE TO EXCESSIVE HEAT. THE VEHICLE HAS 70,000 MILES. THE PARKING BRAKES DID NOT WORK AGAIN AND NEED REPAIR WITH THE OUTCOME UNKNOWN.*AK

THIS VEHICLE WAS INVOLVED IN A SINGLE VEHICLE ACCIDENT HITTING A GAURDRAIL AND CONCRETE DIVIDER. THE 2002 GMC SIERRA1 1500 EXT. CAB TRUCK HAS BEEN TOTALED BY THE INSURANCE COMPANY. THERE WAS EXTENSIVE DAMAGE TO THE FRONT END, HOOD, SIDE PANEL, BED, AND BUMPER, DRIVER SIDE TIRE, ETC. THE AIR BAG FAILED TO DEPLOY. IT ALSO APPEARED THE SEAT BELT JAMMED UPON IMPACT AS OPPOSED TO LOCKING AS IT IS SUPPOSED TO. EVEN THOUGH THE INJURIES WERE NOT SEVERE, SHE HIT HER HEAD ON THE STEERING WHEEL, AND HAD SUSTAINED PROBLEMS FROM THE EXCESSIVE IMPACT AMONG OTHER THINGS. SOMEONE SHOULD CHECK INTO WHY THE AIR BAG DID NOT DEPLOY AS WELL AS THE SEAT BELT.*AK

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2002 GMC SIERRA WITH 10,900 FAILURE MILEAGE AT 15 MPH IN THE DRIVEWAY HE PUT THE FOOT ON THE BRAKE PEDAL AND THE ABS SYSTEM ENGAGED , NOT ALLOWING THE VEHICLE TO STOP. THE VEHICLE WENT THROUGH THE GARAGE WALL. THE VEHICLE WAS TAKEN TO A DEALER, AND THEY FOUND FOUR ABS ERROR CODES. THE DEALER REPLACED THE ABS SENSORS ON THE FRONT WHEELS. THE CURRENT MILEAGE WAS 11,002.*AK CONSUMER HAS PROVIDED INVOICES FOR THE DEALER. UPDATE *4/23/07T *TR

FAILURE OF PARKING BRAKE ON 2002 GMC SIERRA PICKUP. DURING STATE INSPECTION IT WAS FOUND TO BE UNABLE TO HOLD. IT WAS FOUND THAT THE ADJUSTMENTS SCREWS ON BOTH REAR EMERGENCY BRAKES WERE FULLY DISENGAGED, SO THIS MEANT THAT THEY HAD BACKED OFF. THEY WERE AGAINST THE STOPS. THEY WERE ADJUSTED BACK UP, BUT THIS WILL MOST LIKELY HAPPEN AGAIN. I AM A MECHANIC AND KNOW THIS IS A DEFECT THAT COULD CAUSE DEATHS IF THIS IS NOT CORRECTED. THE CAR INSPECTION CENTER WHERE THE TRUCK WAS INSPECTED SAID THERE IS A MANUFACTURING DEFECT THAT THE DEALERS KNOW IS BAD, BUT THEY DO NOTHING TO CORRECT THE DEFECT. HE SAID THEY SEE A LARGE NUMBER OF GMC TRUCK THAT THE PARKING BRAKES IS DEFECTIVE. (MANY OF THE PEOPLE ALSO SAY THEY NEVER USE THE PARKING BRAKE. *JB

PARKING BRAKE FAILURE ON 2002 GMC SIERRA 1500 2WD 4DR EXT CAB W/ AUTOMATIC TRANS. DUE TO EXCESSIVE WEAR OF FRICTION LININGS DUE TO DEFECT IN RELEASE MECHANISM. HAVE 50K MILES ON VEHICLE & EMERGENCY BRAKE SHOES HAVE WORN INTO ROTORS. THE LACK OF A WORKING PARKING BRAKE HAS CAUSED THE TRANSMISSION TO LOCK IN PARK WHEN ON AN INCLINE, ESPECIALLY WHEN TOWING. VEHICLE WILL NOT PASS STATE INSPECTION BECAUSE OF THIS. REFERENCE NHTSA #PE03057, #EA04011.*JB

THERE IS ABNORMAL BRAKE ROTOR DETERIATION AND RUSTING DUE TO POOR MANUFACTURING OR STEEL FORMULAS WHICH RUST ACCERLERATES AND WEARS DOWN THE PADS UNEVENLY. I HAVE WORKED ON BRAKES ON MANY AUTOS AND A FEW TRUCKS I'VE OWNED OVER THE LAST FEW DECADES AND NEVER HAVE SEEN SUCH RUSTING AND SURFACE FLAKING OF THE DISK ROTOR ON MY VIHICLE. I HAD MY DEALER LOOK AT THE ROTORS AND THEY AGREED IT MAY BE A BIT EXCESSIVE. I HAVE TO REPLACE ALL FOUR ROTORS DUE TO POOR QUALITY AND UNREPAIRABLE ROTORS. THE ROTORS LOOK LIKE THEY CAME OFF A 20 YEAR OLD TRUCK....THIS IS A SAFETY AND QUALITY PROBLEM THAT SHOULD BE LOOKED INTO. THANK YOU

DT*: THE CONTACT STATED WHILE TURNING AT VARIOUS SPEEDS ON THE HIGHWAY, THERE WAS A THUMPING NOISE COMING FROM THE STEERING WHEEL COLUMN. THE VEHICLE WAS INSPECTED BY A DEALER WHO DETERMINED THE INTERMEDIATE STEERING SHAFT AND SHAFT PITMAN NEEDED TO BE REPLACED. AFTERWARDS, THE PROBLEM PERSISTED. THE VEHICLE WAS INSPECTED BY THE DEALER WHO DETERMINED THE INTERMEDIATE STEERING SHAFT NEEDED TO BE LUBRICATED. THE MANUFACTURER WAS ALERTED, AND DETERMINED THE INTERMEDIATE STEERING SHAFT LUBRICATION WAS A PART OF GENERAL MAINTENANCE.

I HAVE A 2002 GMC SIERRA 1500 EXTENDED CAB PICKUP WITH 52000 MILES ON IT. THE FRONT HUB BEARINGS ARE ALREADY REQUIRE REPLACEMENT. ON CONSULTING WITH THE LOCAL GARAGE, I DISCOVERED THIS WAS NOT AN ANOMALY, BUT , RATHER, A COMMON OCCURRENCE. MY PREVIOUS EXPERIENCE OVER THE YEARS WITH GM PRODUCTS IS THAT FRONT WHEEL BEARINGS COULD BE PACKED OR REPLACED AT REASONABLE COST, AND THE PARTS PROVIDED AUDIBLE NOTICE OF FAILURE. THE CURRENT DESIGN DOES NOT PROVIDE THIS SAFETY FEATURE. THE ENTIRE HUB MUST BE REPLACED WHEN IT FAILS. AT A COST JUST QUOTED OF JUST BELOW $450 PER WHEEL. THE UNFORTUNATE FACT IS THAT IT IS UNKNOWN HOW MANY OWNERS OF GM PRODUCTS FROM 1998 ONWARD ARE DRIVING WITH WHEEL HUBS THAT ARE SO WORN THAT A CATASTROPHIC FAILURE COULD CAUSE LOSS OF A WHEEL AT HIGHWAY SPEEDS.. UNTIL THE RESOLUTION OF THIS DESIGN SHORTFALL, HIGHWAY DRIVING IS EXTREMELY DANGEROUS. *NM