2003 GMC SIERRA 1500 Complaints

STARTED MY VEHICLE APPLIED THE BRAKE TO SHIFT TO DRIVE AND THE BRAKE PEDAL WENT TO THE FLOOR. I GOT OUT OF THE VEHICLE AND THERE WAS A PUDDLE OF BRAKE FLUID ON THE GROUND ON THE DRIVER SIDE UNDER WHERE THE DRIVERS SEAT IS. THERE WAS BRAKE FLUID DRIPPING FROM A RUSTED BRAKE LINE. I'M LUCKY THIS HAPPENED WHEN THE VEHICLE WAS STOPPED AND NOT WHILE I NEEDED STOP BECAUSE IT WAS A COMPLETE LOSS OF BRAKES.

BRAKES FAILED WHILE ON BOAT RAMP CAUSING BOAT TO KNOCK ME DOWN UNDER TRAILER AS I WAS PULLING DRAIN PLUG .DRIVER WAS ABLE TO APPLY PARKING BRAKE AND PUTTING TRUCK IN DRIVE . BRAKE LINES FAILED BRAKE PETAL WHEN TO FLOOR RUSTED LINES . THEN FOUND OUT THAT IS VERY COMMON WITH GM TRUCKS IN THIS YEAR . RESULT I AM PISSED , A NOTICE FROM GM WOULD HAVE BEEN NICE . WHAT WOULD HAPPEN IF I HAD TO STOP AT A INTERSECTION OR ON THE INTERSTATE.

TL* THE CONTACT OWNS A 2003 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT NOTICED BRAKE FLUID LEAKING FROM THE VEHICLE. IN ADDITION, THE REAR SEAT BELT LATCH FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 144,917.

THE ABS ACTIVATES AT LOW SPEED BRAKING UNDER DRY ROAD CONDITIONS WITHOUT THE TIRES LOCKING UP. THE BRAKE PEDAL VIBRATES AS IF I WERE ON ICE WITH THE TIRES LOCKED UP. BRAKING EFFECT IS REDUCED UNDER THESE CONDITIONS. THIS HAPPENS RANDOMLY AND WHEN IT DOES I CANNOT BE SURE IF I CAN STOP IN TIME BEFORE HITTING THE VEHICLE OR OBJECT IN FRONT OF ME.

82K MILES, ORIGINAL OWNER, WELL MAINTAINED AND GARAGED. HAD TO STOP AT A RED LIGHT AND THE PEDAL WENT TO THE FLOOR AS I WENT INTO THE INTERSECTION.LUCKILY NO OTHER CARS WERE AHEAD OF ME AND NOBODY WAS HURT. DIC LIGHTS CAME ON AND BRAKES HAVE NOT WORKED SINCE LIMPING MY VEHICLE BACK HOME.

PULLING TO A STOP IN MY DRIVEWAY MY BRAKES SLOWED THE TRUCK AND THEN COMPLETELY GAVE WAY WITH THE PEDAL HITTING THE FLOOR. I STOMPED ON THE EMERGENCY BRAKE PEDAL TO KEEP FROM HITTING THE PORCH. I AM SO LUCKY TO HAVE THAT HAPPEN AT LOW SPEED OFF THE ROAD. THAT COULD HAVE BEEN A TRAGEDY ON THE HIGHWAY. TURNS OUT THAT MY BRAKE LINES ARE SEVERELY RUSTED AND ONE OF THE 2 LINES COMING OFF THE MASTER CYLINDER NOW HAS A PINHOLE LEAK IMMEDIATELY ABOVE THE FRAME WHERE IT BENDS 90 DEGREES TO GO BACK TO THE ABS MANIFOLD. APPLYING THE BRAKES JUST SQUIRTS FLUID OUT OF THE LINE. I THOUGHT A SINGLE FAILURE WAS SUPPOSED TO RESULT IN REDUCED BRAKING POWER, NOT COMPLETE LOSS OF BRAKES. NOTE THAT MY TRUCK IS IN OTHERWISE GREAT SHAPE AND I SIMPLY HAD NO IDEA. IT IS CLEAR THAT THE NHTSA HAS BEEN BAMBOOZLED BY GM. BRAKE LINES ARE A CRITICAL LIFE SAFETY SYSTEM, INSTALLED ON AND IN SOME PLACES IN THE CHASSIS BEFORE THE VEHICLE BODY AND BED ARE ATTACHED. IT IS NOT ROUTINE MAINTENANCE TO RINSE THE BRAKE LINES LET ALONE REPLACE THEM. GM PUSHING THIS BACK ON THE CUSTOMER IS COMPLETE BS. YOU CAN BUY NYLON COATED OR STAINLESS STEEL BRAKE LINES FOR LESS THAN 100 $. THE INCREMENTAL COST TO GO FROM STEEL TO SOMETHING THAT WOULD LAST THE OPERATIONAL LIFE OF THE VEHICLE IS LESS THAN 50 $. I'M WAITING ON AN ESTIMATE FROM MY NON-DEALER SHOP, BUT A DEALER CHARGING 3600 $ IS NOT SURPRISING CONSIDERING THE AMOUNT OF LABOR THAT MUST BE INVOLVED. THE NHTSA DECISION ON THE ISSUE IS UNCONSCIONABLE. GUESS IT MIGHT HAVE BEEN DIFFERENT IF THEY HAD RUN OVER A CHILD AT A CROSSWALK OR IF THEIR CHILD WAS MOWED DOWN BY CORPORATE GREED. HOPEFULLY THAT NEVER HAPPENS, BUT WITH SO MANY ROTTING GM TRUCKS ON THE ROAD, WE WILL HAVE TO KEEP OUR FINGERS CROSSED.

I WAS ON MY WAY HOME RUNNING 45 MPH IN LIGHT TRAFFIC. WHEN I WENT TO MAKE A LEFT HAND TURN AND MY BRAKE PEDAL WENT TO THE FLOOR. SCARED THE HELL OUT OF ME. I WAS ABLE TO PUMP THEM ENOUGH TO MAKE THE TURN AND LUCKILY I WAS ONLY THREE BLOCKS FROM MY HOME. I WAS ABLE TO COAST IT HOME. I RAISED THE HOOD AND ALL THE BRAKE LINES ARE SO RUSTY. I HAD MY WIFE STEP ON THE BRAKE AND YOU CAN SEE ONE LINE BUSTED. I CHECKED WITH DEALER AND THEY DON'T OFFER REPLACEMENT PARTS. YOU HAVE PAY SOMEONE TO MAKE THE LINES FOR YOU.

TURNING INTO AN AUTO PARTS STORE, FROM THE HIGHWAY, WHEN I APPLIED THE BRAKES THE PEDAL WENT CLEAR TO THE FLOOR. MY TRUCK SLOWED BUT NOT ENOUGH IF ANYONE WALKING OR A CAR HAD BEEN THERE I WOULD HAVE HIT THEM. I WAS VERY LUCKY. OF THE FOUR BRAKE LINES ONE BURST, TWO WERE SEEPING, BUT NOT DRIPPING AND THE REAR LINE WAS ALMOST AS BAD AS THE OTHER LINES AND ITS A WONDER IT DIDN'T BREAK AT THE SAME TIME. GOING HOME I WOULD HAVE GONE DOWN A VERY STEEP HILL WITH A STOPLIGHT AND A VERY BUSY INTERSECTION. IT COULD HAVE BEEN A DISASTER. THIS IS A LOW MILEAGE TRUCK, SELDOM DRIVEN IN SNOW.

I WAS DRIVING HOME FROM WORK ON I-75 AND STARTED DETECTING A STRONG SMELL OF GASOLINE. I PULLED OVER AND INSPECTED THE VEHICLE. I FOUND THAT THE FUEL LINE HAD RUSTED AND WAS SPRAYING GAS EVERYWHERE. UPON FURTHER INSPECTION, I FOUND THAT ALL THE LINES FOR THE FUEL AND BRAKE SYSTEM WERE SEVERELY RUSTED AND WILL NEED TO BE REPLACED TO AVOID CATASTROPHIC FAILURE THAT COULD RESULT IN SERIOUS INJURIES TO MYSELF AND OTHERS ON THE HIGHWAY. I HAVE RESEARCHED AND FOUND THAT THERE HAVE BEEN THOUSANDS OF COMPLAINTS FILED, BUT NO ACTION TAKEN. AS AN ADDED NOTE...I BOUGHT THE TRUCK NEW, IT IS KEPT IN THE GARAGE MOST OF THE TIME, AND I DO NOT LIVE IN A STATE THAT IS KNOWN FOR HEAVY SNOW FALL OR SALT USAGE. I ALSO HAVE A 1965 MODEL CAR THAT HAS NEVER HAD THE FUEL LINES OR BRAKE LINES REPLACED.

I WAS TOWING MY 33' TRAVEL TRAILER WITH MY VERY WELL MAINTAINED 2003 GMC SIERRA 1500 PICK UP TRUCK. AFTER A FOUR AND A HALF HOUR TRIP ON THE INTERSTATE HIGHWAY DOING 65 MPH, I ARRIVED AT MY CAMPGROUND. AS I WAS BACKING MY TRAILER INTO MY CAMP SITE, MY BRAKE PEDAL WENT TO THE FLOOR AND MY DASHBOARD LIT UP WITH WARNING LIGHTS. I HAD COMPLETE BRAKE FAILURE. I PUT THE TRUCK IN PARK AND GOT OUT TO LOOK UNDER THE TRUCK. RIGHT BELOW THE DRIVER SEAT, BRAKE FLUID WAS POURING OUT OF THE BRAKE LINE WHICH HAD BURST OPEN. I HAD NO BRAKES. THANK GOD THIS HAPPENED WHILE I WAS BACKING THE TRAILER IN AT 2 MPH. MINUTES PRIOR TO THIS I WAS GOING 65 MPH ON THE HIGHWAY, TOWING A 33' TRAILER. I SHUTTER TO THINK WHAT COULD HAVE HAPPENED IF THIS LINE BURST WHILE AT HIGHWAY SPEEDS. MY WIFE AND I WERE FREAKED OUT FOR DAYS THINKING ABOUT WHAT COULD HAVE HAPPENED. WE HAD TO HAVE THE TRUCK TOWED TO A REPAIR SHOP AND ENDURE A VERY EXPENSIVE REPLACEMENT OF ALL THE BRAKE LINES, WHICH WERE COMPLETELY CORRODED. WHILE THE TRUCK WAS BEING FIXED I DID SOME RESEARCH ON THIS PROBLEM AND FOUND THAT THERE WERE MANY, MANY, COMPLAINTS ABOUT THIS EXACT SAME PROBLEM CONCERNING 1999 - 2003 GMC AND CHEVY PICK UP TRUCKS AND OTHER MODELS. GM CLAIMS THAT YOU WOULD STILL HAVE SOME BRAKES BECAUSE THERE ARE SEPARATE BRAKE LINES TO THE FRONT AND REAR BRAKES. THIS IS TRUE, BUT I LOST SO MUCH FLUID, SO FAST, I HAD NO BRAKES. DOES SOMEONE ALWAYS HAVE TO DIE BEFORE THEY FORCE A RECALL? THERE ARE SO MANY COMPLAINTS ON THIS MATTER AND I KNOW THERE IS AN ON GOING INVESTIGATION BY THE NHTSA. ENOUGH INVESTIGATING, FORCE THE RECALL BEFORE SOMEONE DIES IF THEY HAVEN'T ALREADY.