2005 GMC SIERRA 1500 Complaints

MY GMC SIERRA I BOUGHT NEW IN 2006 IT HAS 68,800 MILES ON IT WHEN I WAS SITTING AT A RED LIGHT ON A CITY STREET WHEN THE BRAKE PEDAL LOST PRESSURE AND WENT ALL THE WAY TO THE FLOOR. THE BRAKE LINES HAD RUSTED AND BRAKE FLUID WAS POURING OUT WHEN I TAPED ON THE BRAKE PEDAL. IF I WAS MOVING AT THE TIME THIS HAPPEN SOMETHING REAL BAD COULD HAVE HAPPEN. I OWN A 1948 CHEVROLET PICKUP AND THE BRAKE LINES ARE STILL GOOD ON THAT 70 YEAR OLD TRUCK. GM IS USING POOR QUALITY PARTS FROM LOW BIDDERS ON CONTRACT PUTTING THE PUBLIC AT RISK.

POWER STEERING WENT OUT WHILE ENTERING (TURNING LEFT INTO) PARKING LOT, TOWED TO SHOP. SHOP FOUND BROKE/DEFECTIVE CONNECTION TO STEERING BOX AND LEAKING FLUID. REPLACED FITTING AND TUBING, FLUSHED SYSTEM, AND REPLACED FLUID.

CHARGING SYSTEM FAILURE MESSAGE KEEPS COMING UP ON VEHICLE...REPLACED ALTERNATOR THREE WEEKS AGO AND IT SEEMS TO SOLVE THE PROBLEM...FOR A WHILE AT LEAST...TWO NIGHTS AGO TRUCK DIED...REPLACED BATTERY WITH A BRAND NEW ONE YESTERDAY AND TRUCK IS STILL SITTING ON THE SIDE OF THE ROAD AS BATTERY IS NOT GETTING CHARGE FROM ALTERNATOR.

COMPLAINT ON GM EXHAUST MANIFOLD BOLT DEFECT, INFERIOR BRAKE/ FUEL LINES. MINE IS A 2005 GMC. DEFECTIVE EXHAUST BOLTS AFFECT 12 MILLION GM TRUCKS FROM 1999 TO 2007. GM EXHAUST BOLTS ARE TO SMALL BRITTLE FOR SECURING EXHAUST MANIFOLDS. BOLTS SNAP OFF CAUSING EXHAUST LEAKS. TRUCKS NOT PASSING EMISSIONS AND DANGEROUS EXHAUST FUMES ENTERING THE DRIVERS COMPARTMENT OF THE VEHICLES WHILE DRIVING. I AND MY FAMILY GET A CARBON MONOXIDE HEADACHE WHEN I DRIVE IT AND HAVE HAD TO PULL OVER TO THE SIDE OF THE ROAD FEELING LIKE I WAS GOING TO PASS OUT, OPEN WINDOWS AND SIT UNTIL I FELT BETTER. I HAVE ALSO HAD PROBLEMS GETTING MY TRUCK TO PASS EMISSIONS DUE TO THE LEAKS AND THE LEAKS ARE CAUSING THE VEHICLES TO BE NONE EPA COMPLIANT BECAUSE OF O2 SENSOR ERRORS RESULTING IN FAILED EMISSION TEST. ALSO BRAKE AND FUEL LINES ARE NOT SUITABLE FOR NORTHERN STATES CAUSING BRAKE FAILURE WITH OUT WARNING, FUEL LINES ARE ALL RUSTED AND SWELLED IN DANGER OF BURSTING CAUSING FIRE WITHOUT WARNING. FORD AND OTHER VEHICLES I HAVE WORKED ON USE STAINLESS FUEL LINES AND LOOK LIKE NEW FOR LIFE OF VEHICLE. I HAVE ALSO SEEN OTHER MANUFACTURERS USE POWDER COATED BRAKE LINES ON THE ENTIRE VEHICLE AND 20 YEAR OLD VEHILCES SHOW NO RUST PROBLEMS. MY 2005 GMC FROM THE REAR END BRAKE HOSE TO THE WHEEL CYLINDERS THEY USED POWDER COATED BRAKE LINES. THOSE LINES LOOK LIKE NEW YET. GM KNEW THE POWDER COATED LINES WERE BETTER WHY DID THEY USE FAULTY GALVANIZED STEEL ON THE REST OF THE TRUCK? AS IT IS NOW MY TRUCK CAN'T BE OPERATED ON THE ROAD WITHOUT $3000 IN REPAIRS DUE TO GM USING POOR QUALITY PARTS. THE TRUCK HAS HAD THESE PROBLEMS FOR OVER 5 YEARS NOW AND ONLY HAS 138,000 MILES. TRUCKS LIKE THIS IN SOUTHERN STATES HAVE OVER 250,000 MILES, LINES STILL GOOD. RECALL NEEDS TO BE DONE. GM IS MAKING MONEY NOW YOU TUBE VIDEO ABOUT DEFECTIVE BOLTS HTTPS://WWW.YOUTUBE.COM/WATCH?V=0YG6WLBNZGI *JS

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT NOTICED SEVERE RUST TO THE SUBFRAME OF THE VEHICLE. THE CONTACT STATED THAT THE REAR SUSPENSION, FRONT SUSPENSION, AND STARTER SUPPORT SHOWED EXCESSIVE RUST. ADDITIONALLY, THE SHOCK TOWER, SUPPORTS, TRANSMISSION BOLTS, FOUR WHEEL DRIVE ACTUATOR, AND HARDWARE ALSO SHOWED EXCESSIVE RUST. THE CONTACT ALSO STATED THAT THE HORN ALSO FAILED TO OPERATE INTERMITTENTLY. BECKLEY AUTO MALL (3934 ROBERT C BYRD DR, BECKLEY, WV 25801, (304) 252-3300) STATED THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. THE VEHICLE WAS REPAIRED FOR SEVERAL FAILURES; HOWEVER, THE RUST ISSUE WAS NOT ADDRESSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. *BF UPDATED 9/18/18*JB

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

I DROVE UP TO A STOP LIGHT AND PUSHED THE BRAKES AS USUAL. A BRAKE LINE BURST AND I COASTED THRU THE STOP LIGHT. I USED MY EMERGENCY BRAKE TO STOP. I THINK ALL BRAKE LINES SHOULD BE MADE FROM STAINLESS STEEL UP HERE IN WISCONSIN. THIS DEFINITELY IS A SAFETY ISSUE.

TL* THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 55 MPH IN THE RAIN, THE CONTACT SWITCHED LANES ON A CURVED ROAD AND THE VEHICLE STARTED TO SKID. THE REAR OF THE VEHICLE WAS OUT OF CONTROL. AS A RESULT, THE CONTACT CRASHED INTO A GUARDRAIL AND THEN A MEDIAN. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED NECK INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO AN AUTO COLLISION CENTER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

I HAVE HAD THE BRAKES GO OUT 3 DIFFERENT TIMES ON ME IN THE LAST YEAR. THERE ARE NO SIGNS OF PROBLEMS AND YOU STEP ON THE BRAKES AND A LINE BLOWS. YOU HAVE NO BRAKES PEDDLE GOES TO THE FLOOR AND LITTLE TO NO STOPPING. ONE TIME I WAS COMING DOWN A DIRT ROAD TO A STOP SIGN AND STEPPED ON THE BRAKES AND A LINE BLEW AND THE ABS KICKED IN BECAUSE OF THE DIRT ROAD AND I COULD NOT STOP AND WENT RIGHT THROUGH A INTERSECTION. THEY USED CHEAP LINES, AND NOW PEOPLE IN THE NE WHERE SALT IS USED ARE HAVING PROBLEMS. I COULD HAVE BEEN KILLED.THE LINE RUSTY OUT WHERE THEY BEND AND SALT AND DIRT BUILD UP. THERE IS NO REASON THEY CAN NOT MAKE THESE LINES OUT OF SS OR AS WITH THE NEWER LINES THEY ARE COATED. WHY COME OUT WITH A COAT LINE IF THERE IS NOT A PROBLEM. *TR

EXHAUST MANIFOLD BOLTS ON EACH SIDE OF ENGIN SNAPPED OFF FOR NO APPEARANT REASON / NORMAL USE, BIG CONCERN OF EXAUST FUMES ENTERING THE CAB