2020 GMC SIERRA 1500 Complaints

Number 5 cylinder failure. Engined has failed cylinder is scored causing the engine to miss and lock up. The engine which is a 6.2 l87 is now under investigation for a piston failure causing the engine to lockup. The piston and engine issue has been investigated by my local repair shop and I can provide written and bore scope pictures of the failure. Yes the engine light was on the ESC was disabled and needed replaced and the traction control was disabled also the emergency brake was enabled and then failed

The contact owns a 2020 GMC Sierra 1500. The contact stated while driving 70 MPH, the check engine warning light illuminated, and the vehicle lost motive power. The contact attempted to restart the vehicle however, the vehicle failed to restart. The contact stated that several nearby drivers assisted with pushing the vehicle off the roadway. The contact stated that the first failure occurred the day after the vehicle was purchased. In addition, the contact stated that the failure had also occurred three times within one week. The vehicle was towed to the dealer where the vehicle was purchased. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 123,000.

recently when starting truck brake message alert comes across on dash reading brake error, and not to drive above 45 miles per hour and brakes are NOT totally operational, meaning brake pedal has alot of play in it to bring truck to a stop. Have to turn off vehicle , sometimes repeatedly before it apparently resets computer system. This has now occurred four times in last five months. Events and dash warning message very similar to recall issued 3/3/20, but listed as "complete" on recall data base. Need to seriously and immediately looked into and corrected!

Dear NHTSA, I am filing a complaint against General Motors, LLC (GM) for failing to follow through on a legally binding lemon law settlement and leaving me with an inoperable, unsafe vehicle. Vehicle Information: •Vehicle: 2020 GMC Sierra 1500 •VIN: [XXX] •Date of Purchase: [XXX] •Dealership: Diamond Chevrolet Buick GMC Nature of the Complaint: 1.Vehicle Declared a Lemon: •GM acknowledged that my vehicle was defective and offered a CCP § 998 settlement on April 18, 2024, for $97,000 plus pre-judgment interest. •Despite accepting the offer, GM has failed to facilitate the buyback or repurchase of the vehicle. 2.Ongoing Safety Hazard: •The vehicle is non-operational and poses a safety hazard due to repeated transmission failures, loss of engine power, steering/braking issues, and limp mode activation. •GM’s delay in replacing the vehicle leaves me exposed to ongoing safety concerns. Request for Action: I request that the NHTSA: •Investigate GM’s failure to address and rectify the vehicle’s safety issues. •Document GM’s negligence in resolving safety defects under a recognized Lemon Law claim. •Initiate necessary action to protect consumers from ongoing safety hazards caused by GM’s failure to act. Please contact me for additional information or supporting documentation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At 59000 miles my lifters were rebuilt on the 6.2 liter engine because of a failure in the 1 and 3 piston. Gm paid for the repairs and then At 79000 miles the motor completely blew resulting in complete failure and seizing the motor and heavy metal chips were reportedly found in oil pan. Gm claimed it was a result of me not doing regular oil changes however I suffer from OCD and I am automotive engineer and my oil was changed early in most cases with my truck. Gm will not take responsibility and at the time they wanted $16k to fix my truck. I was going through a very tumultuous divorce and had to pay atty $34k for that wnd could not pay $16k for a new engine resulting in me having to give my truck back to bank and I have not been able to buy a truck or vehicle since then as it ruined my once perfect credit of 820. It’s changed my life forever and GM should take responsibility. I will never buy another GM product again and my father worked for them my whole life and my family only drove their products.

The contact owns a 2020 GMC Sierra 1500. The contact stated while driving 70 MPH, the low oil pressure warning light illuminated. The contact pulled over to the side of the road and noticed that the oil level was abnormally low. The contact added oil to the vehicle and continued driving. The vehicle was taken to Mike's Garage, where it was diagnosed that the valve cover was fractured; however, the part to repair the vehicle was on backorder. The contact related the failure to TSB Number: 22-NA-027. The dealer was notified of the failure and informed the contact that the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 96,000.

The Lifter failure, bent rod, and basically ruined the the cam shaft, the vehicle has had engine replaced and the current engine is now acting up. once again.

Shift to park message appears when in park and engine is turned off. Transmission control had an internal circuit failure. Park not fully engaged and vehicle could roll. Problem confirmed by dealership. Prior recalls for earlier gmc models but not my year.

While driving our 2020 Sierra AT4 down the highway at 65 mph, the engine suddenly cut out and started sputtering. Every light came on. We pulled off the highway and had the truck towed. Our highly trusted, family mechanic company diagnosed lifter 5 was twisted and stuck, along with another stuck lifter. The cost to replace the engine was one hundred dollars more than repairing the two lifters. They purchased a new engine through Van Chevrolet and were surprised the cost had recently decreased from $7-8k to $3900, to purchase a rebuilt engine. The engine appeared to be new, with the bolt threads unused. The new engine comes with a 3year 100k mile warranty through the dealership. We called GM, they said since we went to another mechanic they would not speak with us.

The engine, while driving down the road, incurred a failure to the pusher rod in the #5 cylinder. This occurred at 6750 total miles on engine. Engine failure was repaired by a dealership. The failure occurred again at 99,500 miles to the same #5 cylinder causing major engine damage leading to the replacement of the engine. Our safety was put at risk as the truck decelerated and began vibrating. The second failure occurred and the engine shutdown. These incidents occurred without warning, Yes, a dealer was involved in both incidents. Only a dealership has been involved. The warning occurred after the failure.