2019 GMC SIERRA 1500 Complaints

While I was driving the engine started to lose power on the highway going about 70 mph with my four kids in the car. I had to quickly exit the highway and pull over. I was uncomfortable continuing operating the vehicle and had to get it to the closest GMC dealership which was in Killeen Texas. (Patriot Buick GMC). Upon diagnosis, I was informed that the lifters were damaged and needed to be repaired. Once the technician started the disassembly he noticed that the lifters caused damage to the cam shaft resulting in additional repairs which totaled approximately $8700 in damages/repairs required. I started to research this as the lifters typically do not fail in vehicles that are 80,000 miles or less. While conducting research I noticed that this is a common problem in the GMC Sierra 1500 to the point there is a lawsuit against GMC right now. I am frustrated because I believe that there should be a recall as the safety of my kids and I were put in danger for a part that is commonly failing in this vehicle.

Transmission started fluttering around 60k miles. Per GMC Dealer - this is due to water getting into transmission from fluid put in at the factory. Even though dealer admitted that it's a defect from the factory, the warranty wouldn't cover the repair. This is a well known issue in the 5.3L 8 speed trans.

Engine keeps running out of oil I’ve taken it several times to the dealership sometimes there was no oil in it. Only has 80,000 miles problem started 2 years having it

The contact owns a 2019 GMC Sierra 1500. The contact stated while driving at approximately 20 MPH and making a left turn, the vehicle shook violently. The contact stated that no warning light was illuminated. The contact stopped the vehicle and turned off, and restarted the vehicle. The vehicle was restarted, but after shifting into drive(D), and depressing the accelerator pedal, the vehicle failed to exceed 30 MPH. The contact stated that the vehicle was making an abnormal "roaring" sound. The contact stopped the vehicle and had the vehicle to be towed to the dealer. The dealer diagnosed the vehicle and determined that the valve body on the transmission needed to be replaced; however, the part to complete the repair was on a national back order. The vehicle was not repaired. The manufacturer was informed of the failure. The contact stated that the failure was the second transmission failure. The contact had the transmission replaced in 2024 by the same dealer. The failure mileage was approximately 84,000.

The truck had been parked for about 4 hours, after a 250 mile trip. I cranked it and started driving to return home. I heard an intermittent squealing noise while driving. I had driven only about 2 miles when the engine suddenly shut down in heavy traffic on a four lane divided highway. I managed to get the truck into the median and stop. I was left stranded in the middle of the highway. It turns out the the engine bearing went bad and ruined the engine. I will now have to replace the engine at a cost of about $15,000.00. This is a safety concern when the engine suddenly failed and stalled while driving on a four lane divided highway, in heavy traffic.

ENGINE FAILURE. CAM BEARINGS FAILURE. ENGINE SEIZED UP. SAFETY ISSUE: TRAVELING ON HIGHWAY TOWING A FISHING BOAT. PULLED OFF FOR FUEL. ENGINE COMPLETELY SEIZED UP WHILE AT GAS PUMP. IF IT HAD IT SEIZED UP BEFORE PULLING OFF HIGHWAY FOR GAS, GREAT RISK FOR A CATASTROPHIC CRASH, ESPECIALLY WHEN PULLING A BOAT TRAILER. ALL SYSTEMS INCLUDING STEERING SHUT DOWN. JOHN JONES CHEVROLET DEALERSHIP IN SCOTTSBURG INDIANA RAN DIAGNOSTICS AND CONFIRMED COMPLETE ENGINE FAILURE. FAULTY CAM BEARINGS SEIZED UP. ENGINE IS RUINED AND MUST BE REPLACED. INSPECTION BY JOHN JONES CHEVROLET DEALERSHIP. WE HAD BEEN ON THE HIGHWAY FOR 3.5 HOURS WHEN PULLED OFF FOR GAS. THERE WERE NO WARNING SIGNS. NO CHECK ENGINE LIGHTS, NO LIGHTS AT ALL ON THE DASH. NO UNUSUAL SOUNDS OR SMOKE. NOTHING UNUSUAL BEFORE THE ENGINE SEIZED UP.

valve train/camshaft fairlure which damaged entire engine - happened at 99,650 miles

The passenger side lifters in my truck failed while at idle/5mph speed causing catastrophic engine failure. 2019 6.2L V8 from GM. From my own independent research, and the research/survey of others online, this appears to be a very common problem as a result of known defective parts that were installed on GM engines.

Lifters in engine failed at beginning of March 2025 and destroyed inside of engine. Transmission failed in summer of 2024 and had to be replaced

I was driving down [XXX] near Harrisburg PA in an active construction zone when the truck shut off, the dash blinked a few things very rapidly then went black. I was barely able to coast to an area large enough to get my truck out of the highway traffic. I was stranded on the side of the highway for 4 hrs and due to the construction hardly able to get out of the truck safely as it was around a bend. I’ve had to have the truck towed to a few mechanics to learn that it has suffered a catastrophic engine failure as all cylinders have lost compression. It made no noise at all. There was no signs this was going to happen, just driving normally then a complete engine failure resulting in no compression in all 8 cylinders with no noise. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)