2003 GMC SIERRA 2500 Complaints

I OWN A 2003 GMC DURAMAX 167000 MILES, IT HAS BEEN A GREAT TRUCK UNTIL RECENTLY, AFTER ENGINE GETS HOT IT WILL NOT START BACK UP UNTIL IT HAS COOLED OFF! HAVE NOT BEEN ABLE TO FIND THE PROBLEM YET, BUT FOUND A LOT OF COMPLAINTS ONLINE FROM PEOPLE WITH THE SAME PROBLEM, [INJECTORS], VERY EXPENSIVE TO REPAIR!!! THIS PROBLEM IS VERY FRUSTRATING, WOULD BE GREAT IF GENERAL MOTORS WOULD CORRECT THIS PROBLEM!!!! *TR

TL* THE CONTACT OWNS A 2003 GMC SIERRA 2500 HD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE EVENTUALLY CAME TO A STOP AND WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT BOTH REAR BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. UPDATED 08/12/2014*LJ

WHEN PLACED IN PARK THEN TURNED OFF THE KEY WOULDN'T COME OUT OF THE IGNITION, WHEN PLACED IN DRIVE WHILE RUNNING THE KEY WOULD COME OUT FREELY. *TR

TL* THE CONTACT OWNS A 2003 GMC SIERRA 2500. THE CONTACT STATED THAT THERE WAS A LOSS OF POWER WHILE TRAVELING AT ANY SPEED. THE WARNING LIGHT ILLUMINATED FOR LOSS OF POWER INTERMITTENTLY. THE CONTACT HAD TO DEPRESS THE ACCELERATION PEDAL TO THE FLOORBOARD TO ACCELERATE ON MORE THAN ONE OCCASION BUT TO NO AVAIL. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MORE THAN FIVE TIMES, WHO WAS NOT ABLE TO REPLICATE OR DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE HAD ALSO BEEN TAKEN TO THE DEALER FOR DIAGNOSIS BUT TO NO AVAIL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.

DRIVING TO WORK ONE DAY, A CAR IN FRONT OF ME SUDDENLY STOPPED TO TURN LEFT. I HIT MY BRAKES AND FELT A "POP" AND THE BRAKE PEDDLE WENT STRAIGHT TO THE FLOOR, NO BRAKES. I WAS TRAVELING ABOUT 55 MPH SO AT THAT POINT, I AM A 55 MPH SPEAR ON WHEELS. I SWERVED TO THE RIGHT AND DROVE ACROSS SOMEONE'S DRIVEWAY AND THROUGH THEIR YARD. THIS WEEKEND WAS THE CITY WIDE GARAGE SALES, AND THANKFULLY, THESE FOLKS WERE NOT HAVING A SALE IN THEIR DRIVEWAY OR YARD, OR ELSE THIS COULD HAVE BEEN A TERRIBLE ACCIDENT. THE ONLY RUST ISSUE WITH THIS TRUCK IS THE BRAKE LINES AND FUEL LINES. IF YOUR LINES RUST BEFORE YOUR BODY RUST, THEN I FEEL THERE IS A SERIOUS DESIGN FLAW. IF IT WAS SOMETHING ELSE RUSTING THEN IT WOULDN'T BE AS BIG OF A DEAL. BUT WHEN YOU ARE TALKING BRAKE LINES, IT IS JUST A MATTER OF TIME BEFORE THIS FLAW CAUSES ANOTHER CATASTROPHIC BRAKE FAILURE, LEADING TO AN ACCIDENT INVOLVING SERIOUS INJURY OR DEATH. A 10 YEAR OLD TRUCK SHOULD NOT HAVE THIS PROBLEM. I HAVE OWNED VEHICLES THAT WERE 15, 20 YEARS OLD AND HAVE NEVER HAD TO REPLACE BRAKE LINES. SOMEONE'S LIFE IS WORTH SO MUCH MORE THAN A CHEAPLY MADE BRAKE LINE. *TR

I WAS DRIVING MY 03 SIERRA, APPROACHING A STOPLIGHT AT A BUSY INTERSECTION WHEN I APPLIED THE BRAKES. THE TRUCK BEGAN TO SLOW AT FIRST BUT THEN THE PEDDLE IMMEDIATELY WENT COMPLETELY TO THE FLOOR. I BEGAN TO PUMP IT BUT THERE WAS NO RESPONSE. I WAS HEADING TOWARD THE INTERSECTION, THE LIGHT WAS RED, WITH BUSY CROSS TRAFFIC. THE STREET I WAS ON IS NARROW AND STEEP AND I BEGAN TO PICK UP SPEED. I SHIFTED THE TRANS INTO THE LOWEST GEAR AND STEPPED ON THE EMERGENCY BRAKE. THE TRUCK FINALLY CAME TO A STOP IN THE MIDDLE OF THE INTERSECTION, AS ONCOMING CARS LUCKILY AVOIDED HITTING ME. WHEN I WENT TO MY MECHANIC TO ARRANGE TO HAVE THE TRUCK TOWED, HE KNEW IMMEDIATELY WHAT THE PROBLEM WAS. HE TOLD ME, SIGHT UNSEEN, THAT THE BRAKE LINE UNDER THE DRIVER'S SIDE HAD RUPTURED. LATER, UPON INSPECTION, HE WAS CORRECT. HE ALSO TOLD ME THAT THIS WAS A VERY COMMON PROBLEM WITH THAT YEAR. HE REPLACED THE LINE AND I THOUGHT THAT HAD SOLVED THE PROBLEM; UNTIL TWO DAYS AGO. AGAIN, I AM DRIVING DOWN A HILL AND THE SAME THING HAPPENED. I WAS TOWING A VERY LARGE TRAILER THIS TIME AND THE EMERGENCY BRAKE HAD LITTLE AFFECT. LUCKILY, THERE WAS LITTLE TRAFFIC AND I WAS ABLE TO RIDE IT OUT WITHOUT INCIDENT. I HAVE SINCE DISCOVERED THAT THIS IS A PROBLEM WITH NOT ONLY THE 03 YEAR BUT 4 OR 5 YEARS PRIOR ALSO. ANOTHER MECHANIC TOLD ME THAT THE ENTIRE SYSTEM OF LINES SHOULD BE REPLACED SINCE GM USED A UNCOATED STEEL WHICH BEGINS TO BE COMPROMISED WITHIN JUST A FEW YEARS WHERE SALT IS HEAVILY USED IN THIS AREA. IT IS OBVIOUS THAT GM USED UNCOATED STEEL INSTEAD OF COATED OR STAINLESS TO SAVE A FEW DOLLARS. HAD MY 17 YEAR OLD SON BEEN DRIVING, THE OUTCOME COULD HAVE BEEN DISASTROUS. THIS IS ONLY ONE OF MANY PROBLEMS I HAVE HAD WITH THIS TRUCK. ANOTHER IS ERRONEOUS SPEEDOMETER READINGS. I WILL ADDRESS THESE IN ANOTHER POST. *TR

ISSUE WITH THROTTLE BODY REDUCED ENGINE POWER WHEN DRIVING THROWS OUT CHECK ENGINE LIGHT. THOUSAND OF PEOPLE HAVE THIS SAME ISSUE MOST HAVE JUST STOPPED DRIVING THEIR VEHICLE LIKE I HAVE BECAUSE IT'S UNSAFE TO DRIVE. I HOPING NOT JUST FOR ME BUT EVERYONE OUT THERE WITH THIS SAME ISSUE TO GET A RECALL BEFORE IT KILLS SOMEONE. I HAVEN'T BEEN ABLE TO DRIVE MY TRUCK IN THREE YEARS. *TR

I WAS DRIVING DOWN THE ROAD WHEN MY BRAKE PEDDLE WENT TO THE FLOOR, I HAD TO USE MY EMERGENCY BRAKE TO STOP MY VEHICLE. LUCKILY I SWERVED TO AVOID TRAFFIC IN FRONT OF ME AND WAS ABLE TO STOP SAFELY. UPON HAVING MY TRUCK TOWED, MY MECHANIC SHOWED ME THAT MY BRAKE LINE FROM MY MASTER CYLINDER HAD RUSTED OUT CAUSING BRAKE FAILURE. *TR

TL* THE CONTACT OWNS A 2003 GMC SIERRA 2500 HD. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

I CROSS THE ROUTE 18 ON MASSACHUSETTS WHEN THE BRAKE IS COMPLETELY GONE ALMOST INVOLVED IN ACCIDENT. *TR