2005 GMC SIERRA 2500 Complaints

TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500-HD. THE CONTACT STATED DURING A ROUTINE MAINTENANCE APPOINTMENT THE MECHANIC STATED THE POWER STEERING HOSE WAS LEAKING WHICH CAUSED HIM TO LOOSE POWER STEERING AND POWER BRAKING ABILITY. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT NHTSA RECALL CAMPAIGN ID NUMBER: 05V455000: STEERING: HYDRAULIC POWER ASSISTS: HOSE, PIPING, AND CONNECTIONS WAS RELATED TO THE FAILURE; HOWEVER, HIS VIN WAS NOT INCLUDED AND HE WOULD HAVE TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED BUT STATED THERE WAS A RECALL BUT HIS VIN WAS NOT INCLUDED; THEREFORE, IT WOULD BE AT HIS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 116,000.

DRIVING THROUGH AN INTERSECTION AT 40 WHEN A ANOTHER VEHICLE MADE A LEFT TURN IN FRONT OF ME . I APPLIED MY BRAKES AND PEDAL WENT TO THE FLOOR . I SWERVED AND AVOIDED THE ON COMING VEHICLE . THE REAR HARD STEEL BRAKE LINE ABOVE THE FUEL TANK BURST DUE TO CORROSION . NO WARNING NO FLUID OR BRAKE LIGHT JUST A CATASTROPHE FAILURE OF LINE. UPON INSPECTION LINE IS NOT CORRODED ON THE FRAME RAIL BEFORE THE FUEL TANK JUST BEHIND THE TANK. *TR

DEPRESSED BRAKE PEDAL TO STOP TRUCK AND PEDAL WENT STRAIGHT TO THE FLOOR. FRONT BRAKE LINES HAD RUPTURED DUE TO CORROSION. THIS TRUCK IS MY MAIN TOW VEHICLE AND I HAD A SMALL TRAILER ON WHEN THIS OCCURRED. MY TRUCK HAS NOT SEEN MUCH WINTER USE SINCE NEW AND I AM THE OWNER SINCE NEW. *TR

WHILE DRIVING DOWN A COUNTRY ROAD IN MY PICKUP TRUCK MY BRAKE LINES FAILED IN 2 SPOTS DUE TO RUST AND CORROSION. I WAS PULLING A TRAILER ALSO. VERY VERY DANGEROUS. LUCKY TO HAVE ACTED SO FAST IN USING THE EMERGENCY BRAKE. *TR

TL* THE CONTACT OWNS A 2005 GMC SIERRA 3500. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE BRAKES WERE ENGAGED AND THE VEHICLE FAILED TO STOP. THE CONTACT MENTIONED THAT HE HAD TO ENGAGE THE EMERGENCY BRAKE IN ORDER FOR THE VEHICLE TO STOP. ALSO, THE CONTACT STATED THAT AFTER INSPECTING THE VEHICLE HE NOTICED OIL LEAKING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 42,000. UPDATED 10/24/12 *CN UPDATED 11/08/12

THE 2005 GMC 2500HD FWD (WELL MAINTAINED AND OILED TO PREVENT CORROSION) EXPERIENCED A FAILURE WHILE TOWING MY 24' PURSUIT FISHING BOAT (7200 LBS.) HOME FROM STURGEON POINT MARINA TO HAMBURG, NY 14075 (APPROXIMATELY 10 MILES) WITH "MINIMAL" STOPPING CAPABILITY AS THE DOT 3 BRAKE FLUID WAS BEING EXPELLED. I HAD TO FEATURE THE THROTTLE TO NEGOTIATE STOPPING SENARIOS WITHOUT ISSUE. AS OF 8/20/12, THIS VEHICLE IS WITH FUCCILLO CHEVROLET, INC. (GRAND ISLAND, NY) FOR OVERHAUL OF ENTIRE BRAKING SYSTEM; INCLUDING FUEL LINES. THE CERTIFIED TECHNICIAN SUGGESTED THE ENTIRE BRAKE LINES SYSTEM BE REPLACED ALONG WITH THE FUEL LINES DUE TO EXTREME CORROSION. ALL THIS WORK IS BEING PERFORMED SINCE THE EXCELLENT CONDITION OF THE VEHICLE.THE ESTIMATE FOR THIS WORK IS APPROXIMATELY $2250 TO REPLACE ALL LINES (BRAKE / GAS) AFFECTED BY SEVERE CORROSION. THIS CONDITION IS A RESULT OF POOR MATERIAL SELECTION NOT CAPABLE OF WITHSTANDING NORMAL WINTER CONDITIONS FOUND IN THE NORTHEAST. THE SAME STANDARDS SHOULD BE USED AS SELECTING EXHAUST SYSTEM MATERIAL. BRAKES CAN KILL YOU....EXHAUST SYSTEMS CAN NOT! FINAL NOTE: TRUCK DRIVEN 50 MILES PER WEEK TO WORK (10 MILES EACH DAY). DURING WINTER MONTHS, THE RESIDUAL SALT IS RINSED AS REQUIRED ON A WEEKLY BASIS (OR SOONER) TO PREVENT CORROSION. THIS TRUCK PRIOR TO WINTER DRIVING HAS HAD OIL APPLIED TO THE UNDERFRAME, APPARENTLY, THE BRAKE / FUEL LINE WHERE NOT ADEQUATELY TREATED. *TR

BRAKE PEDAL WENT TO THE FLOOR. INSPECTION DISCOVERED THAT ALL THE VEHICLE BRAKE LINES WERE RUSTED, SOME TO THE POINT OF LEAKING BRAKE FLUID. *TR

TL* THE CONTACT OWNS A 2005 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE SPEEDOMETER WOULD NOT PROVIDE ACCURATE SPEED RATES. THE SPEEDOMETER WOULD READ THAT THE CONTACT WAS TRAVELING 120 MPH WHEN THE CONTACT WAS ACTUALLY TRAVELING 60 MPH. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR INSPECTION OR REPAIRS. THE CURRENT MILEAGE WAS 102,000 AND THE FAILURE MILEAGE WAS UNKNOWN.

I HAVE A 2005 GMC SIERRA 2500HD CREW CAB 4X4 WITH THE 6.0 ENGINE AND 5 SPEED MANUAL TRANSMISSION. EVERYTIME I COME TO A SLOW STOP THE ABS UNIT ENGAGES AND REDUCES PEDAL PRESSURE, CAUSING THE BRAKE POWER TO FADE AND INCREASING THE DISTANCE OF MY STOP. *TR

TL* THE CONTACT OWNS A 2003 GMC SIERRA 2500 HD. THE CONTACT STATED THAT THE POWER STEERING WOULD SEIZE AND THE VEHICLE WOULD HESITATE TO STOP WHEN THE BRAKES WERE DEPRESSED. IN ADDITION, THE TRANSMISSION, WINDSHIELD WIPERS, CRUISE CONTROL, AND THE INSTRUMENT CLUSTER FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE TRANSMISSION, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 29 AND THE CURRENT MILEAGE WAS 100,000.