2002 GMC YUKON Complaints

TL* THE CONTACT OWNS A 2002 GMC YUKON. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, HE CRASHED INTO THE PASSENGER'S SIDE OF ANOTHER VEHICLE AND THE AIR BAGS FILED TO DEPLOY WITH THE IMPACT. IN ADDITION, THE SEAT BELT FAILED TO SECURE AS DESIGNED. THE CONTACT SUSTAINED A BRUISED RIB AND AN INJURY TO THE LEFT LEG. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A SALVAGE FACILITY. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATELY FAILURE MILEAGE WAS 142,000.

HIT BRAKES, STARTED TO SLOW THEN PEDDLE DROPPED, NO WARNING LIGHT . PEDDLE SANK TO FLOOR ,PUMPED PEDDLE TO STOP, HIT LIGHTPOLE AFTER WHICH BRAKE WARNING LIGHT CAME ON . ON INSPECTION ,BRAKE LINE BETWEEN ABS BOX AND REAR AXLE BADLY RUSTED , FAILED AT POINT ABOVE CROSSMEMBER ,IN FRONT OF GAS TANK. HAVE HAD ABOUT 16 CARS ,NEVER SAW LINE RUST THIS BAD ON A CAR LESS THEN 20 YEARS OLD. *TR

PURCHASED A NEW 2002 GMC YUKON XL, AT ABOUT 6800 MILES THE STEERING DEVELOPED A RATTLE, DEALER UNDER WARRANTY REGREASED THE STEERING SHAFT, THIS HELPED FOR A ABOUT A YEAR AND IT STARTED AGAIN. DEALER RE-GREASED WITH WHAT THEY SAID WAS A NEW GREASE THAT SHOULD SOLVE THE RATTLE PROBLEM. IT HAS STARTED THE RATTLE AGAIN AND ONLY HAS 38000 MILES. I UNDERSTAND THERE IS A REDESIGNED STEERING SHAFT THAT SOLVES THIS RATTLE PROBLEM. HERE IS THE BULLETIN TO SOLVE THE POOR SHAFT DESIGN, SHOULD BE A RECALL BUT LOOKS LIKE GM IS ONLY REPLACING ON A CASE BY CASE ISSUE WAITING FOR YOUR WARRANTY TO BE OUT, AT WHICH TIME THEY CHARGE YOU FOR THE POOR DESIGN STEERING SHAFT. GMC TECH BULLETIN 00-02-35-003M (LATEST REVISION) SUBJECT: CLUNKING NOISE UNDER HOOD AND CAN BE FELT IN STEERING WHEEL AND/OR STEERING COLUMN (REPLACE UPPER INTERMEDIATE STEERING SHAFT (I-SHAFT) ASSEMBLY) #00-02-35-003M - (01/31/2007) MODELS: 2002-2006 CADILLAC ESCALADE MODELS 1999-2007 CHEVROLET SILVERADO MODELS (CLASSIC) 2000-2006 CHEVROLET SUBURBAN, TAHOE MODELS 2002-2006 CHEVROLET AVALANCHE 1999-2007 GMC SIERRA MODELS (CLASSIC) 2000-2006 GMC YUKON, YUKON XL MODELS 2003-2006 HUMMER H2 . *TR

2002 GMC YUKON SUFFERED MULTIPLE BRAKELINE FAILURES DUE TO CORROSION. REAR BRAKE LINES RUNNING ALONG THE AXLE WERE ORIGINALLY REPLACED UPON VISUAL INSPECTION. THE REAR MAIN LINE FROM THE ABS MODULATOR FAILED SHORTLY AFTER FROM A CORROSION INDUCED LEAK WHERE THE LINE PASSES OVER THE FUEL TANK. THE FRONT LINES WERE SCHEDULED FOR REPLACEMENT AS A PRECAUTION BUT FAILED PRIOR TO REPAIR WHERE THE LINE PASSES OVER THE RADIATOR BRACE. ALL BRAKE LINES AND FUEL LINES SHOW SIGNIFICANT CORROSION DAMAGE. *TR

STEPPED ON BRAKE PEDAL AND BRAKES FAILED TO STOP VEHICLE. INSPECTED VEHICLE AND NOTICED RUSTED BRAKE LINES FAILED.I AM THE ORIGINAL OWNER OF THIS VEHICLE. *TR

I WAS EXITING THE FREEWAY AND STARTED TO BRAKE AND THEN THE PEDAL WENT TO THE FLOOR. I HAD THE STAND ON IT TO SLOW DOWN ENOUGH TO KEEP FROM HITTING THE CAR IN FRONT OF ME. UPON EXAMINATION OF THE VEHICLE I FOUND A RUPTURED BRAKE LINE. FURTHER REVIEW FOUND ALL 4 LINES 8 INCHES BELOW THE MASTER CYLINDER AND LOWER SERIOUSLY CORRODED. FLUID RESERVOIR WAS STILL FULL OF FLUID. THE LINE BROKE OUT UNDER THE CARRIAGE, FRONT DRIVER SIDE, JUST BEHIND THE FRONT WHEEL WELL. PICTURES ARE AVAILABLE OF THE CORRODED LINES. *TR

TL* THE CONTACT OWNS A 2002 GMC YUKON WITH MICHELIN TIRES, SIZE: 265/70/R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE REAR PASSENGER'S SIDE TIRE BLEW WITHOUT WARNING. THE VEHICLE WAS TAKEN TO MICHELIN FOR DIAGNOSIS BUT THEY WERE UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 8,000.

BRAKE PEDAL WENT TO THE FLOOR WHEN APPLIED AT 30 MPH. ALL LINES AND HOSES WERE SEVERELY CORRODED, NOT MERELY SURFACE RUSTED. BRAKE HOSE NUTS RUSTED TO CALIPERS, COULD NOT BE REMOVED, REQUIRING 2 CALIPERS TO BE REPLACED. *TR

THIS INVOLVES THE EMERGENCY BRAKE THAT WILL NOT HOLD THE VEHICLE WHEN APPLIED. I HAD NOTICED THAT THE EMERGENCY BRAKE DID NOT DO A VERY GOOD JOB HOLDING THE VEHICLE WHEN APPLIED FROM THE TIME IT WAS NEW BUT HAD NOT GIVEN IT MUCH THOUGHT SINCE I NEVER USED IT. SEVERAL YEARS LATER I TRIED TO GET IT INSPECTED AND IT FAILED. I FOUND THAT THE REAR EMERGENCY BRAKE THAT II NEVER USE WERE HAD WORN OUT SHOES AND HAD DAMAGED THE DRUM. I REPLACED THE SHOES AND ONE DRUM AND WAS ABLE TO GET THE BRAKES TO HOLD WHEN THE BRAKE WERE APPLIED. THE BRAKE HAS BEEN APPLIED PROPERLY SENSE THEN BUT STARTED TO DO THE SAME THING AGAIN BY NOT HOLDING THE VEHICLE. I HAD TO REPLACE THE SHOES AGAIN AT 172,000 MILES. THIS SEEMS TO BE A PROBLEM WITH THIS VEHICLE THAT GENERAL MOTORS WILL NOT ADDRESS. *TR

WHILE PULLING OUT OF DRIVEWAY, I PUSHED BRAKE BEFORE ENTERING STREET - PUSHED ALL THE WAY DOWN, BUT HAD NO BRAKE ACTION. WAS BRAKING FINE DAY BEFORE. *TR