2001 HONDA CR-V Complaints

I HAVE NOTICED THAT THE POLYMER HEADLIGHT OUTER SURFACE/LENS OF MY 2001 HONDA CRV HAS STARTED TO DISCOLOR/HAZE/CRAZE THUS REDUCING THE ILLUMINATION OF THE ROAD WAY. I HAVE NOTICED THIS SAME CONDITION WITH NUMEROUS OTHER VEHICLES BOTH FOREIGN AND DOMESTIC. IS THERE A REQUIREMENT THAT THE MATERIALS USED FOR HEADLIGHT LENSES ( AS WELL AS THE INTERNAL REFLECTORS ) BE ABLE TO REMAIN CLEAR FOR ANY PARTICULAR NUMBER OF YEARS/MILEAGE? SHOULD DEALERS/SERVICE SHOPS/SMOG CHECK SHOPS/LAW ENFORCEMENT AGENCIES/ETC. MONITOR VEHICLES AND NOTIFY THE DRIVERS/OWNERS THAT THE LENSES HAVE DETERIORATED TO A DEGREE THAT THEY MAY BE CONSIDERED A SAFETY HAZARD AND SHOULD/MUST BE REPLACED? IF THERE ARE CERTIFICATION OF DURABILITY/MINIMUM USEFUL LIFETIME REQUIREMENTS PLACED ON EQUIPMENT/VEHICLE MANUFACTURERS; AND THESE LENSES ARE NOT MEETING THEM, SHOULD DEALERS ETC. BE REQUIRED TO REPLACE THEM WITH MORE DURABLE VERSIONS? A SUGGESTED INVESTIGATIVE STARTING POINT WOULD BE TO LOOK AT YOUR OWN HEADLIGHT LENSES AND THOSE OF OTHER VEHICLES YOU PASS ON THE ROADS. *TR

2001 HONDA CR-V SE CHECK ENGINE LIGHT WENT ON, IDLE BECAME EXTREMELY ROUGH AND STALLING WHILE DRIVING. NOTHING UNUSUAL PRECEDED THIS INCIDENT. TOOK THE CAR INTO TO BE DIAGNOSED AND WAS TOLD THE 4TH CYLINDER WAS ONLY HOLDING 15-20% OF REQUIRED PRESSURE, IT HAD GONE SOFT. RESEARCHED ISSUE AND FOUND HONDA HAS ISSUED A TECHNICAL SERVICE BULLETIN #03038 REGARDING THIS PROBLEM. IT IS A KNOWN DEFECT IN THE HONDA CR-V AS THE HONDA MAINTENANCE GUIDE DOES NOT RECOMMEND ANY VALVE MAINTENANCE UNTIL 105,000 MILES. HOWEVER, IT HAS BEEN FOUND THAT THE ENGINE'S HIGH COMPRESSION RATE CAUSES THE VALVES TO WARP AND BECOME SOFT UNLESS THEY ARE ADJUSTED EVERY 30,000-35,000 MILES. HAVE BEEN IN CONTACT WITH HONDA AND ALL THEY ARE WILLING TO DO IS SPLIT THE COST 50/50 OF THIS MAJOR REPAIR, OVER $3,000. THEY ARE MANY DOCUMENTED CASES OF THIS OCCURRING WITH THE 1999-2001 HONDA CR-VS THAT USE THE B210Z ENGINE. *TR

I HAVE A 2001 HONDA CRV SE 4WD WITH 63K MILES. THREE YEARS AGO AT 30K MILES THE STEERING WHEEL STARTED TO MAKE SOME KIND OF RUBBING NOISE WHEN PULLING OUT OF PARKING. IT SOUNDED LIKE METAL TOUCHING METAL. I BROUGHT IT BACK TO POWAY HONDA DEALER BUT THEY REFUSED TO TAKE IT SERIOUSLY BECAUSE THEY WERE NOT ABLE TO REPRODUCE THE PROBLEM. I'VE BEEN HAVING THIS NOISE EVER SINCE. *TR

TL*THE CONTACT OWNS A 2001 HONDA CR-V. WHILE DRIVING 55 MPH, THE VEHICLE BEGAN TO SHUTTER AND SHAKE. UPON STOPPING THE VEHICLE, THE CONTACT OBSERVED THE TIRE TREAD PEELING FROM THE TIRE. THE TIRE DID NOT FLATTEN. THE TIRE WAS A BRIDGESTONE DUELER 684, SIZE 205/70R15. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 50,000.

TL*THE CONTACT OWNS A 2001 HONDA CR-V. THE CONTACT ATTEMPTED TO START THE VEHICLE AND IT STALLED. SHE DEPRESSED THE ACCELERATOR PEDAL ALL THE WAY DOWN TO THE FLOOR TO RESTART THE VEHICLE. THE VEHICLE RESTARTED AFTER TWO TO THREE ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADJUSTED THE HEADS IN THE ENGINE. THE CONTACT STATED THAT SHE WAS NOT NOTIFIED OF THE TECHNICAL SERVICE BULLETIN REGARDING THE ENGINE. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 109,000 AND FAILURE MILEAGE WAS 96,000.

CHECK ENGINE CAME ON AT 76,000 MILES. ACCORDING TO DEALER THE EXHAUST VALES BURNT INTO CYLINDER HEAD, #4 CYLINDER WAS AT 25 PSI. ACCORDING TO DEALER THIS HAPPEN BEFORE TO THIS VEHICLE. *NM

TL*- THE CONTACT STATED THAT ON 12/29/06 WHILE DRIVING ON A CLEAR DAY AT 70 MPH SHE HIT THE BACK OF ANOTHER VEHICLE. THE CONTACT STATED THAT VEHICLE IN FRONT OF HER APPLIED THE BRAKES AND SHE DID THE SAME THING. THE CONTACT STATED THAT THE ABS BRAKES DIDN'T PROPERLY WORK AND SHE HIT THE BACK OF THE OTHER VEHICLE. THE CONTACT STATED THAT WHEN SHE APPLIED THE BRAKES THEY FAILED ,AND THE PEDAL WENT TO THE FLOOR WITHOUT RESISTANCE. THE CONTACT SMELL EDSMOKE AND RUBBER. THE CONTACT STATED THAT THE POLICE WAS CALLED, AND WHILE WAITING FOR A POLICE OFFICE SHE DID APPLY THE FOOT TO THE BRAKES AND THE PEDAL WAS STUCK IN THE SAME POSITION FROM THE CRASH. AFTER THE POLICE TOOK THE REPORT, THEY STARTED THE VEHICLE AND THE BRAKES DID GO BACK TO ITS PROPER POSITION.AK

EVENTS LEADING UP TO FAILURE: ENGINE RUNNING POOR FAILURE: BURNT VALVES, LOST 1 CYLINDER, 2 VALVES CORRECTION: REBUILT HEAD AND DO VALVE ADJUSTMENTS SOONER THAN MAINTENANCE RECORDS REQUIRE AND $1,500 IN REPAIRS PLUS RENTAL CAR COSTS. *NM

ROUGH IDLE, ENGINE WOULD STUMBLE BUT RECOVER SEVERAL TIMES WHEN IDLING BEFORE FULLY WARMED UP, POOR FUEL MILEAGE. NO MIL (CHECK ENGINE LIGHT), AND NO CODES OR PENDING CODES DETECTED. DEALER TESTED AND STRONGLY RECOMMENDED VALVE ADJUSTMENT. ONLY 63K MILES ON IT AND VALVES WERE NOT NOISY. OWNER'S MANUAL STATES, "ADJUST VALVES AT 105, 000 MILES OR IF NOISY". NEITHER WERE TRUE. I RESEARCHED CR-V MESSAGE BOARDS AND FOUND LOTS OF "1ST GEN." CR-V'S (MAINLY FROM '99 TO '01) WERE HAVING PROBLEM WHEREBY SOME VALVE SEATS WERE RECEDING INTO CYLINDER HEAD CAUSING NEED FOR PREMATURE VALVE ADJUSTMENTS, BURNT EXHAUST VALVES, OR SOME EVEN NEEDING TO REPLACE CYLINDER HEAD. MOST PEOPLE WHO HAD THE MORE SEVERE PROBLEMS ALSO EXPERIENCED MIL LIGHTING UP & CODE INDICATING ENGINE MISFIRE. I CALLED AMERICAN HONDA CORP SEVERAL TIMES. THE 1ST TIME WAS LIKE PULLING TEETH TO GET THEM TO ADMIT THEY KNEW ABOUT THIS ISSUE, AND THE CORRESPONDING TSB (SERVICE BULLETIN) SENT TO DEALERS. THEY FINALLY ADMITTED IT. BUT AFTER REVIEWING MY CASE TWICE, BOTH TIMES THEY REFUSED TO REIMBURSE ME FOR THE VALVE ADJUSTMENT. THEY CLAIMED: 1) DEALERS ARE FRANCHISED & HAVE NOTHING TO DO WITH THEM, 2) IT'S A MACHINE, AND MACHINES NEED ADJUSTING FROM TIME TO TIME, 3) I DIDN'T PURCHASE EXTENDED WARRANTY SO THEY CAN'T HELP ME, 4) MAINTENANCE SCHEDULE IN THE OWNER'S MANUAL IS JUST A GENERAL GUIDELINE, VALVES SHOULD BE ADJUSTED SOONER, AND 5) SHOULD I REQUIRE CYLINDER HEAD REPLACEMENT IN THE FUTURE, THEY MIGHT OFFER ME SOME KIND OF RESTITUTION, BUT NO GUARANTEES. ENGINE RUNS FINE NOW AFTER VALVE ADJUSTMENT, BUT WHO'S TO SAY IN ANOTHER 10 TO 30K IT WON'T NEED IT AGAIN, PERHAPS ONLY TO FIND OUT IT'S TOO FAR OUT OF SPEC & WILL NEED NEW CYL. HEAD! IT'S PRINTED CLEARLY, IN BLACK & WHITE IN OWNER'S MANUAL: "ADJUST VALVES AT 105,000 MILES OR IF NOISY". PERHAPS WE SHOULD START CLASS ACTION SUIT AGAINST HONDA. THEY NEED TO STAND BEHIND THEIR PRODUCT, REDESIGN THE CYL. HEADS AND DO A RECALL! BUYERS BEWARE! *NM

I WAS INVOLVED IN A ROLLOVER ACCIDENT IN NOV. OF 2005 AND I WAS DRIVING A HONDA CRV 2001. THE AIRBAGS DID NOT DEPLOY DURING THE ACCIDENT OR AFTER. THE VEHICLE ROLLED SEVERAL TIMES AND THERE WAS OVER 100 FEET OF DEBRIS. WHY DIDN'T THE AIR BAGS DEPLOY? THE CRV WAS A TOTAL LOSS. *JB