2001 HONDA GL1800 Complaints

DT*: THE CONTACT STATED WHILE TRAVELING 40 MPH, THE MOTORCYCLE STALLED SUDDENLY WITHOUT WARNING. THE DEALERSHIP DETERMINED THE FUEL INJECTOR FAILED WHICH CAUSED THE FUEL PUMP TO SHUT DOWN AUTOMATICALLY. THE DEALERSHIP INFORMED THE CONTACT AN FI LIGHT WAS SUPPOSED TO ILLUMINATE ON THE MOTORCYCLE PRIOR TO FAILURE OF THE FUEL INJECTOR; HOWEVER THE CONTACT DID NOT NOTICE A LIGHT ILLUMINATED.

2001 GL1800 GOLDWING ENGINE SURGES FROM 1500 RPM TO 1000 RPM AND CONTINUES TO OSCILLATE UP AND DOWN UNTIL THE THROTTLE IS RELEASED OR RPM IS RAISED ABOVE 1500. *TS THE CONSUMER INDICATED THAT THE PROBLEM STARTED AFTER SERVICE BULLETIN 1800A13 WAS COMPLETED. THE SB WAS FOR AN OVERHEATING PROBLEM THAT THE EARLIER GL1800'S HAD. *NM UPDATED 04/21/06.

MY 2001 HONDA GL1800 HAS A SURGING PROBLEM WHEN ENGINE RPM IS 1400-1500 IN ANY GEAR OR JUST STANDING STILL. AT A STAND STILL IF THE THROTTLE IS HELD AT 1400-1500 RPM THE ENGINE WILL OSCILLATE BETWEEN 1000 AND 1500 RPM UNTIL THE THROTTLE IS RELEASED. WHILE DRIVING AT THIS RPM IN ANY GEAR THIS PROBLEM WILL CAUSE THE SUDDEN LOSE OF ENGINE RPM AND THEN A SURGE BACK CAUSING A DANGEROUS SITUATION ESPECIALLY WHEN RIDING 2 UP. IT ALL STARTED AFTER THE ECM WAS UPDATED (10/01/03) FOR AN OVERHEATING PROBLEM (RECALL). HONDA IS AWARE OF THE PROBLEM BUT THEY ARE DRAGGING THEIR FEET JUST AS THEY DID WITH THE OVERHEATING PROBLEM. THIS IS A SAFETY PROBLEM. *JB

REAR SUSPENSION NOT SETTING IN FULL RANGE. WAS REPLACED ONCE BY HONDA WARRANTY 2-2-05 AND AM NOW BEING TOLD THAT THE SAME SYMPTOMS ARE NOW CONSIDERED NORMAL. HAVE LOST OVER 25% OF SUSPENSION ADJ RANGE. HONDA NOW REFUSES TO COVER UNDER WARRANTY. *JB

THERE IS A NOTICEABLE WOBBLE IN THE FRONT END OF MY 2001 HONDA GL1800 AT APPROXIMATELY 45 MPH. IT WASN'T THERE WITH THE FIRST TIRE I HAD, DUNLOP. IT HAS BECOME PROGRESSIVELY WORSE AS THE FRONT TIRE AGES. THIS IS SUBMITTED IN SUPPORT OF ODI#10135765. *NM

THE ANTI-DRIVE SYSTEM IS MAL-FUNCTIONING & HYDRAULICALLY LOCKING THE LEFT FRONT FORK SHOCK. THIS IS ALLOWS THE SHOCK TO OVER PRESSURE & FAIL THE SEALING LIP SEAL. THE OIL THEN IS PUMPED OUT DURING THE SHOCK OPERATION & THE OIL IS COVERING THE FRONT BRAKES & TIRES. THIS CREATES A LOSS OF TRACTION FROM THE OIL COVERED TIRES & LIMITED BRAKING DUE TO THE OIL CONTAMINATED BRAKES. PERSONALLY I HAVE HAD TWO EXACTLY THE SAME LEFT FRONT SHOCK SEAL FAILURES. #1 FAILURE THE MOTORCYCLE SLIPPED & LAID DOWN ON THE GARAGE FLOOR WHEN STOPPING. #2 FAILURE THE MOTORCYCLE HAD THE BRAKES COVER WITH OIL AT A SPEED OF 70 MPH, & I NOTICED AN INCREASE IN THE STOPPING DISTANCE & HAD TO USE "DOWN SHIFTING" TO AID IN THE STOPPING. HONDA IS ONLY REPLACING THE LIP SEAL, NOT REPLACING THE BRAKE PADS, & GIVING THE MOTORCYCLE BACK TO MYSELF WITH REDUCED BRAKING. ALSO, HONDA IS NOT LOOKING INTO THE "ROOT CAUSE" OF THESE FAILURES.

WHILE DRIVING ON INTERSTATE 10 IN TEXAS I DROVE ON A ROUGH AREA OF THE PAVEMENT. I THEN NOTICED OIL COMING FROM THE FRONT LEFT FORK SHOCK SEAL. THE OIL WAS BEING "PUMPED OUT" THROUGH THE SHOCK OIL SEAL THAT FAILED. OIL WAS BEING SPRAYED INTO THE RADIATOR, WINDSCREEN, INSTRUMENT PANEL,ENGINE, FRONT BRAKES & TIRES. I EXITED THE INTERSTATE & AS I ATTEMPTED TO STOP I NOTICED THE OIL COVERED BRAKES DID NOT ALLOW THE MOTORCYCLE TO STOP IN A SAFE STOPPING DISTANCE. I USED THE GEAR DOWN SHIFTING TO AID IN STOPPING THE MOTORCYCLE. THE MOTORCYCLE IS CURRENTLY AT PASADENA HONDA SERVICE FOR INSPECTION & TO CONVERSE W/ THE AMERICA DIVISION HONDA TECH ON RESPONSIBILITY FOR FAILURE. BEFORE I LEFT THE MOTORCYCLE WITH THE HONDA SERVICE, I REMOVED THE DUST COVER THAT IS COVERING THE FAILED OIL SEAL & FOUND A PORTION OF THE LIP ON THE OIL SEAL FOLDED OUTWARD. I HAVE SEVERAL PHOTOS OF THE FAILED SEAL. WHEN EXERCISING THE SHOCK, OIL WOULD PUMP OUT OF THIS AREA. **THIS IS THE SECOND FAILURE ON THE EXACT LEFT FRONT FORK SHOCK SEAL FAILURE, AS A POSSIBLE ANTI-DIVE MALFUNCTION. THIS MAY ALLOW THE LEFT SHOCK TO OVER PRESSURE & FORCE THE RUBBER LIP SEAL TO ROLL OUTWARD & LOOSING THE CAPACITY. THE LAST FAILURE WAS IN JUNE 2004. HONDA DID NOT/ WOULD NOT COVER THE FIRST FAILURE UNDER WARRANTY. SEARCHING THE INTERNET I FIND THAT THERE ARE MANY LEFT FRONT FORK SHOCK FAILURES HAPPENING. *JB

2001 HONDA GL1800 GOLDWING MOTORCYCLE. WHILE IN TRAFFIC, APPLIED FRONT BRAKE SEVERAL TIMES AGGRESSIVELY. SPEEDS WERE 20-30 MPH. UN-KNOWING THAT THE LEFT FRONT FORK SHOCK SEAL FAILED, AFTER THE BRAKING IN TRAFFIC, & OIL WAS PUSHED OUT OF THE FORK SHOCK. THE OIL COVERED THE FRONT TIRE & BRAKE. PULLING INTO THE GARAGE, WHEN I APPLIED THE BRAKE THE FRONT TIRE LOST TRACTION, DUE TO THE OIL ON THE TIRE, & THE MOTORCYCLE SLIPPED & LANDED ON IT'S SIDE. THE REPAIR SHOP REPLACED ONLY THE LEFT FRONT FORK SHOCK SEAL. THEY SHOWED ME THE OLD SEAL & THERE WAS NO DAMAGE. I BELIEVE THAT THE MOTORCYCLES FRONT SUSPENSION ANTI-DIVE SYSTEM IS FAILING IN THE SHOCK "LOCKUP" POSITION & THE SHOCK SEAL IS BEING OVER PRESSURED DURING THE SHOCK MOVEMENT ACTION. ARGUED WITH THE SERVICE SUPERVISOR & THE HONDA MOTORCYCLE DIVISION 866-784-1870 FROM 10 AM TILL 2 PM, & THEY ARE SAYING THAT THERE IS NO PROBLEM WITH THE MOTORCYCLE & THIS IS A ISOLATED INCIDENT. *NM

CONSUMER TOOK 2001 HONDA GL1800 TO THE DEALER FOR THE FRAME INSPECTION AND THE KILL SWITCH RECALL. CONSUMER EXPERIENCING PROBLEMS HAVING THE RECALL REPAIRS PERFORMED.*MR THE VEHICLE RAN FINE PRIOR TO THE CONSUMER TAKING IT TO THE DEALER FOR RECALL REPAIRS. *NM

FRAME TUBBING FRACTURE IN THE REAR TRIANGLE OF THE MAIN FRAME ON THE EDGE OF A WELD. NOTE THAT THIS IS A KNOWN FAILURE POINT ON THIS MODEL OF HONDA GOLDWING WHICH OCCURS IN THE TUBING AT THE EDGE OF THE WELD TO A FRAME CASTING.*AK NO REPAIR IS RECOMENDED ON THIS 7003 TYPE OF ALUMINUM WHEN THE FAILURE IS OUTSIDE OF THE WELD