2001 HONDA PASSPORT Complaints

WHILE DRIVING AT HIGHWAY SPEEDS THE ENGINE DIED, LOST POWER STEERING AND POWER BRAKES (LOST VACUUM TO BOOSTER.) THE #1 INTAKE LIFTER BUTTON POPPED OUT AND THE CAM LOBE HAMMERED THE LIFTER AND VALVE INTO THE #1 CYLINDER CAUSING CATASTROPHIC ENGINE FAILURE. ENGINE OIL WAS IN MID RANGE AND HAD ~2000K ON ENGINE OIL CHANGE. NO FLUID MIXING OCCURRED PRIOR TO OR AFTER THE INCIDENT. WHEN VALVE WAS PUSHED INTO THE CYLINDER IT WAS BENT, THE LOCKING UP OF THE CAM ON THE PASSENGER SIDE OF THE ENGINE CAUSED THE WATER PUMP TO BE BROKEN BENDING THE IDLER PULLEY DOWN DUMPING ANTIFREEZE OUT ONTO THE ROAD. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

A FEW YEARS BACK MY TRAILING LINKAGE ON BOTH SIDES OF VEHICLE RUSTED AWAY FROM FRAME. THE DRIVERS SIDE WAS FIRST AND I WAS TRAVELING AT 50 MPH. HIT POT HOLE AND DRIVERS SIDE LINKAGE BROKE OFF. CAUSING ME TO FISH TAIL IN TRAFFIC AND ALMOST CRASH. NOW I HAVE TWO CRACKS IN MY FRAME AND THE REAR CROSS MEMBER IS RUSTED THROUGH. I HAVE ALSO HAD THE FUEL TANK SUPPORT FIXED AND WELDED BACK ONTO MY TRUCK. THIS WILL COST ME THOUSANDS TO FIX TO HOPEFULLY MAKE IT A DRIVABLE VEHICLE AGAIN. OR. AMERICAN HONDA CAN BUYOUT THESE VEHICLES FROM THESE OWNERS. *TR

TL* THE CONTACT OWNS A 2001 HONDA PASSPORT. THE CONTACT STATED THAT WHILE DRIVING DOWNHILL AT APPROXIMATELY 35 MPH, THE VEHICLE BEGAN TO PULL VIOLENTLY IN ONE DIRECTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, WHO INFORMED THE CONTACT THAT THE ENTIRE FRAME WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. ADDITIONALLY, THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN ID NUMBER: 10V436000 (SUSPENSION) IN 2012, WHICH FAILED TO PREVENT THE FRAME RUST PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

THE FUEL TANK SHIELD FOR MY 2001 HONDA PASSPORT IS COMPLETELY RUSTED OUT. UPON RESEARCHING THE SITUATION I HAVE ENCOUNTERED QUITE A FEW PEOPLE HAVING THIS SAME PROBLEM. I AM SCARED TO EVEN DRIVE THE VEHICLE AS THIS SHIELD IS "BARELY" HOLDING THE TANK UP AND COULD FAIL AT ANY MOMENT THUS DROPPING THE TANK. *TR

FUEL TANK DROPPED DOWN, CHECKED AND IT WAS RUSTED OUT AND BROKE FREE FROM FRAME WHICH ALSO RUSTED OUT. THE ENTIRE FRAME IS RUSTED OUT, I HAVE NEVER SEEN A FRAME RUST COMPLETELY OUT LIKE THIS ! HONDA TOLD ME THERE WAS A RECALL AND MY WIFE TOOK IT TO A DEALER AND THEY SAID THE PROBLEM THAT WAS IN THE RECALL DIDN'T AFFECT THE AREA THEY WILL HAVE TO REPLACE. THE DEALER SAID THEY COULDN'T FIX THE PROBLEM BECAUSE THE WHOLE FRAME WAS RUSTED OUT AND THE VEHICLE WAS UNSAFE. NOW WHAT ? I GUESS I SHOULD SELL ALL MY HONDAS AND BUY AMERICAN MOTORS. *TR

THE DRIVER'S SIDE LINKAGE THAT CONNECTS THE REAR AXLE TO THE FRAME SEPARATED COMPLETELY DUE TO CORROSION. I TOOK IT TO HONDA FOR THE RECALL, WHICH SERVICE BULLETIN 10-079 STATES HONDA WILL PAY FOR VEHICLES LESS THAN 10 YEARS OLD AT THE TIME OF THE RECALL (SEPT 2010)), AND THEY DETERMINED THE DAMAGE WAS SO BAD THAT THEY WOULD NOT ATTEMPT TO FIX THE VEHICLE. I FEEL I SHOULD BE REIMBURSED FOR MY VEHICLE SINCE THE DEFECT HAS CAUSED SUCH EXTENSIVE DAMAGE AS TO RENDER THE VEHICLE UNSAFE. *TR

REAR TRAILING ARM FELL OFF OF THE FRAME DUE TO MAJOR CORROSION. WE HAD IT TOWED TO DEALERSHIP FOR RECALL #10V-436. SERVICE DEPT STATED THE ENTIRE FRAME WAS RUSTED THROUGH THEREFORE THEY HAD NOTHING TO ATTACH THE RECALL BRACKET TO. THIS RECALL SHOULD BE FOR THE ENTIRE FRAME NOT JUST THE BRACKET. IT BROKE WHILE BACKING OUT OF OUR DRIVEWAY. THANKFULLY WE WEREN'T DOING 70 ON THE HIGHWAY. *TR

TL* THE CONTACT OWNS A 2001 HONDA PASSPORT. THE CONTACT STATED THAT THE REAR SUSPENSION AXLE AND FRAME WERE SEVERELY CORRODED AND THERE WERE HOLES IN THE FRAME. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN I.D. NUMBER: 10V436000 (SUSPENSION:REAR) AND TOOK THE VEHICLE TO THE DEALER FOR RECALL REPAIRS. THE DEALER ADVISED THE CONTACT THAT THE FRAME WAS SO CORRODED, THAT IT WAS BEYOND REPAIR. THE DEALER SPOKE WITH THE MANUFACTURER REGARDING THE FRAME AND THE MANUFACTURER ADVISED THE DEALER TO ONLY TO REPAIR WHAT WAS STATED IN THE RECALL. THE DEALER REPLACED THE LOWER LINK FRONT BRACKET ON THE REAR SUSPENSION BUT NOT THE FRAME. THE CONTACT THEN TOOK THE VEHICLE TO A SECOND MECHANIC FOR A SECOND OPINION AND WAS ADVISED THAT THE FRAME COULD POSSIBLY CRACK AND COLLAPSE IF THE CONTACT DROVE OVER A ROAD BUMP. THE FAILURE MILEAGE WAS 119,900. UPDATED 01/04/12 *BF THE CONSUMER SOLD THE VEHICLE TO AN AUCTION. UPDATED 01/10/12 UPDATED 01/12/12

THIS MODEL 2001 HONDA PASSPORT HAS A HISTORY OF FRAME RUST. THERE WAS ONE RECALL 2010 BUT IT DID NOT ADDRESS TANK SHIELD RUST - ONLY REAR AXLE PARTS. THE PASSPORT HAS 72373 MILES AND THE HONDA DEALER WANTS TO CHARGE FOR A REPORT REQUESTED BY HONDA MOTORS. ****AT THIS POINT I DO NOT KNOW IF THE GAS TANK IS GOING TO FALL OUT.**** *TR

MY VEHICLE HAS HAD A RECALL AND THEY TOLD ME IT WAS TOO FAR GONE AND TOOK IT BECAUSE OF BEING UNSAFE TO DRIVE. THEY GAVE ME A RENTAL CAR AND TOOK IT BACK BEFORE THIS WAS RESOLVED. THE DEALERSHIP GAVE ME MY "UNSAFE" CAR BACK BECAUSE I COULDN'T BE LEFT WITHOUT A CAR. I AM A SENIOR CITIZEN WITH A HANDICAP. ALL I WANTED WAS TO HAVE MY CAR REPLACED WITH A COMPARABLE CAR, INSTEAD THEY WANT TO GIVE ME A SETTLEMENT CHECK AND TRIED TO SELL ME A NEW CAR. I CANNOT AFFORD A NEW VEHICLE OR PAY MORE FOR A VEHICLE THAN MINE IS WORTH. I AM HAVING A DIFFICULT TIME FINDING A REPLACEMENT AT THE SAME PRICE. *TR