2020 HONDA PILOT Complaints

I am reporting a severe safety defect regarding the automatic transmission on my 2020 Honda Pilot AWD (VIN: [XXX]). The vehicle experiences a violent and constant transmission vibration/judder under light throttle acceleration. On XXX, at 127,073 miles, an authorized Honda dealership officially diagnosed the vehicle under Repair Order # XXX, confirming the presence of "shudder at light throttle". Despite changing the transmission fluid as required by maintenance schedules, the issue persists. This failure causes unexpected vehicle hesitation and jerky shifts while driving at highway speeds, creating a high risk of rear-end collisions and posing an immediate safety hazard to my family and other drivers on the road. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Summary of safety defect and failed recall repair: Vehicle: 2020 Honda Pilot EX (Clean California Title) Core Issue: Persistent, catastrophic failure of the MOST Bus fiber-optic communication network, resulting in complete blackout of the federally mandated rear backup camera (FMVSS No. 111 violation), total infotainment reboot loops, loud audio cracking/popping, and instrument panel system failure during active vehicle operation at 65+ mph highway speeds. RECALL REMEDY FAILURE CHRONOLOGY: 1. IN-WARRANTY ANCHOR: On April 20, 2022 (34,201 miles) at Tracy Honda, initial network cracking/popping and communication faults were logged under factory warranty. Display head unit was replaced, but underlying MOST Bus backbone issues persisted. Fakra connectors replaced to attempt to fix the issue. 2. RECALL ATTEMPT: On July 17, 2025, at Lompoc Honda, the vehicle was presented specifically under Safety Recall Campaign 23-047 / NHTSA 23V-431. Dealer technicians installed FAKRA connectors and connector jumpers per official remedy instructions. 3. REMEDY FAILURE: The recall remedy failed to correct the defect. The vehicle continues to experience "Network Communication Lost" and "Check Tuner" system collapses, completely disabling the rear backup camera display without warning - all while being in a 10-minute reboot loops. SAFETY HAZARD: The sudden, unannounced loss of rear visibility and screen blackout creates a direct backover and collision hazard in violation of Federal Motor Vehicle Safety Standard No. 111. Furthermore, total network reboots at highway speeds cause severe driver distraction. REMEDY REQUESTED: American Honda Motor Co., Inc. has been notified (Corporate Case #XXX), but has failed to remedy this known federal safety defect after statutory repair opportunities. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Full brake system, Emissions System problem, and Service System malfunctioning, out of the blue. Factory Reset and System Updated performed with no improvement.

The contact owns a 2020 Honda Pilot. The contact stated that after starting the vehicle, there was an abnormal ticking sound coming from the engine. The vehicle was taken to the local dealer, who examined the engine and discovered metal shavings inside the oil pan and there was engine rod bearing damage. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The contact was informed of NHTSA Action Number: PE25008 (ENGINE). The contact stated that the vehicle had experienced the failure listed in the NHTSA Action Number. The failure mileage was 46,500.

Engine start/stop function fails to restart after automatically shutting off at a light or in traffic. It falters and fails to start, then the dashboard lights up with errors, and I have to put it into park before restarting. Sometimes it takes a few tries before restarting. The battery has been replaced twice in the last year and the starter motor within the last year too, but the issue persists.

When the vehicle is at a stoplight or stop sign, the engine regularly shuts off. The engine does not automatically restart and sometimes it takes several minutes to restart the engine, leaving the car blocking traffic at a light. This happens REPEATEDLY and often.

Lots of crackling noises via the audio system. Display reboots itself many times before it finally went BLANK. Radio / DVD DEAD. Blind Spot warnings DEAD. Back up camera DEAD. Navigation DEAD. Eventually the battery goes DEAD and the car will not start. Got Stranded a few times. Changed the battery. But hopeless and reliability is DEAD. Definitely disappointed with HONDA.

First of, there are a LOT of Honda Pilot owners online who have the same exact complaints in honda forums and social media. Windshield Lane Keep Assist camera is malfunctioning. Adaptive cruise control, Emissions systems, Road departure system, Auto high beam problem, Lane keeping assist, Collision mitigation system warning lights all come on. No previous warnings or failures prior. This started out of the blue and has been happening everyday for a few months now. This malfunction puts driver and passengers at risk.

The problem on our Honda Pilot is related to the starter. We have had four instances now where the auto start/stop function has failed to restart the car after sitting at a stop light. This has happened at very busy intersections resulting in difficulty restarting the car and the car temporarily disabling the auto start/stop functions. I just had this happen for the fourth time on 7/9/26 at approximatlely 6:00 PM. I am planning on taking it into the dealership to have it looked at since it has happened multiple times. I also see on the Internet that other owners are having this issue and NHTSA is looking into it. I feel this is a significant safety issues since this happens in traffic and could result in people being rear-ended when their car won't start. This problem started for me about two months ago but I thought it was just a fluke but apparently it is not. The battery and electrical system has been checked and are working properly.

On two separate occasions this vehicle has died when stopped at a traffic light. First time was in February and the second was in June, both times were in 2026. Both times had to push the off button and do a restart.