2023 HONDA PILOT Complaints

The contact owns a 2023 Honda Pilot. The contact stated that while driving at an undisclosed speed, the brake pedal was unexpectedly engaged causing the vehicle to abruptly stop in ongoing traffic with no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that the front brake sensors had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred on multiple occasions. The vehicle was taken back to the dealer. The vehicle not diagnosed or repaired. The manufacturer was made aware of the failure, and multiple cases were opened. The contact expressed concern that the vehicle was hazardous to operate and that the failure could lead to a catastrophic crash. The contact also stated that the vehicle was unsafe to drive with the contact and the contact’s child inside. The failure mileage was approximately 50,000.

I have a 2023 Honda Pilot AWD Elite with approximately 46,000 miles. It has an engine idol feature that's suppose to restart the engine after idoling. I was in a parking lot waiting to enter into traffic when the engine completey shut down. I was able to restart the engine at the time. Again the same day I was at a stop light, the car was idoling and when the light turned green, I took my foot off the brake and proceeded to press the gas pedal, the car shut down completely and I had to restart the vehicle. I made an appointment to take my car to the dealership the next morning. On Friday May 1st, 2026. I brought the vehicle to the dealership but they told me they won't be able to see it until Monday. Saturday, I took my child to his soccer match and again, at the stop light before getting onto the freeway, the vehicle shut down after Idoling. The feature Auto idol/restart is automatically on when you start the vehicle. It will drive fine if you remember to turn the function off. Honda has no official recall on this. There was a similar software issue recall in 2025 but the dealership told me that campaign was closed.

At about 9700 miles I noticed a popping noise in the steering wheel when it was turned left or right after driving for a few miles and it could be felt in the steering wheel. The popping sound got worse and on July 7, 2025 I took the car to the Honda dealership I bought it from at 11, 900 miles and the master mechanic confirmed the sound and stated the steering rack needed to be replaced. That was done over 4 days but several months later the popping sound that could again be felt in the steering wheel returned. I contacted the Georgia Attorney General Lemon Law division and was advised that because it was a safety defect I should give Honda a Final Repair Opportunity Notice under the GA Lemon Law which I did on Oct 24, 2025. Honda ignored the Notice and the Attorney General Accepted the case for Arbitration which is set for May 29, 2026. In preparation for arbitration, I discovered that at least 3 other complaints have been filed with the NHTSA about the exact same safety issue I have experienced. I do not know how these complaints were resolved but concerning one of them, the steering rack was replaced like mine and the popping sound from the steering returned. Honda therefore knows of this safety defect but has continued to ignore my Lemon Law Complaint and request for discovery of internal Honda information concerning this defect. I have severely limited driving of this vehicle to short trips at slow speeds to my law firm and cannot drive it at highway speeds for fear of steering failure.

I was stopped at a stop light on a very busy road. The vehicle went into Auto Idle shut down. When the light turned green, I attempted to press the gas but the engine was completely stalled and would not restart. I had to put the vehicle in park, turn off the vehicle, and completely restart it for the vehicle to be able to successfully clear the busy intersection. After this incident, the vehicle would inconsistently give me the Auto Idle System Problem warning when first started. I chose to disengage the Auto Idle system until I was able to take it to the dealer. They claim it is the electrical charging wire which is an 8,000 dollar repair for a 3 year old vehicle. We are currently awaiting the inspection from our extended warranty.

Description: While using cruise control at highway speed and winter weather conditions, the cruise control system suddenly and unexpectedly disengaged without adequate warning. The vehicle experienced rapid deceleration and I lost control, resulting in multiple spins, a near collision with a truck, and impact with a curb before coming to stop. The vehicle sustained damage. Fortunately no one was not severely injured. History and safety concern This is not an isolated event. I have experienced similar, unexpected cruise control disengagements multiple times over the past year while driving under varied conditions. Each event has created a significant safety risk. The sudden, uncommanded disengagement at highway speed caused abrupt deceleration and loss of control, which presents a severe hazard to vehicle occupants and other road users. I have reported the issue to the manufacturer and requested a full diagnostic investigation, system data logs, root-cause determination, and remediation (I am requesting replacement or buyback if a defect is confirmed). I have asked the manufacturer to escalate to a senior case manager/remediation team and to preserve all relevant data and parts. Requested NHTSA actions Open an ODI safety defect investigation into this vehicle model/series and the cruise control/ADAS/cruise-control module behavior. Request preservation and production of all relevant manufacturer data, including ECU/ADAS event data recorder logs, telematics, software versions, diagnostic records, and any field complaints or warranty claims related to cruise control disengagements. Evaluate whether this is a systemic safety defect requiring recall, remedy, or other actions, and consider requiring manufacturer owner notification and appropriate remedies (repair, replacement, buyback) if a defect is confirmed. Provide guidance on any additional evidence or steps I should take to support the investigation.

Seatbelt sensory goes off in the middle row right passenger staying seatbelt not connected. Seatbelt is connected and the alert will not cut off.

The third row seat belt buckles on driver side and passenger side have been replaced due to failing to register when a child is seated and buckled in that row causing the vehicle alarm to go off notifying me that the child is unbuckled when they are not. I have been to the dealer 5 times going on 6 for this same issue. Have had a total of 3 buckles fail, one of them had failed twice now. 2 of them have been repaired and the vehicle is scheduled to go back to the dealership April 3rd to fix the two new buckles that have failed.

The contact owns a 2023 Honda Pilot. The contact stated that while driving at an undisclosed speed, the rearview mirror console located near the front windshield became inoperable. There was no warning light illuminated. The contact stated that upon inspecting the area, the rearview mirror console was extremely hot to the touch. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 74,071.

The driver seat has come unsecured from the vehicle and has been loose and rocky like a rocking chair . Was at the dealer twice for repair

Seatbelt sensors for the passenger second row dinging off and on when seatbelt is buckled. Also the light coming on that says emergency brake unavailable.