2020 HYUNDAI KONA Complaints

While driving approximately 70 mph on I-10 in Louisiana late at night, my 2020 Hyundai Kona EV displayed a “Check EV System” warning while I was on the highway. There were no safe areas or emergency shoulders available to pull over, so I continued driving toward the nearest exit. Approximately 15 minutes after the warning appeared, as I attempted to exit the highway, the vehicle suddenly lost power and rapidly slowed. The vehicle came to a complete stop and could not accelerate, move forward, or reverse. This created a serious safety risk because the vehicle lost propulsion while traveling at highway speed. The vehicle had approximately 62,000 miles at the time of the incident. The vehicle was towed to Giles Hyundai where the dealership diagnosed an internal temperature sensor and resolver failure. Because these components are integrated into the drive system, the dealership replaced the entire traction motor assembly. The repair cost was approximately $9,000. The sudden loss of propulsion at highway speed created a dangerous situation for both the driver and surrounding traffic.

many times a year, without warning, vehicle dash lights turn off and light up like a christmas tree, followed by fca warning sound and lights going off, and a loud mechanical thud. Lose engine throttle going highway speeds. This can occur at nearly any speed without warning. Car must be powered off and back on to get normalcy. This puts me, everyone in the car and everyone on the highway at risk. Dealership was not able to reproduce or pull error codes.

While driving under normal conditions, the vehicle’s dual-clutch transmission (DCT) failed to engage properly, causing a sudden and unexpected loss of propulsion. When the accelerator was pressed, the vehicle hesitated and did not respond as commanded, resulting in delayed or no acceleration. This occurred while driving in traffic at approximately 30 mph while trying to acceletate to merge onto highway and has happened multiple times. In some instances, the vehicle appeared to remain in gear but would not accelerate, and in other instances the transmission disengaged before re-engaging unpredictably. This created an unsafe situation, as the vehicle could not maintain speed or merge safely, significantly increasing the risk of a collision, especially in traffic or at intersections. The issue occurred without sufficient warning and continues to happen intermittently during normal driving.The vehicle was inspected by a dealership, which stated the condition is related to a clutch issue within the dual-clutch transmission and acknowledged it is a known issue affecting this transmission. The dealership further stated the issue would not be repaired because the vehicle is out of warranty.

the headlights in this model Kona keep burning out after 9 months or so. I have replaced them multiple times in the last 5 years on both left and right sides. I use glove to put in the bulbs and are very careful not to let my hands touch the bulb. I have never had this happen with any other car I have owned. I suspect an electrical system issue, or perhaps wiring, but that is speculation. I have not had this inspected by the dealership. The latest date of failure is listed below.

The timing system was repaired in February 2025. After similar symptoms of vehicle stalling, the check engine light came on Found a software update that needed to be completed to determine if engine needed replaced. Dealership has refused for seven weeks to complete the entire job of the update which includes running a diagnostic of codes. Instead, they have been arguing that the timing system needs replaced and not providing the codes from the safety software update. Obviously there's a much deeper issue if the timing system keeps breaking down.

The vehicle has ~51K miles. It has been maintained according to the manufacturer's recommended repair schedule. At low speeds (<10 mph) or when coming from a full stop the vehicle hard shifts. When driving up inclines at low speeds (<10 mph), the vehicle shakes and stutters on the verge of shutting off. This happened twice on [XXX]. I experienced a full vehicle shut off on [XXX} while the vehicle was stationary, but shifted into drive . In August, the vehicle stuttered and shook before shutting off. I have reported three instances of this issue to my local Hyundai dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle suddenly began shutting off upon braking and/or acceleration at any speed, idling very hard, and/or barely starting or dying immediately after starting and making a very loud whining noise while driving on an interstate. A mechanic ran a diagnostic test on it and determined that it was a P1327 code and recommended it be taken to dealership for full engine failure. This particular code was known by Hyundai to occur on certain models and years, including Kona 2019-2021, as early as 2022 and while a recall campaign was initiated, no recall to date has been issued. No warning indicators on dash occurred in advance or even after the vehicle began malfunctioning (i.e., no check engine indicator, etc.). Vehicle is available at dealership upon request.

The engine shut down when the car stops at a red light or stop sign. There are metal shavings in the oil due to issues with the pistons.

Car keeps stalling no matter what speed you're driving. Took the car to NTB and they said nothing is wrong with it. It continues to happen even in busy highways where someone almost ran into the back of me. Not safe to drive. Concerned as numerous forums suggest this is a problem with 2019-2021 Hyundai Konas.

The contact owns a 2020 Hyundai Kona. The contact stated that the vehicle was consuming an excessive amount of engine oil. There was no warning light illuminated. The vehicle was taken to a local dealer, where the vehicle was diagnosed, and the contact was informed that the turbocharger was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 65,000.