2020 HYUNDAI KONA Complaints

The contact owns a 2020 Hyundai Kona. The contact stated that while her daughter was driving approximately 30 MPH, the check engine warning light illuminated, and the vehicle stalled. The driver was unable to restart the vehicle and had the vehicle towed to an independent mechanic. The contact stated that the mechanic had not diagnosed the vehicle; however, an oil change was performed. The vehicle was repaired; however, the check engine warning light remained constantly illuminated. The contact that the vehicle was taken to a local dealer and two software updates were performed as per the manufacturer recalls on the vehicle, but the contact was informed that the recall repair for NHTSA Campaign Number: 21V301000 (Engine) could not be performed. The contact stated that the check engine warning light remained illuminated, and the vehicle was taken to an independent mechanic. The mechanic related the engine warning light being illuminated with the unrepaired recall. The contact was referred to the dealer again for assistance. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 106,000.

6/17/2024 12 volt battery was dead; EV was fully charged 6/16/2024 using Level 2 charger in my home garage. AAA charged the battery; I drove to Crossroads Hyundai Loveland, CO and asked to have the converter to the main battery checked; this was not done. Crossroads checked the battery via CADEX with "good battery charge" as result. No other diagnostic work was performed. 8/26/2024 12 volt battery again depleted; AAA charged twice 11:06 am (recharge and retest ) and 3:51pm (Bad & replace). I drove again to Crossroads Hyundai which claimed battery test showed good battery. Technician found a draw dropped after pulling fuses F6 multi media and F16 memory. Techline at Hyundai was contacted and tech was instructed to install junction box for fuses (91950-K4061 Junction Box assembly I/PNL 91). The car was undriveable on the Crossroads lot until part received and replaced 9/20/2024. 9/24/2024 when I arrived to pick up the car, the service advisor told me the door was left ajar after car wash, causing draw on battery; the battery was damaged by continued discharge due to strain from parts replaced. Hyundai agreed to replace the battery at no charge to customer. There were no warming lamps, messages or other symptoms of the problem prior to 6/17/2024. My safety, as a senior and woman is at risk if the car was stranded in a parking lot or other area outside of my home garage.

Vehicle has problems shifting between 1st and 2nd gear. Stutters and has issues accelerating. Has almost caused me to be hit while turning left against traffic. Was serviced at Hyundai dealership today and they cannot replicate the issue or find anything wrong and reprogrammed the clutch touch point engagement. It happened again on the way home.

When stopped at a light, I hit the gas and the car just sputtered. The car jolted and did not move, finally, hit the gas again it was able to move. It has happen before. My roommate's Dad told me I need to keep track of problem and file a report. I was told the injectors needed to be cleaned. I put injector cleaner into it, It seem to help but it happened again. It seems the dealer just says something needs to be cleaned.

I am concerned about the safety of my car and have little faith that there are qualified mechanics who understand EVs and can properly service an EV car. Two times on April 9, 2024 (and on at least 4 other occasions in 2023) while drive at approximately 45 miles an hour on a RI State highway at a safe distance from any care in front of me, my vehicle went into the fail-safe mode while I was driving causing a sudden significant loss of power to the car and it appeared to be that it was going to stall. There was no warning sound indicating that I was going to crash into the forward vehicle (again, I was at a safe distance). In order to continue driving, I had to pull onto the road shoulder, shut off the car, which seemed to reset it. On this particular day/occasion, this situation occurred twice in the span of about 10 minutes. Had there been anyone driving right behind me, they would have hit my car. In addition, I brought my car to the dealer to address but the dealership did not know how to fix/address my problem. They did find "multiple codes" in the car history, deleted the codes, and test drove the car. They said if it happened again, to let them know. They also told me if it occurred again, then I should bring it in when the 1 and only technician, who knows anything about the EV cars, was working. I took a photo of the dashboard immediately after one of the episodes while the car was still running before I shut if off. I will attach it.

The vehicle shut down while I was driving approximately 40 mph on a major throughway out of town. I was unfamiliar with the area and had to quickly pull over into a resident's driveway. I immediately shut the vehicle down and tried to restart it. It would not turn over, so I waited a few minutes and tried again. The engine then made a noise that almost sounded like "I quit" and would not make any noise when I turned the key after that. I called a local tow company who towed it to Firestone Complete Auto Care which was the nearest open garage. After they ran their diagnostic, they said that the engine had seized and that there was no oil in the reserve. I never had any engine lights light up on the dashboard until the second the car stopped working, when they ALL came on. My mechanic friend says that these engines have computers that time stamp when the warning lights come on, so it will be interesting to know if they use that information. I have contacted Hyundai customer service and because we are not the original owners of the vehicle, they said the powertrain/engine is not covered under the 5 year/60k mile warranty from Hyundai. We do have an extended warranty through a 3rd party company, but they are giving us a difficult time too. We are still waiting to hear if they will cover the replacement of the engine. This is a HUGE safety risk because my vehicle gave no advanced warning that it was needing service/maintenance and just stopped functioning while I was driving. If I had been on a different street or in the middle of a turn, it could have resulted in injury/death of occupants of the vehicle. My oldest son is also just starting to drive. If he were driving this vehicle when this occurred, he may not have known what to do and could have been stranded in the middle of a busy highway, where an accident could have been imminent.

We just had our 2020 Kona updated from the dealer with major software and recall updates. Since that point the car has been draining from the 12volt battery on it's own and killing the charging circuit for the battery. It has caused us to have to jump start the car and not be able to keep the 12 volt charged which runs all of the environmentals and car systems. Unless you have a jump pack with you, you have to jump it after every stop. I have tested the battery and it is fine but the system needs a high end initial draw and is not getting it. I have contacted the dealer but they are saying it is not their problem. This needs government address, as it is the same issue in the NHTSA recalls or Hybrid and EV Sonata and Ioniq 5 models.

The issue is when I'm decelerating to around 5 mph and go to accelerate again, there is a horrible grinding sound from the transmission and I can no longer accelerate. I then have to stop and re accelerate. This is dangerous if there is a car coming and I pull out and have to stop all of a sudden. I have 2 separate videos of the issue. The dealership won't fix it under warranty because they can't replicate it. The dealership won't even take a look at anything.

The Hyundai Kona was struck head-on by another vehicle. There was one driver and one minor passenger in the right rear seat in the Hyundai Kona. The driver had minor injuries while, unfortunately, the accident was fatal to the passenger. The impact of the collision caused the right rear seat to snap forward, fracturing the passenger's neck. The cause of death for the passenger was blunt force trauma caused by the neck fracture. If the seat had stayed in place during the impact, the passenger's neck would not have been fractured. The vehicle is no longer available for inspection. To our knowledge, the problem has not been reproduced or confirmed by a dealer or independent service center. The vehicle was inspected after the accident by the police. There was no symptom of the problem prior to the accident.

This has happened about 15 times since I bought my Hyundai Kona EV Ultimate new in February 2021: When a car in front of me slows very quickly, occasionally my car tries to help me too much. I have been in complete control of the situations, but my car beeps it's warning, adds it's efforts and the brakes lock up with tires squealing, and we stop with plenty of space in between myself and the car in front of me. This usually happens in freeway traffic. It is terrifying and I always immediately look in my rearview mirror to see if I'm going to get rear-ended. I haven't been hit yet, though I have been flipped off a few times. One of these days, people will be hurt, along with the damages to the cars. The first time it happened was only about 2 weeks after the purchase. I had my 5-year old twin granddaughters in their car seats. Just as described above, the brakes locked up and it really scared them (me too!). I took it back to the salesman I bought it from at Stevens Creek Hyundai and he said it was just a setting with the response time, so he changed it. But it kept happening intermittently. I brought into the Future Hyundai of Concord dealer and they test drove it, could not replicate it, and after checking with their computers, said that the "system is working as designed". Frustrated that I wasn't being heard, I contacted Hyundai Consumer Affairs. They supported me and I got a case number and another appointment at a different dealer, Dublin Hyundai. This time, I went on the test drive and the technician was able to replicate the situation. At first he said it was a setting, but I said that I didn't care what the setting was, this should never happen. It is very dangerous. He agreed and said he would need to contact "Techline" the next day. But when I tried to find out any information about this conversation, I got only silence. Then I got a message that I could come pick up my car and that "the system is working as designed". Help!