2020 HYUNDAI PALISADE Complaints

When driving down the tollway in my city early in the morning, no cars around for at least 200 yards, something small hit my windshield causing a spiderweb crack in the center of windshield. Will have owned the vehicle for 2 weeks as of tomorrow and has less than 3k miles on it.

I have a 2020 hyundai palisade and it only has 9000 miles on it. The driver side seat belt and the second row middle seat belt will not buckle anymore. The driver seat belt start just a few month after i bought the car. The second row middle seat belt issue looks like came with the new car , we did not know because we did not use that seat until now. The dealer is making this my issue and they are telling me , this is due things stuck in the seat belt and asking me to pay to fix the issue.

While we were in a store shopping the windshield spontaneously cracked. No reason, not caused by a rock chip or any other impact.

I walked out to my vehicle in the driveway this morning and the windshield was cracked for no apparent reason. There were no visible chips near the crack. Crack extended from lower Driver's side corner upwards and across to almost the center-line. I also had to previously repair two chips in the windshield that did not appear to be from debris damage. It would appear that the windshield is defective as installed at the factory.

The rear windshield shattered unprovoked. This was only 3 weeks after being repaired for the same issue. This is the third time.

At 12,800 miles, while parked, a 18'' to 24'' windshield crack spontaneously appeared originating from the lower, passenger side edge, sloping up towards driver side. Nothing came into contact with the glass, and no chipped starting point is visible.

While driving in heavy rains , check engine light comes up and vehicle starts vibrating. Once the vehicle is stopped and restarted the light & vibration goes away. This happened twice in 2 months ( July & aug 2021) and while driving in Interstate. I did report to the dealer/service manager after the first time and they were not able to pull up any logs/codes from the vehicle computers. The second time, it happened, I took the photo of the same. First time it occured when I had about 17500 miles on the vehicle. Second time it was 19643 miles. Both times it was raining heavily and speed was between 40- 50 miles/hour

Steering wheel makes whirring sound when turned. Service department aknowledged the problem and replaced the worm gear in the steering shaft. Issue went away. Now about 5000 miles since repair the same issue is back.

On interstate highway in South Dakota in September 2020, a small pebble came off the road surface creating a small chip on front windshield. Within one hour the windshield had a crack horizontally covering the entire windshield. This caused a complete one day delay on our vacation trip as the windshield had to be replaced at a local Safelite location. Certainly the delay was an inconvenience but more important we are concerned about our safety. This occurred when vehicle was less than 2 months old. Now it is July, 2021 and on another interstate a small pebble came off the road and caused a small chip in the lower left windshield. Next day the small crack started to run requiring a compete windshield repair AGAIN. If a small pebble can do this immediate damage, I fear the entire windshield could shatter causing a major accident or at worst a fatality. Safelite and Travelers Insurance have all documentation regarding the two incidents.

The vehicle's air bag warning light on dash was noted to be intermittently illuminated when car being driven, and only when passenger is in front passenger seat. Car taken to dealer, air bag sensor in front seat to be replaced. Problem has persisted despite being repaired three times by the dealership. Error codes remain the same or similar when checked by dealership. Repair records can be furnished on request.