2004 HYUNDAI SANTA FE Complaints

2004 HYUNDAI SANTAFE BROKEN COIL SPRING RUBBING AGAINST THE FRONT TIRE. VEHICLE WAS PARKED IN MY DRIVEWAY WHEN I HEARD A VERY LOUD BANG THAT SOUNDED LIKE A SHOTGUN. I WENT OUT TO INVESTIGATE BUT COULD NOT FIND ANYTHING WRONG. THE NEXT MORNING I ATTEMPTED TO LEAVE FOR WORK WHEN I NOTICED A STRANGE NOISE. I COULD NOT IDENTIFY THE SOUND SO I TURNED AROUND AN PARKED THE VEHICLE BACK IN THE DRIVEWAY. IT WAS THEN I NOTICED A CURVED SHAPE PIECE ON THE GROUND WHICH LOOKED LIKE A HOTDOG WHERE MY VEHICLE HAD BEEN PARKED. I PICKED THE HOTDOG SHAPED PIECE OF STEEL APPROXIMATELY 3/4" DIAMETER. IT APPEARED TO HAVE BEEN BROKEN ON ONE END. AFTER FURTHER INVESTIGATION I FOUND IT TO BE A PIECE OF THE COIL SPRING ON THE FRONT DRIVERS SIDE STRUT. THE COIL SPRING WAS NOW RUBBING AGAINST THE FRONT TIRE. LUCK FOR ME THIS DID NO HAPPEN WHILE I WAS ON THE HIGHWAY. *TR

THERE IS A STRONG SMELL OF GASOLINE COMING FROM MY VEHICLE - IT CONSUMES BOTH THE INTERIOR AND THE AROUND THE ENTIRE EXTERIOR OF THE VEHICLE. LOOKING AT ALL OF THE COMPLAINTS, THIS IS NOT THE FIRST TIME THIS HAS HAPPENED. WHY ISN'T THERE A RECALL?? HYUNDAI - ARE YOU DOING ANYTHING TO HELP YOUR CUSTOMERS????? *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL TANK WAS CRACK AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 97,000.

DIES IN THE MIDDLE IF ROAD! ALMOST DIE. ALL THE TIME!!!!!! DIES IN THE MIDDLE IF ROAD! ALL THE TIME!!!ALMOST DIED. *TR

GAS TANK LEAK NEAR THE EXHAUST SYSTEM. CAUSE BELIEVED TO BE DUE TO A DESIGN FLAW. THE BOTTOM OF TANK WAS COVERED BY A POLY SHELL. THE SHELL TRAPPED MOISTURE AND SALT, ETC. BETWEEN BOTTOM OF METAL TANK AND POLY SHELL. THIS SET UP A CORROSION ENVIRONMENT AND RESULTED IN LEAK. NEW REPLACEMENT TANK FROM HYUNDAI DOES NOT HAVE THE POLY SHELL. NOTE: THE VEHICLE HAS NO RUST AND IS IN VERY GOOD CONDITION. *TR

AFTER PULLING INTO TRAFFIC, I LIFTED MY FOOT FROM THE ACCELERATOR WHEN I REACHED MY DESIRED SPEED. HOWEVER, THE VEHICLE CONTINUED TO ACCELERATE. I APPLIED THE BRAKE, AND THE ENGINE CONTINUED TO REV FOR 1 OR 2 SECONDS. THERE WAS NO ACCIDENT ON THIS OCCASION, BUT IT WAS TERRIFYING, AND I HAD MY CHILD IN THE VEHICLE. *TR

MY OIL CHANGING PLACE THOUGHT I HAD A POWER STEERING FLUID LEAK, SO I TOOK IT TO THE DEALER TO CHECK. THE REAL PROBLEM WAS THE FRONT RIGHT AXLE BOOT WAS LEAKING BADLY (COVERED BY THE POWER TRAIN WARRANTY), BUT THEY FOUND THAT THE RIGHT AND LEFT CONTROL ARM BUSHINGS HAD COLLAPSED AND THE SENSORS WERE FROZEN IN PLACE. AFTER THEY FIXED THESE, THE MECHANIC TOOK IT FOR A TEST DRIVE, AND DURING THE TEST DRIVE, THE RIGHT FRONT COIL SNAPPED. I AM TOLD THAT I MUST NOW REPLACE BOTH LEFT AND RIGHT FRONT COILS AND HAVE THE CAR RE-ALIGNED. THE COILS SHOULD BE ON RECALL, AS OBVIOUSLY THERE IS A DEFECT IN THE MANUFACTURING. *TR

WHENEVER I GET GAS AND WHICH I DREAD , ONCE I FILL UP THE TANK OR JUST PUT A FEW GALLONS AND I TURN THE IGNITION IT GRINDS LIKE IT IS TRYING TO START . EVENTUALLY IT WILL TURN OVER OR I WILL HEAR A POP. I AM AFRAID AT SOME POINT WITH THAT POP THAT IT WILL CATCH ON FIRE. THIS HAPPENS EVERY TIME I FILL THE VEHICLE WITH GAS. COULD SOMEONE PLEASE LET ME KNOW WHAT THE RESOLUTION IS. *JS

NOTICED A STRONG SMELL OF GAS COMING FROM CAR. COULD SEE GAS LEAKING FROM UNDER CAR. THE LOCAL HYUNDAI DEALER SAYS THE GAS TANK HAS CORRODED, AND MUST BE REPLACED. CONTACTED HYUNDAI USA AND WAS TOLD THE WARRANTY ON THE GAS TANK HAD EXPIRED, AND THAT I WAS NOT ELIGIBLE FOR ANY ASSISTANCE (TOUGH LUCK). *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH OVER RAILROAD TRACKS, HE HEARD A POPPING SOUND. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE FRONT PASSENGER'S COIL SPRING HAD FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 101,000. UPDATED 06/17/14 MA UPDATED 8/17/17*CN