2009 HYUNDAI SANTA FE Complaints

GAS GAGE INDICATION SHOWS EMPTY WHEN THE TANK IS FULL OR EMPTY. THIS HAPPENED WITH OUR 2008 SANTA FE TOO.

OIL LEAK FROM VALVE COVER GASKET WHICH HAS BEEN FIXED ON TWO DIFFERENT OCCASIONS. AND GAS METER IS NOT READING THE CORRECT LEVEL OF GAS.

AIRBAG LIGHT CONTINUOUSLY ON. NEVER HAD A PROBLEM BEFORE. HAVE BEEN IN AN ACCIDENT BUT CLEARED. CAR WAS PUT BACK TOGETHER AND NOT ON A SALVAGE TITLE. FUEL PUMP SENSORS ARE AT FAULT. NEED TO REPLACE FUEL PUMP SENSORS. ALL FAULT CODES APPEAR WHEN VEHICLE IS NOT IN MOTION.

MY CONTROL ARM AND AXLE BROKE AFTER THE JUNE 2017 UNDERCARRIAGE VEHICLE RECALL REPAIR WAS COMPLETED BECAUSE A HOLE WAS DISCOVERED BECAUSE OF CORROSION. MY VEHICLE WAS IN MOTION WHEN THE AXLE BROKE APART FROM THE BALL JOINT

CHECK ENGINE LIGHT IS ON AND GAS GAUGE SHOWS EMPTY EVEN AFTER FILLING UP TANK.THE PROBLEM STARTED AT AROUND 100,000 MILES ( GIVE OR TAKE) MECHANIC SAID IT THE FUEL SENSOR ON DRIVER'S SIDE AS PER ELECTRONIC READING.A RECALL MUST BE ISSUED FOR THIS DANGEROUS DEFECT. ITS PLAIN TO SEE ITS A COMMON ISSUE. I ALREADY RAN OUT OF GAS DURING MY MORNING COMMUTE ON NYC WESTSIDE HIGHWAY & FDR DRIVE, I LITERALLY ALMOST DIED THE 1ST TIME IT HAPPENED.

WHILE TRAVELING ON THE INTERSTATE AT SPEED (70 MPH), CAR STOPPED RESPONDING TO THROTTLE WITH NO WARNING. AS I MERGED TO RIGHT LANE, CAR DIED COMPLETELY AND I HAD TO MANEUVER TO SHOULDER WITH NO POWER. STUCK HERE WITH WIFE AND 2 TODDLERS UNTIL TOWED TO MECHANIC. THE ALTERNATOR WAS DEAD AND HAD TO BE REPLACED. ONE YEAR LATER, SAME THING (LUCKILY NOT ON INTERSTATE THIS TIME, AND WARNING LIGHT DID COME ON THIS TIME). ALTERNATOR REPLACED AGAIN. LATER IN 2015, HYUNDAI ANNOUNCED A MAINTENANCE CAMPAIGN (#936), AND I WAS REIMBURSED FOR INITIAL 2 EVENTS, AND LOCAL DEALER COMPLETED THE REQUIRED MAINTENANCE IN NOV 2015. 2 YEARS LATER, SAME THING: WARNING LIGHTS, OIL ON ALTERNATOR, ETC. LOCAL DEALER AGAIN COMPLETES THE WORK (THANKFULLY AT NO CHARGE TO ME). AS OF TODAY, OIL IS ON THE ALTERNATOR AGAIN, AND I FEEL IT IS ONLY A MATTER OF TIME BEFORE THE ISSUE OCCURS AGAIN. AS MY WIFE IS TYPICALLY DRIVING THE KIDS AROUND IN THIS VEHICLE, I DO NOT LIKE THE THOUGHT THAT IT COULD CUT OFF AT ANY MOMENT. I AM HOPING HYUNDAI WILL ANNOUNCE A PERMANENT FIX OR RECALL. I AM REACHING OUT TO THEM FOR ADVICE ON THE LATEST RECURRENCE. INITIAL EVENT: 6/28/14 (MILEAGE: 61020) 2ND EVENT: 6/1/15 (MILEAGE: 79800) HYUNDAI CAMPAIGN COMPLETED: 11/19/15 (MILEAGE: 89512) 3RD EVENT: 08/30/17 (MILEAGE: 119929) FEB 2018 (MILEAGE: 127177) - NOTICE OIL BUILDING ON ALTERNATOR AGAIN

2009 HYUNDAI SANTA FE V6 3.3 LITER HAS EXPERIENCED OCCASIONAL, RANDOM STALLING OVER A FEW YEARS, ALWAYS WHILE BRAKING AND OFTEN WHILE TURNING. THE PROBLEM SEEMS TO HAPPEN AFTER A PERIOD OF STEADY SPEED DRIVING AND THEN SLOWING DOWN AND TURNING. WHEN THIS HAPPENS, THE VEHICLE STEERING INSTANTLY GETS VERY DIFFICULT AND BRAKING ABILITY LIKEWISE BECOMES INCREASINGLY DIFFICULT. AFTER PUTTING THE VEHICLE IN NEUTRAL, OR PULLING OVER AND PARKING THE VEHICLE, IT WILL ALWAYS START RIGHT BACK UP AND RUN FINE. THE THROTTLE POSITION SENSOR HAS BEEN REPLACED BUT THE PROBLEM PERSISTS. I AM A 50 YEAR OLD MAN WHO CAN WRESTLE THE CAR TO SAFETY (SO FAR), BUT MY WIFE, CHILDREN, OR OTHERS MAY NOT BE SO FORTUNATE. THERE ARE REPEATED MENTIONS OF OTHER HYUNDAI VEHICLES WITH SIMILAR PROBLEMS, AND THESE MOSTLY MENTION A TPS REPLACEMENT AND AN ACCOMPANYING ECU FIRMWARE UPDATE. THERE ARE NO APPARENT RECALLS OR TSBS WITH HYUNDAI THAT AFFECT THIS VEHICLE AND ENGINE COMBINATION, AND THIS IS A HUGE SAFETY PROBLEM FOR WHICH THERE APPEARS TO BE A REMEDY PATH.

SERIOUS FUEL GAUGE MALFUNCTION. GAUGE ALWAYS READS EMPTY, EVEN AFTER A FILL UP. GAUGE CONTINUES TO READ EMPTY WHETHER STATIONARY, IN MOTION, ON A CITY STREET, TURNING BRAKING, ETC. I BELIEVE THE CAUSE OF THE SAFETY RISK IS A FAILED FUEL SENDER ASSEMBLY, LIKELY PARTS 94460-0W000 AND 94430-0W000. THIS APPEARS TO BE A WIDESPREAD PROBLEM IN THE 2009 HYUNDAI SANTA FE MODEL. DEFINITELY A SAFETY HAZARD, AS I CANNOT TELL HOW MUCH FUEL IS IN MY TANK WHILE DRIVING. ANOTHER COMMON ISSUE WITH THIS MAKE AND MODEL IS A FAILURE OF THE PURGE VALVE. THIS HAS ALSO HAPPENED IN MY VEHICLE. THIS DEFECT WILL PROHIBIT THE CAR FROM STARTING IF YOU FILL UP A FULL TANK. SO, THE DRIVER IS FORCED TO FILL UP LESS THAN A FULL TANK SO THAT THEY CAN BE CONFIDENT THAT THE CAR WILL START AFTER PUTTING GAS IN THE VEHICLE. THIS IS A LESS SERIOUS HAZARD THAN THE FUEL GAUGE, BUT WORRISOME NONETHELESS.

2009 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARDS TO REAR BRAKE PADS BEING WORN. *LD THE CONSUMER STATED THE VEHICLE WAS BOUGHT FROM THE DEALER UNDER THE ASSUMPTION THAT IT WAS STREET LEGAL AND SAFE TO DRIVE. AFTER 5 WEEKS, IT WAS DISCOVERED THAT THE REAR BRAKE PADS WERE WORN TO 0% WEAR AND THE FRONT BRAKE PADS WERE AT 1% WEAR. THIS CAUSED DAMAGE TO THE CALIPERS, ROTORS, AND PADS. *JS

MY ESC,ABS& AWD SYMBOL CAME ON AT THE SAME TIME & I KNOW OTHER PEOPLE WHO OWN HYUNDAIS & HAD THIS ISSUE IM GUESSING THIS IS SOMETHING MAJOR BECAUSE WHEN I CALLED THE DEALERSHIP THEY KNEW EXACTLY WHAT I WAS TALKING ABOUT THEY ALL CAME ON WHILE I WAS DRIVING