2008 HYUNDAI SANTA FE Complaints

MY CAR STARTED TO DISPLAYED THE FUEL TANK AS EMPTY WHEN IS NOT. UPON TURNING ON THE ENGINE, THE GAS GAUGE LIGHT IS ON AND THE FUEL TANK IS DISPLAYED AS EMPTY. THE GAS GAUGE ON OCCASION ALSO SPORADICALLY FLUCTUATES UP AND DOWN, REGARDLESS OF HOW MUCH GASOLINE IS IN THE TANK.

THE ISSUE STARTED SHORTLY AFTER MY VEHICLE SURPASSED 60,000 MILES. UPON TURNING ON THE ENGINE, THE GAS GAUGE LIGHT IS ON AND THE FUEL TANK IS DISPLAYED AS EMPTY. THE GAS GAUGE ON OCCASION ALSO SPORADICALLY FLUCTUATES UP AND DOWN, REGARDLESS OF HOW MUCH GASOLINE IS IN THE TANK.

FUEL LEVEL SENSORS FAILED AT 80,000MILES WHILE ON HIGHWAY. CANNOT MONITOR FUEL LEVEL. CHECK ENGINE LIGHT ON. WITH CHECK ENGINE LIGHT ON, VEHICLE FAILS INSPECTION. DEALER QUOTES $800 TO REPAIR. DEALER ACKNOWLEDGES THIS FLAW ENDEMIC TO THIS MODEL. INTERNET CONFIRMS THIS WITH HIGH NUMBER OF COMPLAINTS.

THE FUEL GAUGE STARTED BEHAVING ERRATICALLY AT 75000 MILES. THE FUEL LEVEL SENSOR CAN SUDDENLY DROP TO EMPTY, THEN COME BACK TO 1/2 FULL AND THEN TO EMPTY. IT CANNOT SHOW FUEL LEVEL PROPERLY. THIS IS SERIOUS HAZARD ISSUE AS OWNER CANNOT CORRECTLY TELL FUEL LEVEL WHILE DRIVING. OWNER HAS 10YEAR 100K POWER CHAIN WARRANTY BUT HYUNDAI DEALER REFUSED TO FIX THIS ISSUE AS THEY CLAIMED THIS IS NOT PART OF POWER CHAIN. THIS ISSUE HAPPENS ANY TIME WHILE DRIVING. *TR

GAS FUMES AND SMELL ARE IN THE INTERIOR OF THE VEHICLE. THIS IS MOST PREVALENT WHEN THE VEHICLE HAS A FULL TANK OF GAS. THIS OCCURS BOTH WHEN THE CAR IS IN MOTION AND WHEN IT IS GARAGED. THE DEALERSHIP SERVICE DEPARTMENT COULD FIND NO CAUSE BUT THIS HAS BEEN OCCURRING FOR APPROXIMATELY 18 MONTHS. I AM CONCERNED WITH THE SAFETY AND HEALTH ASPECTS OF THE GAS FUME BUILD IN THE INTERIOR OF THE VEHICLE.

THE FUEL SENSOR(S) AND/OR THE FUEL GAUGE ON MY 2008 HAVE FAILED. THIS HAS CAUSED MY FUEL GAUGE AND "RANGE" BEFORE EMPTY GAUGE TO FLUCTUATE AND GIVE A FALSE READING. I HAVE DONE SOME RESEARCH ON THIS PROBLEM AND IT SEEMS THAT THERE ARE A HUGE NUMBER OF SIMILAR COMPLAINTS. THIS IS A POTENTIAL SAFETY HAZARD AS STALLING OUT IN HEAVY TRAFFIC IS A POSSIBILITY. I AM CURIOUS WHY HYUNDAI HAS NOT ACCEPTED RESPONSIBILITY FOR THIS AND RECALLED THESE CAR FOR REPAIR.

DRIVER'S SIDE SUN VISOR BROKE FROM ITS SOCKET WHILE DRIVING ON THE HIGHWAY. THE VISOR HUNG BY THE WIRE FOR THE LIGHT. THIS IS A WELL KNOWN DEFECT. IT IS DANGEROUS AND SHOULD BE ADDRESSED BY THE MANUFACTURER. I WAS ABLE TO JURY RIG IT BACK - VERY SIMPLE AND EASY; HOWEVER THEIR NEGLECT OF THIS IS DANGEROUS.

FUEL GAUGE SHOWS EMPTY TANK, WHEN TANK IS FULL. CHECK ENGINE LIGHT ON, BUT IS INTERMITTENT. RISK IS THAT VEHICLE RUNS OUT OF FUEL WITH NO NOTICE.

THE CHECK ENGINE LIGHT CAME ON AND THE GAS GAUGE WAS NOT WORKING PROPERLY. ON 7/27/2016 I TOOK THE VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE FUEL SENDERS. ON 9/9/2016 I TOOK THE VEHICLE BACK TO THE DEALERSHIP BECAUSE WHEN THE GAS TANK WAS FULL, THERE WERE VERY STRONG FUEL FUMES INSIDE THE VEHICLE. THE MAINTENANCE REP STATED THAT THEY CHECKED IT OUT AND MADE SURE EVERYTHING WAS SEALED PROPERLY. HE ALSO STATED THAT IT WAS PROBABLY THE FUEL TANK PURGE VALVE FOR WHEN THE WEATHER IS HOT THE GAS WILL EXPAND. IN EIGHT YEARS THIS HAS NEVER BEEN AN ISSUE. NOW IT IS NOVEMBER AND THERE ARE STILL GAS FUMES INSIDE THE VEHICLE. I AM NOW TAKING THE VEHICLE BACK FOR A THIRD TIME. THE FUMES ARE SO STRONG THAT NOBODY CAN SIT IN THE BACK SEAT OF THE VEHICLE. EVEN WHEN THE VEHICLE IS SITTING IN THE GARAGE OVERNIGHT, THERE ARE STRONG GAS FUMES PRESENT.

CHECK ENGINE LIGHT STAYS ON. FUEL GAUGE WILL READ EMPTY EVEN AFTER JUST FUELING. FUEL GAUGE WILL OCCASIONALLY READ A RANDOM LEVEL THEN DROP TO EMPTY WITHIN SECONDS. OBD CODES STATES FUEL SENSOR ERRORS.