2004 HYUNDAI SANTA FE Complaints

WHILE DRIVING ON A STRAIGHT, SMOOTH SECTION OF INTERSTATE HIGHWAY MY WIFE AND I HEARD A VERY LOUD BOOM, AS IF WE HAD HIT A LARGE ROCK OR SOMETHING. THERE WAS NO VIBRATION THAT AN IMPACT WOULD HAVE CAUSED. WE DIDN'T KNOW WHAT HAD CAUSED THE NOISE. 2004 HYUNDAI, SANTA FE DROVE FINE. TWO DAYS LATER, WHEN MAKING A LOW SPEED RIGHT TURN, THE RIGHT FRONT TIRE BLEW OUT. WHEN THE TIRE WAS REMOVED IT WAS DISCOVERED THAT THE COIL SPRING HAD BROKEN, MADE CONTACT WITH THE TIRE AND RIPPED IT ABOUT THREE QUARTERS AROUND COMPLETELY THROUGH. AFTER RESEARCHING THE TOPIC I WAS APPALLED AT HOW MANY COMPLAINTS THERE WERE ABOUT BROKEN SPRINGS ON 2004 SANTA FES. IT SEEMS TO BE A RECURRENT PROBLEM WITH THIS VEHICLE AND SHOULD BE RECALLED. IF THE SPRING HAD RUPTURED THE TIRE WHEN IT APPARENTLY BROKE, ON THE HIGHWAY I HESITATE TO THINK WHAT WOULD HAVE HAPPENED, OR HOW MANY LIVES WOULD BE AT RISK. I BELIEVE IT IS TIME HYUNDAI STEPPED-UP AND RECALL THE SPRINGS. *TR

2004 HYUNDAI SANTA FE. CONSUMER STATES WHILE PULLING OUT OF THE DRIVEWAY, THE DRIVERS SIDE FRONT COIL SPRING BROKE, POKING A HOLE THROUGH THE SIDEWALL OF AN 8 MONTH OLD TIRE *TGW

ON APRIL 21, 2011 WENT TO BACK SUV OUT OF MY DRIVEWAY WHEN THE FRONT LEFT TIRE WENT FLAT. AFTER REMOVING THE TIRE FOUND TIRE HAD A HOLE ON INSIDE WALL OF TIRE . THIS WAS CAUSED BY THE COIL SPRING PROTRUDING OUT. UPON FURTHER INSPECTION FOUND THE COIL SPRING BROKEN. THE CAR HAD TO BE TOWED TO A REPAIR SHOP. I FEEL VERY LUCKY THIS DID NOT HAPPEN WHILE DRIVING AT A HIGH RATE OF SPEED. *TR

I WAS TRAVELING DOWN THE HIGHWAY AT 70MPH WHEN, ALL OF A SUDDEN, I HEARD A BANG AND THE CAR VEERED OUT OF CONTROL. IT WAS A TERRIFYING EXPERIENCE. I REGAINED CONTROL OF THE CAR I WAS ABLE TO SAFELY PULL TO THE SIDE OF THE ROAD TO INVESTIGATE AND I NOTICED THAT THE COIL SPRING BROKE. THE FOLLOWING DAY I BROUGHT MY VEHICLE TO THE HYUNDAI DEALER AND THEY CHARGED AN OUTRAGEOUS AMOUNT TO REPLACE. NOT VERY LIKELY THAT I WOULD PURCHASE ANOTHER HYUNDAI. *TR

THE DRIVER'S SIDE COIL SPRING BROKE ON MY 2004 HYUNDAI SANTA FE AT 40,000 MILES. I WAS DRIVING DOWN A STREET AND THERE WAS A LOUD EXPLOSION TYPE SOUND, MY VEHICLE ACTUALLY FELT LIKE IT JUMPED, ALL THE DASH LIGHTS CAME ON AND THE ENGINE DIED. I WRESTLED WITH THE WHEEL TO GET THE CAR OVER TO THE SIDE OF THE ROAD BUT I WAS STILL IN THE ROAD. THERE WAS A WOMAN IN FRONT OF ME GETTING OUT OF HER CAR WITH A TODDLER AND I CAME CLOSE TO HITTING THEM AS I TRIED TO CONTROL MY TRUCK. I'M SO GLAD I WASN'T GOING FASTER THAN 10-15 MPH. THE REPAIR AGENT SAID HE'D NEVER SEEN THIS HAPPEN AT LESS THAN 100K+ MILES, AND IT TOOK OUT THE BRAKE LINE AND FUEL LINE ON THAT SIDE AS WELL. TOTAL COST WILL BE $1500. AS THE TIMING BELT ALSO NEEDS CHANGING. NOT HAPPY. I SEE MANY OTHER COMPLAINTS OF THIS SITUATION (COIL SPRING GOING ON HYUNDAI SANTA FE AT LOW MILEAGE), BUT I DON'T SEE ANY KIND OF REPARATION OFFERED BY THE COMPANY OR ANY RECALL. THERE SHOULD BE - THIS IS NOT ACCEPTABLE. I'M NOT LIKELY TO BUY A HYUNDAI AGAIN. *TRW

I PARKED MY VEHICLE IN A PARKING LOT AT 8AM AND THEN BY 1PM MY COIL SPRING BROKE DESTROYING MY TIRE AND RESULTING IN MY GETTING TOWED. HAD MY COIL SPRING BROKE ON THE HIGHWAY I WOULD HAVE CRASHED *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THE VEHICLE WOULD NOT START. THE CONTACT WOULD WAIT FOR SEVERAL MINUTES BEFORE BEING ABLE TO RESTART THE VEHICLE. THE DEALER WAS CONTACTED AND ADVISED THAT THE PROBLEM COULD BE CAUSE BY THE EMISSION SYSTEM. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSIS OR REPAIRS. THE FAILURE MILEAGE WAS 85,500.

2004 HYUNDAI SANTA FE HAS SUDDEN ACCELERATION AND SURGING NO TROUBLE LIGHTS ON. DEALERSHIP TOLD ME THE THROTTLE SENSOR HAD TO BE REPLACED, SO WE DID THAT. ABOUT A MONTH LATER, SAME THING HAPPENED. DEALERSHIP REPLACED THROTTLE SENSOR AGAIN, AT NO CHARGE. SAID IF IT HAPPENS AGAIN WE WOULD NEED A NEW THROTTLE BODY. HAPPENED AGAIN, SO HAD THE THROTTLE BODY REPLACED. HAPPENED AGAIN AND WAS TOLD IT WAS WIRING THAT HAD TO DO WITH CRUISE CONTROL. WHICH I NEVER USE. HAPPENED AGAIN TODAY 3/16/2011. NOTIFIED THE DEALERSHIP THAT I WAS DROPPING OFF TONIGHT IN THE NIGHT DROP. I HAVE ALREADY PAID OVER $1000.00 FOR SOMETHING THAT HAS NOT BEEN FIXED. WE WILL SEE WHAT HAPPENS TOMORROW. WE MAXED OUT OUR TOWING WITH AAA, SO MY HUSBAND, WHO WORKS SECOND SHIFT AND HOUR AND HALF AWAY FROM WHERE WE LIVE HAS TO DRIVE IT BACK TO THE DEALERSHIP TONIGHT. IT STARTED TODAY WHEN HE WAS ABOUT 15 MINUTES AWAY FROM WORK. ALSO THIS IS OUR ONLY CAR, AND DEALERSHIP ALWAYS SAYS THEIR LOANER CARS ARE ALL OUT. JUST WANTED THIS DOCUMENTED AND AM PRAYING MY HUSBAND GETS BACK TO THE DEALERSHIP OK. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE INTERIOR DOOR HANDLES WERE DESIGNED AS CHROME OVER PLASTIC AND THE CHROME FRACTURED.. THE FAILURE WAS CAUSING THE EDGES TO BE EXPOSED, WHICH WERE EXTREMELY SHARP. WHEN THE CONTACT'S ATTEMPTED TO EXIT THE VEHICLE SHE CUT HER HAND WHEN SHE GRABBED THE DOOR HANDLE. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER FOR INSPECTION OR REPAIRS. THE FAILURE AND CURRENT MILEAGE WAS 52,000. UPDATED 05/03/11*LJ THE CONSUMER STATED THE DOOR HANDLES WERE DESIGNED AS CHROME OVER A NON-METALLIC SUBSTRATE. OVER TIME, THE CHROME CRACKED AND CURLED UP, THUS FORMING RAZOR SHARP EDGES WHICH COULD NOT BE OBSERVED WHEN THE HANDLE WAS IN ITS NORMAL POSITION. UPDATED 05.11.11

TL* THE CONTACT OWNS A 2004 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE STALLED AS SOON AS IT WAS STARTED. SHE WAS ABLE TO RESTART THE VEHICLE THE FOLLOWING DAY YET THE VEHICLE ABNORMALLY ACCELERATED WITH AN UNUSUAL INCREASE IN ENGINE RPM AS SHE DEPRESSED THE BRAKES. THE VEHICLE WOULD NOT STOP AND SHE THEN SHIFTED INTO NEUTRAL AND SHUT THE VEHICLE OFF. THE VEHICLE WAS TOWED TO THE DEALER WHERE A DIAGNOSTIC TEST WAS PERFORMED. THE FAILURE WAS LOCATED AT THE THROTTLE BODY ASSEMBLY WHICH THE CONTACT WAS ADVISED TO HAVE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 76,000.