2003 HYUNDAI SANTA FE Complaints

TL*THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE ROLLED OVER 4-5 TIMES. NONE OF THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED SEVERAL BROKEN BONES AND THE DRIVER SUSTAINED SEVERAL BRUISES. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 150,000.

SINCE BUYING MY CAR USED IN 2006, MY 2003 HYUNDAI SANTA FE SLIPS OUT OF GEAR AND VIOLENTLY JERKS. ON THE HIGHWAY IT SCARES ONE HALF TO DEATH. AND I SEE THAT THERE ARE MANY OTHER COMPLAINTS OF THIS PROBLEM ALONG WITH THE VEHICLE STOPPING ALTOGETHER. THIS PROBLEM HAPPENS SO INTERMITTENTLY WITHOUT AN ENGINE CHECK LIGHT, THAT I KNEW A DEALERSHIP WOULD NOT BE ABLE TO FIND A PROBLEM. NOW THE VEHICLE WON'T SHIFT OUT OF FIRST GEAR. *TR

TL*THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE DEALER INFORMED THE CONTACT THAT A NEW AIR BAG WAS NEEDED BECAUSE THE DRIVER'S SIDE AIR BAG LIGHT REMAINS ILLUMINATED. THE DEALER PERFORMED A DIAGNOSTIC AND SCAN TEST AND STATED THAT THE AIR BAG NEEDED TO BE REPLACED AT THE COST OF $900. THE FAILURE MILEAGE WAS 43,098.

TL*THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. WHILE OPENING THE PASSENGER SIDE DOOR, THE CONTACT'S FINGER WAS GASHED BY THE HANDLE. HE FOUND A SPLIT IN THE CHROME PLATING OF THE DOOR HANDLE. THE DEALER WAS UNAWARE OF THIS DEFECT. THE MANUFACTURER STATED THAT THEY WOULD SEND A PACKET AND CHECK BACK WITHIN 4 - 6 WEEKS. THE CONTACT FEELS THAT THE MANUFACTURER IS COVERING UP THE ISSUE BECAUSE THEY HAVE NOT INSPECTED SIMILAR MODELS WITH THE SAME CONSTRUCTION. THE CURRENT AND FAILURE MILEAGES WERE 100,000.

TL*THE CONTACT OWNS A 2003 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE FRONTAL AIR BAG WARNING LIGHTS CONTINUED TO ILLUMINATE ON THE INSTRUMENT PANEL. SHE FOUND RECALLS FOR THE 2002 AND 2004 MODELS, BUT NOT FOR THE 2003 MODEL, EVEN THOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 100,000.

THE INTERIOR DOOR HANDLES ON MY 2003 HYUNDAI SANTE FE HAVE CHIPPING/PEELING PAINT. (THE CHROME PAINT) OPENING THE DOOR TO GET OUT THE CHROME PAINT IS SHARP LIKE A RAZOR AND CUTS MY FINGERS AND MY CHILD'S FINGERS AS IT IS HAPPENING ON ALL FOUR DOORS OF THE VEHICLE. IT GETS EMBEDDED INTO YOUR FINGER SOMEWHAT LIKE A SPLINTER BUT MUCH MORE DIFFICULT TO REMOVE AND IS VERY PAINFUL. *TR

I OWN 2003 HYUNDAI SANTE FE ON JUNE 2008 IT STARTED STALLING,HESTITATING ON THE HIGHWAY IT STARTED JERKING AND ENGINE LIGHT CAME ON PULLED TO SIDE IT SHUT OFF WOULD NOT START UNTIL HOURS LATER, TOOK TO DEALER DIAGNOSTIC SHOWED CRANKSHAFT ,BELT TIMING PLUGS, TOTAL COST WAS $1219.84 STATED WAS NOT WARRANTY, I HAD THEM REPAIR , LAST COUPLE MONTHS ,SAME THING AGAIN, BUT I NOTICE THAT THE JERKING AND STALLING HAPPENS AFTER A RAINY/HUMID DAY THE JERKING AND STALLING HAPPEN MORE, WAS TOLD SPARK PLUGS NEEDED TO BE REPLACE AGAIN,STILL THE SAME PROBLEM. I WILL CONTACT HYUNDAI AMERICA AND ALSO THE BBB ABOUT THIS, I THINK THERE SHOULD BE A RECALL AND TAKEN CARE OF, THE STALLING WHILE DRIVING CAN CAUSE AN ACCIDENT WHICH 2 TIMES IT ALMOST HAPPEN WITH ME. I CAN NOT AFFORD TO PAY THIS AGAIN. DOING RESEARCH THIS IS HAPPENING TO LOTS OF 2003 , BUT THIS HAS HAPPEN PRIOR TO 2001 & 2002. I HOPE TO GET SOMETHING RESOLVED. *TR

MY HYUNDAI SANTA FE 2003, 4 CYLINDER, 2.4 LITER ENGINE STALLED 4 TIMES. ENGINE LIGHT CAME ON. I TOOK IT TO SERVICE DIAGNOSED WITH CRANK PRECISION SENSOR. NO COVERED UNDER WARRANTY. DOING RESEARCH I FOUND OUT THAT THE 2001 AND 2002 WAS RECALLED FOR THIS MATTER. ALSO FOUND OUT THAT MANY 2003'S ARE HAVING THE SAME PROBLEM. ALSO I FIND IT DISTURBING THAT HYUNDAI WONT COVER THIS BECAUSE IT IS AND ELECTRONIC PART BUT THE ENGINE CAN JUST STALL AT ANY MOMENT. BECAUSE IT WAS RECALLED 2YRS PRIOR SHOULD RAISE A RED FLAG. I WILL BE CALLING HYUNDAI CORP. THANK YOU SORAYA GARCIA *TR

THE AIR BAG RED WARNING LIGHT CAME ON IN 9/08. THE DEALER SCANNED THE SYSTEM, CLEARED HISTORIC CODES, CYCLED THROUGH SELF TEST SEVERAL TIMES. CODES DID NOT RESET. LIGHT CAME BACK ON IN 1/09. I WILL TAKE VEHICLE BACK TO DEALER. MY OPINION IS THAT SAFETY EQUIPMENT SHOULD BE MORE RELIABLE . WHEN THE RED LIGHT INITIALLY CAME ON THEY COULDN'T FIND A PROBLEM BUT I WILL BE CHARGED APPX. $600 WHEN THEY FIX THE PROBLEM. *TR

THE VEHICLE JERKED VIOLENTLY AND THEN SUDDENLY STALLED SEVERAL TIMES ON THE HIGHWAY AT SPEEDS AROUND 60 MPH, CAUSING DANGEROUS DRIVING CONDITIONS. A FEW DAYS LATER THE VEHICLE WOULD NOT START AT ALL. THE VEHICLE WAS BROUGHT TO A REPAIR FACILITY AND IT WAS DISCOVERED THAT THE CRANKSHAFT POSITION SENSOR WAS CRACKED AT THE SENSOR END NEAR THE CRANKSHAFT AND TIMING BELT. REPLACING THE PART WAS LABOR INTENSIVE SINCE SEVERAL ENGINE COMPONENTS HAD TO BE REMOVED TO REACH THE SENSOR, THEREFORE THE REPAIR COSTS WERE HIGH. THE DEALERSHIP WANTED AROUND $1,000 TO REPLACE WITH THE PART ONLY COSTING $90. I BROUGHT THE VEHICLE TO AN INDEPENDENT REPAIR SHOP AND HAD THE CRANKSHAFT POSITION SENSOR REPLACED, THE VEHICLE NOW STARTS. BOTH THE HYUNDAI DEALERSHIP AND HYUNDAI MOTOR AMERICA REFUSED TO COVER REPAIR COSTS WHILE THE VEHICLE WAS IN NEED OF REPAIR AND BEFORE I BROUGHT IT ELSEWHERE. BOTH DEALER AND MANUFACTURER CONTINUE TO REFUSE NOW TO REIMBURSE COSTS AFTER I HAD TO GO TO A LESS COSTLY REPAIR FACILITY. MY CASE # WITH HYUNDAI MOTOR AMERICA IS #3467755. I HAVE ALSO CONTACTED THE ALTERNATIVE DISPUTE RESOLUTION LINE AT THE BETTER BUSINESS BUREAU. I NOTIFIED THE REPRESENTATIVE AT HYUNDAI THAT THIS SAME PART WAS RECALLED ON THE 2 PRIOR YEARS MODELS OF SANTA FE (NHTSA CAMPAIGN ID# 03V520000) AND THAT NUMEROUS COMPLAINTS WERE MADE TO NHTSA FOR THE SAME PROBLEM WITH 2003 CRANKSHAFT POSITION SENSORS. CURRENT NHTSA ODI COMPLAINT #'S THAT ARE NEAR EXACT MATCHES FOR THE 2003 MODEL ARE ODI ID# 10238818, 10176719, 10133625, AND 10115680. SIMILAR ARE #10203556, 10199900, 10195530, 10183323, 10128836, AND 10050501. ALSO SEE NHTSA CAMPAIGN ID 03V520000 AND THE EPA RECALL #1791 - MFR# 49. A SIMILAR RECALL WAS DONE IN CANADA, SEE TRANSPORTATION CANADA RECALL #2002008, CAMPAIGN CODE R33. APPARENTLY THE PART CONTINUED TO DEFECTIVE AT THE POINT OF MANUFACTURER IN THE 2003 MODELS AS WELL. HIGH SPEED STALLS AND VIOLENT JERKING POSING RISK OF INJURY AND DEATH. *TR