2012 HYUNDAI SANTA FE Complaints

I was contacted by Auffenberg Hyundai in OFallon IL in October of 2024 to schedule recall work. On 10/23/24, the car was dropped off in working condition to the dealership for that recall (engine software update). The day after the vehicle was returned, the check engine light came on and the vehicle went into "limp mode". I returned it to the dealership 10/24/24. They changed the knock sensor and I picked it back up on [XXX]. On the same date, the check engine light came on and vehicle went back into "limp mode". Car was returned to dealership 10/28/24, due to the issue being after hours and on a weekend. They tested it and reset software. I did not get vehicle back until 1/3/25. On [XXX], the check engine light came on again and vehicle went into "limp mode". Car was returned to the dealership and now it is 3/17/25 and I still have no resolution. The vehicle is unsafe to drive because in "limp mode" you cannot go above a certain RPM level. Pulling out into traffic is dangerous when your vehicle just will not accelerate. If this were to happen on the interstate, then it could be catastrophic. The dealership has been able to reproduce this issue, but offers no fix as they state that they are being limited by corporate Hyundai. A corporate claim was made but Hyundai is unwilling to fix an issue they caused. In essence, the recall broke my vehicle and corporate Hyundai has decided to do nothing. Note: All records for repairs and dealership/corporate communications are with Auffenberg Hyundai, 1050 Berg Blvd, Ofallon IL 62269; phone 618-622-9001; contact is John Koch. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Windows issues multiple times. The first time the driver side front window would occasionally go up then automatically down when I tried to raise the window. Likewise when I tried to open the window it would go up and down. Dealer couldn’t identify a problem since it was occasionally an issue. Then when it finally no longer worked at all it was repaired. Now the driver side window has malfunctioned for the second time with no warning stuck in the closed position. I also had the driver side rear window malfunction. The window just dropped down into the door without warning and without trying to operate it at all. The dealer fixed the first two instances but not the third. I’m guessing it may have been covered under the 10 yr warranty in the past. My fault I guess I should have brought my car to the dealer in 2020 when it happened. (COVID and other reasons)

My engine stalls while driving. Now engine is knocking real loud. Then stall again. My safety and others drivers safety because my engine stalls could cause a crash, wreck. Mechanic listened to engine, said engine is knocking and stalling, this is a safety issue. Vehicle has not been inspected by manufacturer, or others. No warning lights, symptoms, Monday December 30, 2024.

NHTSA Recall #20V746000 2012 Hyundai Sonata Manufacture Recall #198 Connecting Rod Bearing failure leading to possible road side fire. Possible risk of injury or death. Hyundai has been contacted twice about recall. Claim they have no responsibility to comply with recall. They closed the dealership where the car was purchased new. They offer two other dealers that are located in other cities. One requires driving a distance of over 200 miles. The other requires round trip ferry travel. Mileage would still be approximately 150 miles plus ferry expense plus fuel expense and possible an over night lodging at $150 to $200 per night and one to two day obligation. It is a total lie that Hyundai will correct their negligence at no cost to the owner. Their first representative informed me that all transportation cost were the owners responsibility. Regardless of the apparent negligence and obvious risk to the public safety, the company apparently disregarded an engine flush after maching as a cost saving practice. I believe every qualified machinest would know that metal chips left over from this process could not left in a finished motor. Just stupid but might have saved a few dollars. I'm a [XXX] man with [XXX] and [XXX] that make sitting for hours impossible. There is no one willing or able to spend this time commitment no money laying around for this expense. Hyundai knows that. Very fast to say "Not my PROBLEM. Car has very low mileage. Engine check light is on. Hyundai will not guarantee if the car is safe or even able to be driven that far. The solution is very simple....... The local deal handles many different auto brands. I'm sure the Hyundai qualified mechanics are still employed. Knowing this, Hyundai refuses to allow local people to install this device that does not correct the problem. Just lets the driver know it's serious. Another cost saving decision due I'm sure because they don't want to pay. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),

My engine caught on fire in the middle of the night ([XXX] on [XXX]). The fire department was called by my building’s security and they came to put out the fire. The security footage shows that the car engine caught on fire for no apparent reason. The fire department did not identify any foul play or vandalism nor did the security camera footage. Unfortunately since my car has been paid off, I only had liability coverage and could not get the coverage to assess. I had to junk the car. No one was hurt but there was broken glass and some parts around the parking lot due to fire and fire department having to shatter and pry open the engine bay. Please advise if someone can help me in my situation. Also this should be made aware to Hyundai. There was a recall but I was never notified. Nor does any recall history show up for this. See article: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2012 Hyundai Santa Fe. The contact stated that the vehicle was experiencing electrical failures. The contact stated that the 12 Volts battery was replaced several times. Additionally, the contact stated the battery terminals were corroded only few weeks after the battery replacement. The vehicle was taken to several independent mechanics, where the cause of the battery failures could not be determined. The battery was replaced; however the failure persisted. The vehicle was not repaired. No further information was provided. The manufacturer was not notified of the failure. The failure mileage was approximately 45,000.

Getting occasional knocking sound while vehicle is running and immediately even when the vehicle is turned off. Sound is emanating from the rear of the vehicle (gas tank).

Purchased this used 2012 Santa Fe directly from Hyundai last January (2023) We have had to continually fill it up with oil. Two months ago, driving to work and the car stops accelerating and felt like the “power was going out”. I was on a busy highway early in the morning when it died on me. Took it to a nearby mechanic and it threw engine failure pins. There was no oil so we added more oil and it drives but will not exceed 50 mph and goes out at any given time.

I have complained about this previously to recall, and it's doing it again. My engine shut off while driving its happened on the Fred harrman bridge twice now. All the dashboard lights come on and the engine shuts off I had to put it in neutral and restart it. It very dangerous and scarey experience. Also one of my passerger head light doesn't come on sometimes and the back driver side tail light. I can get out and hit it then it will come on. I have been pulled over by the police for it once before I told them it works just hit it. He did told me to get that fixed and gave me a warning. I can't afford to eletbeledtrical done little alone an engine please help. Call should have the first report as well.

I took my 2012 Hyundai Santa Fe into the dealership on March 7, 2024. The engine had failed due to the failure of the connecting rod bearing that is under recall. On April, 6th 2024 I was called that my car was ready. As I got into the car there was a coffee cup, a water bottle, and a long nose plier left in my vehicle. Then I noticed that the tire pressure warning light was on. I went back to the service department, and they went to refill the air. Note the paperwork shows that it had already been done. I got the car back and proceeded to leave, I traveled about two blocks before turning around. The right front turn light was out, and the car made a vibrating noise, and didn't have the same feel as before I had the engine problem, they took it back in to look at the vehicle again. They fixed the turn light. Told me the problem with the TPMS was the batteries inside it. As for the vibration and poor handling I was told the vehicle needed new motor mounts, and said they would fix it for three thousand dollars. Looking up the part numbers of these motor mounts, they are labeled as engine mounts, the engine is what was replaced. None of these problems existed before I brought my car in. The last item on the paperwork was that of a multipoint inspection. If they had inspected my vehicle, these problems would have been found before returning my car to me. I don't feel safe driving my car.