2008 HYUNDAI SANTA FE Complaints

I ALSO HAD THE FUEL SENSOR GO OUT AND HAD IT FIXED. AND I HAD TO HAVE MY ALTERNATOR REPLACED TWICE. ONCE WHEN IT WENT OUT AND AGAIN IN 9 MONTHS DUE TO RECALL FOR A FUEL GASKET COVER DEFAULT. SO I PAID THE FIRST TIME OUT OF POCKET $700 ONLY TO FIND OUT IT WAS PROBABLY DUE TO THE DEFAULT. LYNDA

FUEL LEVEL SENSOR FAIL. THE GAS GAUGE DROPS FROM FULL TO 1/4 TANK TO 3/4 TANK. THE "RANGE" DISPLAY WILL GO FROM EMPTY TO 300 MILES LEFT TO 79 MILES LEFT. ALL OVER THE PLACE. IT WILL SAY YOUR FULL AND YOU ARE EMPTY IT WILL SAY YOUR EMPTY AND YOU ARE FULL. THIS HAPPENED WHILE YOU ARE IN MOTION ON ANY ROADWAY AT ANY SPEED AND ALSO WHEN YOU TURN THE CAR OFF AND BACK ON. UPDATED 12/16/15.*JB

WHILE ACCELERATING TO GET ON THE HIGHWAY THE VEHICLE RAPIDLY ACCELERATED WITHOUT PRESSING THE GAS PEDAL. WHEN THIS OCCURRED THE PEDAL STARTED GOING TO THE FLOOR. PRYING UP ON THE PEDAL WITH YOUR FOOT DID NOT HAVE AN AFFECT. THIS HAS HAPPENED TWICE AND THE DEALER HAS LOOKED AT IT TWICE AND HAS ADVISED THAT THEY COULD NOT FIND A PROBLEM.

CHECK ENGINE LIGHT CAME ON. I THEN NOTICED WHEN THE LOW FUEL LIGHT CAME ON AND I FILED THE TANK IT ONLY TOOK 12 GALLONS INSTEAD OF THE USUAL 15-16. I CALLED THE DEALER AND THEY IMMEDIATELY STATED IT WAS THE FUEL LEVEL SENSOR. CAUSING BOTH ISSUES. IT MUST BE A COMMON ISSUE. $500 QUOTED REPAIR. NOW WHEN THE LIGHT COMES ON AND YOU FILL IT TAKES BETWEEN 10 AND 12 GALLONS. NOT SURE IF THAT MEANS THERE WAS 4-6 IN THE TANK OR SOMETHING ELSE IS RESTRICTING THE VOLUME OF FUEL YOU CAN ADD. CHECK ENGINE LIGHT COMES ON AND GOES OFF INTERMITTENTLY. ALSO THE LOW FUEL NIGHT MAY COME ON AND THE GAUGE SHOWS NEARLY EMPTY AND THEN IT MIGHT GO OFF AND SHOW 1/4. IS IT EMPTY OR IS IT A QUARTER. MILEAGE ON THE CAR ABOUT 63000.

FUEL GAUGE STOPPED WORKING AND SERVICE ENGINE LIGHT IS ON. FUEL GAUGE NOW READS EMPTY EVEN IF TANK IS FULL. THIS IS A SAFETY ISSUE AS AMOUNT OF GAS IN TANK IS UNKNOWN AND SHOULD BE RECALLED BY HYUNDAI.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CLOCK SPRING SWITCH NEEDED TO BE REPLACED. IN ADDITION, THE TECHNICIAN MADE THE CONTACT AWARE THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V472000 (AIR BAGS). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 112,000.

THE ISSUE BEGAN ABOUT A MONTH AGO DURING A LONG INTERSTATE TRIP. IF THE FUEL GAUGE REACHED THE 1/4 TANK MARK, IT WOULD PLUMMET TO EMPTY. AS THE CAR RAN, THE GAUGE WOULD RISE UP AND FALL AGAIN REPEATEDLY. SOMETIMES WHEN THE CAR WAS STARTED (EVEN WITH A FULL TANK), THE GAUGE WOULD NEVER RISE ABOVE "E." THANKFULLY, THE CAR NEVER STALLED AND ALWAYS STARTED. I JUST HAD IT SERVICED TODAY. BOTH SENDING UNITS WERE REPLACED AND WAS TOLD BY A HYUNDAI DEALER THAT THEY KEEP THESE PARTS (FUEL SENSORS) IN STOCK DUE TO THE HIGH FREQUENCY OF CALLS THEY RECEIVE FROM OTHER OWNERS WITH THIS SAME PROBLEM. SURPRISED THERE HAS BEEN NO RECALL ISSUED YET!

WHEN THE GAS TANK IS LESS THAN HALF FULL, THE FUEL GAUGE DISPLAYS TANK AS NEARLY EMPTY AND THE AMBER LOW FUEL LIGHT APPEARS. THE CHECK ENGINE WARNING LIGHT ALSO COMES ON. THE FUEL GAUGE SWINGS BACK UP TO NEARLY HALF FULL, DROPS DOWN TO 1/4 FULL, THEN DROPS DOWN TO ALMOST EMPTY, THEN SWING BACK TO HALF FULL. AFTER FILLING THE TANK THE FUEL GAUGE IS ONCE AGAIN ACCURATE UNTIL THE TANK GOES BELOW 1/2 FULL. . THIS IS A FUEL SENSOR ISSUE WITH THE TWO SENSORS IN THE GAS TANK. I'M GOING TO HAVE TO RESET THE ODOMETER EVERY TIME I FILL UP AND MAKE SURE I FILL UP THE TANK EVERY 300-325 MILES. I'VE DONE MY RESEARCH AND THIS IS A KNOWN, WIDESPREAD ISSUE WITH THE 2008 HYUNDAI SANTA FE VEHICLES. I SAW MANY COMPLAINTS ABOUT THIS ISSUE FILED ON THE NHSTA SO THIS AGENCY IS WELL AWARE OF THE ISSUE BUT HAS CHOSEN NOT TO RECALL THE SANTA FE FOR THE 2008 MODEL YEAR. I DON'T UNDERSTAND THIS: THIS IS A SAFETY ISSUE AS WELL AS A GROSS DESIGN AND MANUFACTURING PROBLEM WITH THIS VEHICLE.

WHEN THE GAS TANK IS LESS THAN HALF FULL, THE FUEL GAUGE DISPLAYS TANK AS NEARLY EMPTY AND THE AMBER LOW FUEL LIGHT APPEARS. THE CHECK ENGINE WARNING LIGHT ALSO COMES ON. THE FUEL GAUGE SWINGS BACK UP TO NEARLY HALF FULL, DROPS DOWN TO 1/4 FULL, THEN DROPS DOWN TO ALMOST EMPTY, THEN SWING BACK TO HALF FULL. ABOUT 3 MONTHS AFTER THIS PROBLEM STARTED, THE FUEL GAUGE REMAINS NEAR EMPTY WITH THE AMBER LOW FUEL LIGHT LIT. WHEN I FILL UP THE GAS TANK, THE FUEL GAUGE IS ONCE AGAIN ACCURATE UNTIL THE TANK GOES BELOW 1/2 FULL. HOWEVER, THE CHECK ENGINE LIGHT REMAINS ON AT ALL TIMES AND CAN ONLY BE CLEARED BY A MECHANIC. I'VE HAD MY MECHANIC CLEAR IT TWICE. THIS IS A FUEL SENSOR ISSUE WITH THE TWO SENDERS IN THE GAS TANK. I WAS GOING TO HAVE THIS REPAIRED BY HAVING THE FUEL PUMP ASSEMBLY REPLACED BUT FOUND OUT IT WOULD COST $1000. I CAN'T AFFORD THAT SO I'M STUCK. I'M GOING TO HAVE TO RESET THE ODOMETER EVERY TIME I FILL UP AND MAKE SURE I FILL UP THE TANK EVERY 300 MILES. I'VE DONE MY RESEARCH AND THIS IS A KNOWN, WIDESPREAD ISSUE WITH THE 2008 HYUNDAI SANTA FE VEHICLES. I SAW MANY COMPLAINTS ABOUT THIS ISSUE FILED ON THE NHSTA SO THIS AGENCY IS WELL AWARE OF THE ISSUE BUT HAS CHOSEN NOT TO RECALL THE SANTA FE FOR THE 2008 MODEL YEAR. I DON'T UNDERSTAND THIS: THIS IS A SAFETY ISSUE AS WELL AS A GROSS DESIGN AND MANUFACTURING PROBLEM WITH THIS VEHICLE. WE BOUGHT THIS VEHICLE USED WITH NO KNOWLEDGE OF THIS. THE FUEL GAUGE STARTED BEHAVING ERRATICALLY A LITTLE OVER A YEAR AFTER WE BOUGHT IT IN MAY 2014, WHICH WOULD BE AROUND LATE JULY 2015. HE FIRST SIGN OF A PROBLEM OCCURRED AFTER I FILLED THE GAS TANK IN LATE JULY 2015. THAT WAS THE FIRST TIME THE CHECK ENGINE LIGHT CAME ON EVEN THOUGH THE GAS TANK WAS FULL. I HAD MY MECHANIC CLEAR IT. THIS SAME THING HAPPENED ABOUT 6 WEEKS LATER. AFTER THAT THE ERRATIC FUEL GAUGE BEHAVIOR I DESCRIBED STARTED OCCURRING.

LATE LAST YEAR (2014) MY GAS GAUGE SUDDENLY SHOWED EMPTY (WITH EMPTY LIGHT COMING ON) ON MY 2008 HYUNDAI SANTA FE GLS 2..3 L ENGINE. IN ADDITION, THE 'CHECK ENGINE' CAME ON AND STAYED ON. I TOOK VEHICLE TO MY MECHANIC, WHO TOLD ME THE FAIL CODES RELATED TO THE A AND B SENSORS IN THE FUEL TANK NOT FUNCTIONING PROPERLY. THE COST OF THE REPAIR WAS ESTIMATED AT AROUND $700.00. MY VEHICLE IS NO LONGER UNDER ANY WARRANTY. I ASKED IF THIS DEFECT IS CAUSING ENVIRONMENTAL PROBLEMS OR OTHER PROBLEMS THAT COULD CAUSE ENGINE DAMAGE, ETC. AND HE SAID NO. I SAID WELL, I COULD LIVE WITH THIS BY ZEROING OUT MY TRIP INDICATOR AND KEEPING TRACK THAT WAY, KNOWING MY APPROXIMATE MPG. (I LIVE IN WISCONSIN ON THE LAKESHORE AND WE ARE UNDER MANDATORY EMISSIONS TESTING DUE TO THE POLLUTED AIR COMING UP FROM ILLINOIS AND BEING TRAPPED BY LAKE MICHIGAN.) HE TOLD THAT NEXT YEAR (CURRENT 2015), MY VEHICLE WOULD NOT PASS EMISSIONS BECAUSE THE 'CHECK ENGINE' LIGHT IS ON! NOW AS REGISTRATION IS DUE IN NOVEMBER, I HAVE TO GET IT FIXED. FIRST OFF, I BELIEVE THIS IS A SAFETY ISSUE BECAUSE IF I FORGOT TO ZERO OUT MY TRIP ODOMETER AND RAN OUT OF GAS IN TIN-BUK-TWO, I OR MY WIFE (WHO DOESN'T HAVE A CONCEALED CARRY PERMIT) COULD BE STRANDED IN A DANGEROUS AREA. SECONDLY, I GET SCREWED ON NOT BEING ABLE TO REGISTER MY VEHICLE DUE TO A NON-EMISSIONS RELATED ISSUE.