2007 HYUNDAI SANTA FE Complaints

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE DRIVING AT 15 MPH, THE CONTACT NOTICED A LOUD CLICKING SOUND FROM THE FRONT DRIVER SIDE OF THE VEHICLE. THE FAILURE ALSO OCCURRED WHILE IN REVERSE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT LOWER CONTROL ARM BUSHINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 116,595.

ALL OF THE SUDDEN MY GAS GUAGE STARTED TO FLUCTUATE IN ITS READINGS. I NOTICED ONE DAY MY GAS LIGHT WAS ON--STATING MY GAS TANK WAS EMPTY AND I KNOW I HAD GAS IN THE TANK. I ENDED UP GOING TO THE GAS STATION AND FILLED THE TANK. MY GUAGE READ FULL FOR A DAY THEN MY GAS LIGHT WENT ON (EMPTY). AS I DROVE THE CAR I NOTICED THE GAS GUAGE SLOWLY RISE TO THE CORRECT READING OF "FULL". THE FLUCTUATION IN THE READINGS ARE CONSTANT. THIS IS VERY FRUSTRATING AND CONCERNING TO ME, AS I DRIVE CHILDREN AROUND AND CANNOT RELY ON MY GAS GUAGE TO GIVE ME AN ACCURATE READING. I AM CONSTANTLY GOING TO THE GAS STATION JUST TO MAKE SURE THAT I DO HAVE GAS. THIS ISSUE CAUSED MY ENGINE LIGHT TO COME ON. IF I RUN OUT OF GAS ON THE FREEWAY, OR OFF IN THE DESERT HERE, IT COULD BE FATAL.

THE FRONT RIGHT DRIVEAXLE BROKE, RESULTING IN THE FRONT TIRE FALLING OFF. I HAD TO REPLACE THE DRIVESHAFT, THE BALL JOINTS, CONTROL ARM, SERPENTINE BELT AND ALTERNATOR BELT AND PAY FOR AN ALIGNMENT, FOR A TOTAL COST OF $876.01. AT THE TIME OF THE INCIDENT, THE VEHICLE WAS TRAVELING AT APPROXIMATELY 1 MPH. 30 MINUTES PRIOR TO THAT, I WAS TRAVELING AT 70 MPH WITH MY FAMILY. CAN YOU IMAGINE YOUR TIRE FALLING OFF AT 70 MPH? HYUNDAI HAS BEEN CONTACTED AND HAS CHOSEN TO IGNORE MY REQUEST FOR REIMBURSEMENT. HOWEVER, THEY HAVE ISSUED A RECALL FOR THE 2013 FOR THE SAME ISSUE.

BACK IN 2011, MY DRIVER'S SIDE SUN VISOR FAILED (THE BRACKET BROKE AT THE ELBOW WHERE THE PLASTIC IS MOLDED AROUND THE BRACKET). IN LOOKING AT THE PART, I NOTED THAT THE QUALITY/GAUGE OF THE BRACKET WAS NOT VERY ROBUST. I WAS AN EMPLOYEE OF FIRST PRINCE AND THEN JOHNSON CONTROLS, AND AM VERY FAMILIAR WITH SUN VISORS AND THE BRACKETS THAT SUPPORT THEM. BASED ON MY OBSERVATIONS, THE DESIGN IS INFERIOR AND IS NOT ROBUST ENOUGH TO LAST THROUGH THE LIFETIME OF THE VEHICLE. THE REASON I'M WRITING TO YOU NOW, IS THAT MY PASSENGER SIDE VISOR ALSO FAILED RECENTLY, WITH DAMAGE IN THE EXACT SAME AREA. I AM ALSO NOTING THAT THE DRIVER'S SIDE BRACKET IS STARTING TO WEAKEN, AS IT WILL FREQUENTLY NOT STAY IN A LOCKED UP POSITION. THIS WAS THE SAME SYMPTOM EXHIBITED BEFORE THE FIRST DRIVER SIDE VISOR FAILED. IN MY OPINION, THERE HAS TO BE AN EXCESSIVELY HIGH FAILURE RATE FOR THIS PART AND AS THE REPLACEMENT IS EXPENSIVE (APPX. $240), I FEEL THERE IS A RISK AND PERHAPS ALREADY OCCURRENCE OF A RISK OF THE BRACKET FAILING WHILE DRIVING AT HIGH SPEED, AND/OR A DRIVER WHO'S VISOR FAILED, HAVING VISION IMPAIRED BY THE SUN AND BECOMING INVOLVED IN AN ACCIDENT. I BELIEVE YOU SHOULD LOOK AT THE REPLACEMENT RATE FOR THIS PART ACROSS NOT ONLY THIS MODEL, BUT ALL OTHER'S AS I NOTE THAT FREQUENTLY THE DESIGN OF AN ELBOW BRACKET CROSSES OVER MULTIPLE PLATFORMS.

ALL OF THE SUDDEN MY GAS GUAGE STARTED TO FLUCTUATE IN ITS READINGS. I NOTICED ONE DAY MY GAS LIGHT WAS ON--STATING MY GAS TANK WAS EMPTY AND I KNOW I HAD GAS IN THE TANK. I ENDED UP GOING TO THE GAS STATION AND FILLED THE TANK. MY GUAGE READ FULL FOR A DAY THEN MY GAS LIGHT WENT ON (EMPTY). AS I DROVE THE CAR I NOTICED THE GAS GUAGE SLOWLY RISE TO THE CORRECT READING OF "FULL". THE FLUCTUATION IN THE READINGS ARE CONSTANT. THIS IS VERY FRUSTRATING AND CONCERNING TO ME, AS I DRIVE CHILDREN AROUND AND CANNOT RELY ON MY GAS GUAGE TO GIVE ME AN ACCURATE READING. I AM CONSTANTLY GOING TO THE GAS STATION JUST TO MAKE SURE THAT I DO HAVE GAS. THIS ISSUE CAUSED MY ENGINE LIGHT TO COME ON AND AS A RESULT CANNOT PASS EMISSIONS UNTIL I GET THIS FIXED.

I PURCHASED THIS VEHICLE USED IN AUGUST OF 2015 AND WHEN I FILLED THE CAR UP I NOTICED THE FUEL GAUGE DIDN'T READ FULL. WITHIN A FEW MINUTES THE FUEL HAND DROPPED BELOW HALF FULL. I HIT THE TRIP BUTTON TO SEE WHAT THE RANGE DISPLAY WAS REPORTING AND IT WAS DROPPING LIKE A ROCK (STARTED AT 200+ MILES AND DROPPED DOWN TO LESS THAN 100 MILES). THEN A FEW MINUTES AFTER THAT THE EMPTY LIGHT CAME ON AND THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO AUTOZONE AND THEY DIAGNOSED IT WITH A P0460. THIS APPEARS TO BE A FREQUENT PROBLEM ON THIS MODEL CAR. I CAN'T UNDERSTAND WHY THIS IS NOT A RECALL SITUATION. IT IS POSSIBLE TO RUN OUT OF GAS WHILE MOVING (ON EXPRESSWAY) WHICH COULD CAUSE A MAJOR ACCIDENT.

MY GAS GAUGE STARTED MALFUNCTIONING EARLIER IN 2015, THEN IT TOTALLY WENT OUT BY MAY OF 2015. NOW, IT WORKS WHEN IT WANTS TO, BUT IT'S NEVER REALLY RIGHT. MY TRIP GAUGE DOESN'T WORK EITHER. THANKS TO THIS ISSUE, I FAILED MY SMOG TEST, THEY SAID THAT MY GAS TANK SENSORS NEED TO BE REPLACED. I GOT AN ESTIMATE OF NEARLY $1000 TO COMPLETE THIS PROCEDURE THAT LOTS OF OTHER OWNERS HAVE HAD PROBLEMS WITH. WHY ISN'T THIS A REPAIR COVERED BY HYUNDAI? DO YOU BUILD YOUR PRODUCTS TO LAST LONG ENOUGH TO MAKE IT THROUGH YOUR WARRANTY PERIOD? I'VE NEVER HAD TO REPLACE THIS WITH PREVIOUS VEHICLES.

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE DRIVING 50 MPH, THE DRIVER SIDE SUN VISOR DETACHED AND OBSTRUCTED THE DRIVER SIDE VIEW. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVER SIDE SUN VISOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

WHILE DRIVING THE FUEL GAUGE DROPPED TO EMPTY. THEN THE CHECK ENGINE LIGHT CAME ON. I HAD TO CODE READ AT A LOCAL AUTOMOTIVE STORE. THE PRICE OF THERE PART WAS 350. I CAN ONLY IMAGINE WHAT A DEALER WILL CHARGE. HE TOLD ME IT WAS A FUEL LEVEL SENDING UNIT. AFTER RESEARCHING THIS I FOUND LOTS OF COMPLAINTS ON THIS SAME ISSUE. THIS SHOULD NOT BE FAILING THIS SOON.

AFTER STARTING MY VEHICLE AND PROCEEDED TO WORK MY SANTA FE ESC LIGHT CAME ON AND THE CAR WENT INTO A "LIMP MODE". IT SLOWED DOWN TO 10 MPH AND WOULDN'T LET ME ACCELERATE. I PULLED OVER AND I COULD FEEL THE ENGINE SPUTTERING. I TURNED OFF THE ENGINE AND WAITED A MINUTE. TURNED THE ENGINE BACK ON AND PROCEEDED TO WORK WITHOUT INCIDENT. NOW NO MATTER WHEN I DRIVE WHETHER ITS A COLD START OR AFTER 30 MINUTES OF DRIVING THE VEHICLE GOES INTO LIMP MODE. WHILE DRIVING AT A SLOW SPEED ON BACK ROADS IS NOT A SERIOUS ISSUE I FEEL THAT WHEN I AM ON THE HIGHWAY TRAVELING AT 65MPH AND IT HAPPENS IS A MAJOR SAFETY ISSUE. THIS HAS HAPPENED ON NUMEROUS OCCASIONS AND I NO LONGER FEEL SAFE IN MY VEHICLE. I HAVE DONE SOME RESEARCH ON THIS PROBLEM AND I AM NOT THE ONLY ONE. THIS IS A SERIOUS ISSUES THAT I FEEL NEEDS TO BE ADDRESSED BY HYUNDAI IMMEDIATELY BEFORE SOMEONE GETS INJURED OR KILLED.