2017 HYUNDAI SANTA FE Complaints

motor blew up on 2/28/2025 safety was fine three different shops including two dealerships have confirmed a blown motor no warning lights or signs it was going to happen The company is denying my claim under there Extended Warranty Notification they sent me. This is happening to thousands of other customers. Lots of social media sights out there.

2107 Santa fe ultimate engine went to limp mode. I have 92k miles. The Vin shows no recalls. The warranty says 1st buyer. I am 2nd buyer, bought at 33k miles. I need help!!! There is no reason other than defect that my engine should have gone out! I've read plenty of things. Excessive oil consumption, rod bearing wear, crankshaft... I need Hyundai to replace my engine.

Oil consumption problem.hyundai company denied my request for repair all I have all documents.

My 2017 Hyundai Santa Fe had a new engine installed at the dealership, Fred Beans Hyundai Flemington, NJ. I picked it up on [XXX] on [XXX] (and after 134 miles) my car's check engine light came on. I rerouted to dealership about 8 miles. Sitting outside service bay, I smelled smoke and then saw smoke coming out of vents. I then jumped out of car and the car became engulfed in flames and subsequently exploded. The day I picked it up, I pointed out to the service manager that they had not reattached everything to the car properly, sloppy workmanship. Best guess is that they did not attach a valve correctly. Miracle no one was injured or killed! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated on the instrument panel. The contact later added 2 quarts of oil to the engine; however, not too long after adding the oil, the contact checked the dipstick, and the oil had been consumed. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was taken to the dealer to be serviced and the contact was informed that the engine oil was abnormally low. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 98,000.

Was going down the highway at 65 when my vehicle completely lost the accelerating component. Almost got rear ended so I pulled off. Then made it to work when it happened again. The engine light came on and gave 2 codes. Finally got it towed to the dealership where they have decided it’s either a new timing chain or new engine due to mechanical loss. They discovered there was no oil in the car and they have also found metal shavings in my oil. Now they are telling me I need a whole new engine. I only have 124000 miles on this car. The car was driving perfectly fine the day before and had just been to the dealer and looked over 1,500 miles before and I was told everything was perfect working condition. I am out $4000 on a car I bought a year and a half ago in October 2023.Was told my warranty only lasted a year.

Excessive Oil Consumption caused the PCV Sensor/Actuator (Exhaust Camshaft Timing Oil Control Valve) to fail. While the vehicle is still operable, the failure causes engine timing to change resulting unpredictable losses in power during acceleration, excessive fuel consumption, and incomplete combustion passing through the Catalytic Convertor posing a risk for future component failure. In the four months that the vehicle is operating in this condition, with its check engine light on, I have had two near collisions while attempting to merge into roundabouts and freeway entry. Fortunately, both were avoided. I no longer attempt freeway entry during rush hour. Two independent service repair shops did a computer diagnostic test and confirmed the problem with the PCV components. They suggested that the excessive oil condition be corrected first. Otherwise, any replacement components will continue to fail. Excessive oil consumption appears to be a chronic problem in the Hyundai 2.4 L engine. The engine and drivetrain is covered under a 10 year or 100,000 warranty. A year earlier the dealership performed a controlled test when the vehicle only had 60,941 miles, where the initial oil loss was 2.5 quarts per 1,000 miles. An Oil Chamber Combustion Clean, where solvents are used to remove excess carbon was performed. It temporarily reduced the oil consumption to .7 quarts per 1,000 miles. This is still requiring a replacement of about 2 Quarts of oil between routine oil changes in a 5 quart system. The dealership indicated that it passed. About 3 months later the oil consumption increased to 1.0 Quart per 1,000 miles and 8 months later the PCV components failed. If the dealership did the right thing and repaired the engine to eliminate oil consumption, everything would have been fine. I am still trying to get the dealership and Hyundai to honor their warranty. for excess oil consumption. With it the PCV components are also replaced and all is good.

I have only had my car 7 years and it is at 151,000 miles. I purchased it brand new in 2018. At about 15,000 miles I reported a burning smell under the hood and took kt in. The service department stated they did not smell anything. I continued to keep up with the service and had some issues with oil consumption. Hyundai did the test, but came back and advised it was okay and Hyundai's do this and it is okay. I later had an issue where it began jerking as if it were about to cut off after coming back from Virginia. I had it towed in and they advised it was nothing. Maybe bad gas. I was also told to just always check my car to put oil in it. I felt like this was crazy to have to carry around oil to put in my car within the same month of having an oil change or anytime. I have taken this vehicle in for this reason before I reached 150,000 miles and they would not give me an engine starting it necer had a recall. I explained that it has had issues where it stalled pulling out to get in traffic and I almost had an accident and it has had issues with the engine where it would jerk and hesitate. At this time, I recently went to Simpsonville for a funeral and it began the jerking and hesitation when we got into Fountain Inn. It was a lot and I was told by a mechanic that I needed a new engine. Hyundai would not help me. I called consumer affairs, I guesd with Hyundai and they took over 2 weeks and said there were no recalls and they couldn't do anything. I bought this car brand new, made sure I took care of it and this was what I got. Hyundai is a rip off and they do not guarantee anything. I will never buy from them again. Now I have been without a vehicle for over a month and not even anyone trying to get me a loaner, help with giving me a discount to purchase another vehicle or anything. I should have not had any issues with this car. I was having the exact issues of the recall vehicles but they state there were no recalls on it. Something needs to be done.

Vehicle has been excessively consuming oil. I have been doing regular oil changes every 3k miles and topping off when it gets low. I was driving on the highway and experienced total engine failure with no warning signs. Engine completely locked up and is at the dealership waiting to be inspected.

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated while driving at an undisclosed speed, the oil pressure and the check engine warning light illuminated. The vehicle lost motive power and the steering wheel seized. The vehicle was started; however, the vehicle failed to start as intended. The contact stated that the vehicle was stuck in the middle of the road. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 84,000.