2008 HYUNDAI SANTA FE Complaints

WHILE DRIVING ON THE HIGHWAY THE FUEL PROPULSION SYSTEM LIGHT CAME ON AND THE FUEL GAUGE READ EMPTY. HOWEVER, BASED ON MILEAGE AND THE LAST TIME I HAD FILLED THE GAS TANK, I KNEW I SHOULD HAVE CLOSE TO HALF A TANK. THE NEXT MORNING THE GAUGE READ CLOSE TO HALF A TANK. WHILE DRIVING THE FUEL GAUGE MARKED ONCE AGAIN EMPTY. AS A DRIVER, I HAD NO IDEA HOW MUCH GASOLINE THE CAR REALLY HAD. I TOOK THE CAR TO THE DEALERSHIP AND THEY RETRIEVED THE CODE P0469: FUEL LEVEL SENSORS A AND B FAILURE. HYUNDAI DEALERSHIP/WARRANTY DID NOT COVER THE COST OF THE REPLACEMENT, EVEN THOUGH THE CAR ONLY HAD 40, 228 MILES. I HAD TO PAY $600.00 FOR THE REPLCEMENT OF THE TWO FUEL SENSORS.

SAFETY ISSUE: FAILURE OF THE FUEL SENDING UNIT PERMANENTLY TURNS ON THE "CHECK ENGINE LIGHT" WHICH DENIES THE USE OF THE "CHECK ENGINE LIGHT" FOR OTHER SERIOUS CONDITIONS. MANY CONSUMERS HAVE PREVIOUSLY REPORTED THE FAILURE OF THE FUEL SENDING UNIT. THESE UNITS COST BETWEEN $800 TO $1200 TO FIX SO MOST DRIVERS DO NOT FIX IT AND INSTEAD USE THE ODOMETER READING TO DETERMINE WHEN FUEL IS NEEDED. UNFORTUNATELY, DRIVING WITH THE "CHECK ENGINE LIGHT" ON AT ALL TIMES PREVENTS THE DRIVER FROM SEEING THE "CHECK ENGINE LIGHT" ILLUMINATE WHEN A SERIOUS CONDITION EXISTS. THEREFORE, THIS IS A SAFETY ISSUE. CONSIDERING THE NUMBER OF CONSUMER REPORTS ALREADY SENT TO NHTSA REGARDING FAILED FUEL SENDING UNITS, HYUNDAI SHOULD IMMEDIATELY ISSUE A SAFETY RECALL TO FIX THESE UNITS.

FILLED TANK AND READ EMPTY WITH LOW FUEL LIGHT ON. THE NEXT DAY WHILE DRIVING THE MORE I DROVE THE MORE THE FUEL NEEDLE WENT UP UNTIL IT EVENTUALLY READ FULL AND THE LOW FUEL LIGHT WENT OUT. NOW USUALLY WHEN IT GETS DOWN TO ABOUT 1/2 TANK NEEDLE WILL DROP TO EMPTY, FUEL LIGHT WILL COME ON, RANGE INDICATOR WILL READ----AND NOW THE CHECK ENGINE LIGHT COMES AND GOES.

AFTER SEVERAL HOURS OF NORMAL HIGHWAY DRIVING, THE VEHICLE EXPERIENCED A SUDDEN LOSS OF POWER AS THE ENGINE COMPUTER ENTERED "LIMP HOME" MODE. PRESSING THE ACCELERATOR HAD NO EFFECT. DIAGNOSED AS THROTTLE POSITION SENSOR FAILURE. THIS PROBLEM OCCURRED SEVERAL TIMES, WITH AN ENGINE RESTART CLEARING THE PROBLEM TEMPORARILY. WHILE THESE INCIDENTS DID NOT RESULT IN A CRASH, THEY COULD EASILY HAVE, DEPENDING ON TRAFFIC CIRCUMSTANCES.

ERRATIC FUEL GUAGE REGISTRATION. THEN EMPTY WITH LOW FUEL LIGHT ON. TANK HAD JUST BEEN FILLED.

AFTER FUELING UP, TO A FULL TANK, THE FUEL GAUGE STILL REGISTERED EMPTY AND FUEL LIGHT AND CHECK ENGINE LIGHT CAME ON. UPDATED 09/01/2015*LJ UPDATED 10/14/2015 *JS

HYUNDAI SAFETY RECALL CAMPAIGN NO. 103: IN RELATION TO THE ABOVE RECALL, MY VEHICLE DID NOT QUALIFY DUE TO IT BEING MANUFACTURED ON 2 JUNE 2008. MY CLOCK SPRING FOR THE DRIVER'S AIR BAG HAS BECOME INOPERABLE AS INDICATED BY THE AIR BAG LIGHT ILLUMINATION AND DEALER'S DIAGNOSIS. THE DEALER STATES SINCE THERE IN NO RECALL, I MUST PAY FOR THIS PART AND THE DIAGNOSIS BECAUSE I HAVE SURPASSED THE 5YR/60K WARRANTY. THIS IS A SAFETY ISSUE AND I AM SURPRISED IT IS NOT COVERED FOR FREE. AS SEEN WITH THE ABOVE RECALL CAMPAIGN, I WAS A FEW MONTHS SHY OF HAVING IT REPLACED FOR FREE REGARDLESS OF MILEAGE. IS THERE A WAY TO HAVE MY VEHICLE QUALIFY FOR THE RECALL?

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. AFTER REFUELING THE VEHICLE, THE FUEL GAUGE FAILED TO REGISTER THE CORRECT LEVEL OF FUEL. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 106,000.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHEN THE IGNITION WAS TURNED TO THE ON POSITION, THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CLOCK SPRING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000.

THIS VEHICLE HAS DEVELOPED A SPEED SENSITIVE "WHIRRING" SOUND WHILE THE TRANSMISSION IS ENGAGED. WE INITIALLY THOUGHT IT WAS A TIRE NOISE, BUT DID NOT GO AWAY WHEN NEW TIRES WERE INSTALLED. THE DEALERSHIP TOLD US IT WAS THE DRIVE BELT RUBBING AGAINST THE COVER, BUT FURTHER INVESTIGATION BY ANOTHER REPAIR FACILITY FOUND NO EXCESSIVE WEAR ON THE BELT, AND NO INDICATION OF CONTACT WITH THE COVER. THE NOISE IS ACTUALLY COMING FROM THE TRANSMISSION, AND IS EXACTLY AS DESCRIBED IN RECALL 102 WHICH APPLIES TO 2010 MODELS. I PLAN TO START A FIGHT WITH HYUNDAI OVER THIS REPAIR AS THE TRANSMISSIONS ARE THE SAME ON THE 2008 MODELS AS THE 2010.