2009 HYUNDAI SANTA FE Complaints

AT 32,000 MILE THE REAR DRIVER'S SIDE WHEEL SMELLED HOT, BRAKE DUST RESIDUE VISIBLE AND SQUEALING COMING FROM THIS DRIVER'S SIDE REAR WHEEL. FOUND THAT THE DRIVER'S SIDE REAR OUTSIDE BRAKE PAD WAS WORN DOWN TO METAL. DRIVER'S SIDE INSIDE PAD AND PASSENGER REAR PADS, BOTH INSIDE AND OUT WERE FINE WITH HARDLY ANY WEAR ON THEM.. HYUNDAI DEALER SAID IT IS NORMAL FOR REAR DISC PAD TO WEAR THIS UNEVEN AND FOR CALIPER'S TO STICK ON CAUSING THIS. I FEEL THIS IS A DEFECT IN EITHER DESIGN OR QUALITY OF PARTS AS OTHER SANTA FE OWNERS ARE ALSO EXPERIENCING THIS AT EVEN LOWER MILEAGE. DEALER WANTS YOU TO PAY $60 TO HAVE YOUR DISC BRAKES CLEANED AND ADJUSTED (WHAT IS THERE TO ADJUST?) WHY DO ONLY HYUNDAI SANTA FE BRAKES NEED THIS UNHEARD OF SERVICE? WHY IS IT ONLY OCCURRING ON THE DRIVER'S SIDE FOR ME AND OTHER OWNERS? DISC BRAKES SHOULD NOT ACT THIS WAY.

I WAS DRIVING APPROXIMATELY FORTY (40) MILES PER HOUR, IN TRAFFIC, WHEN THE ENGINE SHUT-OFF. I QUICKLY TURNED THE IGNITION TO "OFF" AND THEN BACK ON. THE ENGINE STARTED IMMEDIATELY. I AM EXTREMELY CONCERNED ABOUT BEING IN AN ACCIDENT. THIS HAPPENED AGAIN, WHEN I WAS DRIVING THROUGH A PARKING LOT. I QUICKLY TURNED THE IGNITION TO "OFF" AND THEN BACK ON. THE ENGINE STARTED IMMEDIATELY, ON BOTH OCCASIONS. I TOOK MY VEHICLE INTO PLANET HYUNDAI IN LAS VEGAS, NEVADA, ON AUGUST 7, 2013. THEY COULD NOT IDENTIFY THE PROBLEM WITH THEIR SYSTEMS CHECK AND COULD NOT PRODUCE THE SAME ENGINE SHUT-OFF EVENT, WHILE OPERATING THE VEHICLE. *TR

WHEN ENTERING AN UP-RAMP TO A LIMITED ACCESS HIGHWAY AT SLOW SPEED, LESS THAN 30 MPH, AND TURNING TO THE RIGHT, THE ENGINE SUDDENLY DIED AND POWER WAS LOST TO STEERING AND BRAKES. WE WERE ABLE TO PULL OFF THE ROAD AND RESTART, BUT WERE JUST LUCKY THAT THIS DIDN'T HAPPEN ON A CURVE AT HIGH SPEED OR IN HEAVY TRAFFIC. TOOK THE CAR TO THE DEALER THE NEXT DAY, AND THEY WERE UNABLE TO REPEAT THE PROBLEM. *TR

WHILE DRIVING, DRIVER'S SIDE REAR WHEEL GENERATING A SCREECHING NOISE AND A BURNING SMELL. CHECKED TIRE AND BOTH THE TIRE AND WHEEL RIM WERE RED HOT. TOOK TO HYUNDAI DEALER. SAID CALIPERS NOT SLIDING PROPERLY. THEY CLAIM ON SANTA FE'S YOU HAVE TO BRING THEM IN FOR SERVICE (THE CALIPERS) EVERY 10K OR SO, AS THE REAR CALIPERS HAVE A TENDENCY TO FREEZE. I CHECKED THE INTERNET, AND THERE ARE NUMEROUS POSTINGS ON HYUNDAI SANTA FE OWNERS HAVING SIMILAR PROBLEMS. ALSO AN ARTICLE IN THIS WEEK'S HARTFORD COURANT AUTO SECTION OF A CONSUMER WITH A SIMILAR PROBLEM. IF I HAD NOT PULLED THE CAR OVER AND CHECKED THIS OUT THOROUGHLY, I COULD HAVE HAD A BLOWOUT AS THE HOT TIRE WOULD HAVE EXPLODED. THERE MAY BE A DEFECT IN SANTA FE CALIPERS. A SAFETY RECALL MAY BE IN ORDER. *TR

I WAS A PASSENGER IN THE VEHICLE WHEN IT CRASHED INTO A FIRE HYDRANT DOING APPROXIMATELY 40MPH. THE SEATBELT FAILED TO LOCK AND THE AIRBAGS FAILED TO DEPLOY. THE CAR HAS MAJOR DAMAGE TO THE UNDERBODY, FRONT-END, THE INSIDE OF THE VEHICLE DASH, THE MOTOR MOUNTS, ENGINE AND OTHER DAMAGES ARE UNKNOWN AT THIS TIME. *TR

I WAS A PASSENGER IN MY VEHICLE ON THE WAY TO THE LICENSE BRANCH AND WAS SITTING STILL AT A STOP LIGHT, WHEN A VEHICLE REAR-ENDED MY CAR. *TR

WHILE SLOWING DOWN, APPLYING BRAKES TO EXIT THE HIGHWAY INTO THE CLOVERLEAF OFF RAMP, STEERING BECAME VERY DIFFICULT AND I WAS FORCED TO CONTINUE IN THE CURRENT DIRECTION OFF THE ROAD INTO THE GRASS. UPON STOPPING NOTICED DASH LIGHTS WERE ON AND THE VEHICLE HAD STALLED. I WAS VERY LUCKY THAT I WAS HEADED INTO A GRASSY AREA AND NOT INTO A WALL AS I COULDN'T STEER IN ANY OTHER DIRECTION FROM WHEN I LOST POWER. HYUNDAI FOUND NO ERROR CODES AND COULDN'T REPLICATE THE PROBLEM. PLEASE SEE THE FOLLOWING LINKS FOR PAGES OF SIMILAR EXPERIENCES WITH HYUNDAI SANTA FE: 15 PAGES OF RELATED ISSUES - HTTP://WWW.HYUNDAI-FORUMS.COM/187-CM-2007-2012-SANTA-FE/133580-2011-SANTA-FE-STALL-WHILE-DRIVING-13.HTML ANOTHER - HTTP://WWW.CARPROBLEMZOO.COM/HYUNDAI/SANTAFE/ENGINE-STALL-PROBLEMS.PHP. *TR

DRIVING ON HIGHWAY, ESC LIGHT & CHECK ENGINE LIGHT ILLUMINATED, CAR LOST POWER. AFTER APPROXIMATELY 2 MINUTES, CAR RESTARTED AND RETAINED POWER FOR APPROXIMATELY ONE YEAR. THIS YEAR, THE CAR HAS DUPLICATED THE SAME PROBLEM 4 TIMES WITHIN A MONTH, AND WHEN FOOT ON BRAKE IN DRIVE, THE CAR SURGES SO BADLY THAT AT TIMES I THOUGHT SOMEONE HAD BUMPED THE REAR OF CAR. I TOOK TO DEALER TODAY AND THEY REPLACED THE THROTTLE POSITION SENSOR UNDER WARRANTY. THIS WAS VERY MUCH A SAFETY CONCERN , WOULD OFTEN HAPPEN THIS YEAR WHEN VEHICLE WAS SLOWING, SO THAT MAKING A LEFT TURN PUT ME IN A DANGEROUS SITUATION.THE REPLACEMENT OF THE THROTTLE SENSOR SEEMS TO HAVE REMEDIED THE PROBLEM. *TR

WHILE TRAVELING I HEARD A HIGH PITCH SQUEALING NOISE. UNSURE OF WHAT THE NOISE WAS, I TOOK THE SANTA FE TO MY MECHANIC. HE CHECKED THE BRAKES AND SHOWED ME THAT THE REAR DRIVER SIDE BRAKE HOUSING DID NOT MOVE AS FREELY AS THE OTHERS. HIS SUGGESTION WAS TO NOT DRIVE MORE THAN ABOUT 2 HOURS AT A TIME BECAUSE THERE IS THE POSSIBILITY OF THE BRAKE SYSTEM HEATING UP AND CATCHING FIRE. SINCE THE TIRE IS RIGHT BY THE GAS TANK, THAT TELLS ME THERE IS A SIGNIFICANT SAFETY HAZARD. ANY FIRE NEAR GASOLINE HAS THE POTENTIAL TO... I HAVE SEEN MANY SIMILAR COMPLAINTS ON LINE AND FEEL THIS IS A MANUFACTURING DEFECT. *TR

WHILE DRIVING THE VEHICLE IT SHUT DOWN. THE WARNING LIGHTS CAME ON THE DASHBOARD AND THE VEHICLE LOST ALL FUNCTIONS (I.E. ACCELERATION,STEERING, ETC) THE INCIDENT WAS UNDETECTED BY THE DEALERSHIP AND NOT ABLE TO BE DUPLICATED. THE VEHICLE HAS SHUT DOWN SINCE THE INITIAL MALFUNCTION. *TR