2017 HYUNDAI SANTA FE Complaints

The 9C2 campaign software update introduced dangerous vehicle hesitation and unpredictable gear changes in active traffic, presenting and immediate crash hazard

On June 10, 2024 at 107,129 miles Hertrich Hyundai dealership of New Castle inspected my vehicle and submitted a request to Hyundai for engine replacement under the recall settlement of the Theta II Engine Settlement. Hyundai denied the request because of the rebuilt title, even though the rebuilt title resulted only from prior Roof damage unrelated to the engine, powertrain, or recall issue. After continuing to seek assistance from Hyundai, my engine ultimately seized and suddenly stopped working on May 10, 2026, while driving on the highway with my two children. The vehicle lost power and stopped in traffic, creating a dangerous situation and causing my children extreme fear and distress. Had Hyundai honored the Theta II Engine Settlement when I first requested assistance, this failure could have been prevented. I request that Hyundai honor the Theta II Engine Settlement and replace my defective engine at no cost to avoid any future problems. My Hyundai Santa Fe is covered under the Theta II Engine Settlement. For over three years, I repeatedly contacted Hyundai after experiencing symptoms consistent with the known Theta II engine defect. Hyundai failed to provide meaningful assistance, did not properly process my requests, and denied coverage solely because of the vehicle’s rebuilt title.

Odometer Fraud. The contact purchased a 2017 Hyundai Santa Fe Sport. The vehicle was a dealer sale. The contact stated that while attempting to trade the vehicle, the contact was informed by the dealer that the odometer had been rolled back prior to the purchase. The contact had purchased the vehicle in March 2022. A Carfax report indicated that the odometer was reported at approximately 75,585 miles on January 28th, 2022, and 55,710 miles on February 11, 2022, reflecting a 20,000 miles difference. The contact stated that the mileage at the time of purchase was unknown. The vehicle currently had approximately 132,064 miles. The issue was reported to the Pennsylvania State Police and the Pennsylvania Attorney General.

After a recall repair (Campaign 9C2) was performed on my vehicle, it developed a hesitation and lack of acceleration issue that did not exist before the repair. The vehicle exhibits rough or delayed gear shifting, a noticeable lack of power/acceleration, and behavior that feels like the engine is not receiving adequate fuel. This occurs both during cold start and after the vehicle has been driven and is fully warm

We have a 2017 Hyundai Santa Fe Sport with a refurbished engine due to a past class act settlement, we were notified by Hyundai to bring in the vehicle for Service campaign 9C2 to update the Engine Control Module (ECM) Software for vehicles equipped with the (2.4 GDI) Theta II refurbished engine, which we have. The morning after we updated the 9C2 software, after starting our car cold for the first time in the am, our car went into limp mode, shaking very badly, it would not accelerate above 20 MPH, it had a lot of trouble shifting from 1st to 3rd gear and acted like it was going to stall out and then die in the middle of the road while I was in the car with my 2 children. The dealership we took it to was not able to duplicate the limp mode, but has documented that they did witness hesitation and sluggishness while test driving it. I cannot validate that it was test driven cold immediately as requested as all their test drives were done without me. Due to the vehicle not accelerating as it should normally, I feel the vehicle is very unsafe and unreliable as well. I’m willing to provide more documentation, and our car is available for further inspection. I did request the help of a Hyundai customer relations case manager who stated Hyundai is aware of all of the drive-ability issues I have stated and he said they are hoping to provide another software update, but that time frame is unknown. Dealership mechanic stated the same thing and believes our issue is related to the 9C2 update. The manufacture has not inspected the vehicle, but we would absolutely love them to if they would. There have been no check engine lights come on before or after this update, only misfire codes came up after the update which dealership has those, and since the dealership was unable to witness it going into limp mode while driving it, they could not gain the much needed data that pinpoints the exact problem. We were advised to warm up car and rev up the RPM to above 2,000 before driving.

I own a 2017 Hyundai Santa Fe Sport 2.4L (VIN: [XXX]). On XXX, my vehicle received Campaign 9C2 (ECU software update for Theta II emissions improvement). Shortly after this update, I began experiencing a drivability issue that did not exist beforehand. Description of the issue: The problem occurs only after the vehicle has been sitting long enough for the engine to become completely cold, typically overnight. During approximately the first 1/4 mile of driving, the vehicle intermittently jumps, surges, or lurches while accelerating normally. Once the engine warms up, the symptom completely disappears and the vehicle drives normally for the remainder of the trip. There are no warning lights, no check engine light, and no diagnostic messages. The Hyundai dealer has had the vehicle for nearly a week but has been unable to reproduce the concern. Because the issue only occurs during the initial cold start and first portion of the drive, I am concerned that it may not have been tested under the same conditions in which I consistently experience the problem. I am not claiming that Campaign 9C2 caused the issue, but the timing is notable because the symptom began only after the ECU update was performed. I am requesting Hyundai's assistance in determining whether: - the ECU update was installed correctly, - any required adaptation or relearn procedure is incomplete, - there are any related Technical Service Bulletins or software updates, or - additional diagnostics should be performed during a true cold-start drive with live data recording. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On July 4, 2026, I was driving 2.5 hours from home. My car stopped after about an hour of travel. The car shook and the check engine light came on as the car shut down. There were no warning lights on in my vehicle. I have oil change records. My car had burned through all the oil in an hour. This is not a new problem with this model Hyundai. Every group I went to discuss the problem online all had customers who reported their vehicles suddenly started burning oil quickly which resulted in damaged motor with no warning lights in the dashboard. I had to have my car towed from out of town to the dealership. The dealership that said I had extended warranty on parts of the motor. However upon checking the motor, they said it wasn't covered. I filled out a claims report with Hyundai motors who looked into the problem and also said it's not covered under warranty. This is a known issue of Hyundai with a failure to warn of low oil in the car's warning center. This is a fault of Hyundai. I've taken good care of my car and just paid $1000 for new tires on July 2, 2026 before my trip. The dealership quoted me a price of $3500 to replace the motor with a used one. It would also require 16 hours of labor which I Believe is $200 an hour. I believe they should replace the motor due to faulty systems. My car has 107,000 miles on it, but whenever I've gone to have it checked out, everything checked out fine even at the dealership. Also, this is a known issue that Hyundai is refusing to address with their customers.

My 2017 Hyundai Santa Fe (VIN: [XXX]) was brought to Herb Chambers Hyundai of [XXX], in December 2023 to address the Underbody Corrosion Recall/Campaign (9A0). The dealer performed the preventative service. However, the remedy completely failed because the frame was already severely structurally compromised by rust. In early 2024, I relocated to [XXX] with the vehicle. Now 2026, The front subframe sub-assembly deteriorated to a hazardous point, forcing me to spend a large sum of my own money on front-end repairs caused directly by this corrosion. Currently, the rear subframe and rear suspension components are heavily corroded and structurally disintegrated. The vehicle is completely unsafe to drive, presenting an imminent risk of structural collapse and suspension failure while in motion. Hyundai's recall remedy was ineffective and merely masked the rust. The rear subframe (crossmember/cradle) and control arm anchor points are severely corroded, rusted out, and crumbling to the touch, creating an imminent risk of suspension collapse while driving. The extreme corrosion has spread to the metal fuel line the vehicle is unsafe to drive due to the advanced corrosion . Denial of Service by Local Distributor: The vehicle is currently located in the U.S. territory of Puerto Rico. I presented the vehicle and documentation to the local authorized distributor, Sojitz de Puerto Rico (Hyundai of Puerto Rico). As indicated I brought the Vehicle to MVP Hyundai Humacao (XXX) and filed a claim (# XXX) However they never sent a anyone to inspect the vehicle or process a safety claim, claiming they bear no responsibility because the vehicle was imported from the mainland, Because this is a failed federal safety campaign remedy that now poses an immediate threat to my life and public safety, INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

After having the Service Campaign 9C2 ECU SOFTWARE UPDATE FOR THETA II EMISSIONS IMPROVEMENT, TSB 26-01-013H-2 done, my vehicle started having driveablity issues. On a normal, cold start the engine's RPMs go up really high, so I take my foot of the gas and the revs drop, almost stalling the car, and then the car bucks. I put my foot back on the gas pedal, and the engine revs really high again and takes off. If I try to drive normally, the car bucks and runs rough. My car also revs a lot higher during highway driving, than it did before the update. All of this is also causing terrible gas mileage. My car did nothing like this until I had the 9C2 update.

The vehicle is in limp mode and is displaying a flashing check engine light with a P1326 powertrain code. The vehicle in question is a 2017 Hyundai Santa Fe Sport equipped with a Theta II 2.4L GDI engine at 118,000 miles. Per the service campaign T3G, listed on the NHTSA website, this vehicle is covered under warranty repair since it is a Theta II engine vehicle that is displaying an active P1326 power train code. The vehicle is under he 10 Year/120,000 miles limitations of the extended warranty. The dealer just submitted to us a quote to repair the vehicle and is stating that none of the repairs listed are covered under warranty. This includes a quote to replace the engine knock sensor, which is a warranty item under the T3G service campaign’s extended warranty.