2008 HYUNDAI SANTA FE Complaints

THE FUEL SENSOR ON THIS VEHICLE SUDDENLY STOPPED WORKING. THE READINGS ON THE FUEL WOULD FLUCTUATE WILDLY FROM FULL TO EMPTY. THIS IS SAFETY ISSUE DUE TO NOT KNOWING HOW MUCH FUEL IS IN THE CAR AND CAN CAUSE THE CAR TO STALL OUT AT THE HIGHWAY. I FIRST HAD A PROBLEM WITH THE FUEL SENSOR 2 YEARS AGO AND HYUNDAI FIXED UNDER WARRANTY. THE PROBLEM HAS COME UP AGAIN AND ITS NOT COVERED UNDER WARRANTY. THE PROBLEM IS CAUSED BY A DEFECTIVE FUEL SENSOR. THE COST OF THE REPAIRS IS APPROXIMATELY $750. THERE SHOULD BE A RECALL ON THE FUEL SENSORS. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A SQUEALING NOISE NEAR THE FRONT OF THE VEHICLE. A MECHANIC STATED THAT THE RACK AND PINION STEERING WAS DEFECTIVE. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 58,000. UPDATED 09/02/14*LJ UPDATED 11/12/2014 *JS

THE FUEL LEVEL SENSOR IN THE TANK BEGAN TO FAIL, CAUSING THE FUEL GAUGE TO BEHAVE ERRATICALLY. FUEL LEVELS WOULD SWING WILDLY FROM FULL TO EMPTY. THE CEL WAS THROWN, BUT NOT UNTIL AFTER THE ERRATIC BEHAVIOR WAS OBSERVED. WITHOUT A CEL TO WARN OF A PROBLEM, THE DRIVER MAY THINK THEY HAVE FUEL WHEN THEY DO NOT AND POTENTIALLY RUN OUT OF GAS. THIS WOULD BE A SERIOUS SAFETY HAZARD AT HIGHWAY SPEEDS. WE'VE SPOKEN WITH HYUNDAI AND THIS IS NOT A RECALL OR EVEN A TSB ISSUE, DESPITE THE FACT THAT THE PROBLEM IS WELL DOCUMENTED AMONG OWNERS OF THIS VEHICLE. THE PROBLEM IS COMMON AND THIS VEHICLE SHOULD BE RECALLED. *TR

THE FUEL LEVEL SENSOR IN THE TANK BEGAN TO FAIL, CAUSING THE FUEL GAUGE TO BEHAVE ERRATICALLY. FUEL LEVELS WOULD SWING WILDLY FROM FULL TO EMPTY. THE CEL WAS THROWN, BUT NOT UNTIL AFTER THE ERRATIC BEHAVIOR WAS OBSERVED. WITHOUT A CEL TO WARN OF A PROBLEM, THE DRIVER MAY THINK THEY HAVE FUEL WHEN THEY DO NOT AND POTENTIALLY RUN OUT OF GAS. THIS WOULD BE A SERIOUS SAFETY HAZARD AT HIGHWAY SPEEDS. WE'VE SPOKEN WITH HYUNDAI AND THIS IS NOT A RECALL OR EVEN A TSB ISSUE, DESPITE THE FACT THAT THE PROBLEM IS WELL DOCUMENTED AMONG OWNERS OF THIS VEHICLE. THE PROBLEM IS COMMON AND THIS VEHICLE SHOULD BE RECALLED. *TR

MY 2008 GAS GAUGE IS NOT WORKING PROPERLY OR READING THE CORRECT LEVELS OF FUEL. WHEN I FILL THE TANK UP, THE LOW LEVEL INDICATOR LIGHT ILLUMINATES AND STAYS ON FOR SEVERAL DAYS. THE CHECK ENGINE LIGHT ALSO ILLUMINATES. AFTER SEVERAL MILES OF DRIVING (FEW DAYS), BOTH LIGHTS WILL GO OFF AND GAS GAUGE WORKS PROPERLY. AROUND THE HALF TANK MARK, THE INDICATOR LIGHT COMES BACK ON SHOWING EMPTY AND CHECK ENGINE LIGHT APPEARS. I'VE TAKEN THE VEHICLE TO DEALERSHIP AND THEY QUOTED NEARLY $800 TO FIX THIS PROBLEM. EVEN THOUGH THEY ADMITTED THAT THIS IS A COMMON OCCURRENCE, THERE IS NO RECALL??? THIS IS VERY DANGEROUS AND SHOULD BE INVESTIGATED. *TR

MY SANTA FE LIMITED AWD 2008 WAS BOUGHT AT THE END OF FEB 2009 AND NOW HAS ~44K MILEAGE. I HAD TWO SIMILAR INCIDENTS WITH MY SANTA FE TODAY (7/6/2014), WHICH LED TO SIGNIFICANT POWER LOSS AND SPEED LOSS OF THE CAR ON THE ROAD. THE FIRST TIME, I WAS DRIVING ON A LOCAL ROAD AT ~45 MPH. SUDDENLY I FELT THE CAR LOST THE POWER AND BEGAN TO SLOW DOWN. I STEPPED DOWN ON THE ACCELERATOR, BUT THE CAR COULD NOT ACCELERATE (THE SPEED DROPPED TO ~20 MPH). I SAW 3 SYSTEM INDICATOR/WARNING LIGHTS ON: THE ESC OFF(ELECTRONIC STABILITY CONTROL) AND CHECK ENGINE INDICATORS HAD A STEADY LIGHT AND THE AWD SYSTEM WARNING LIGHT WAS FLASHING. I PULLED OFF TO THE SIDE OF THE ROAD, SHUT OFF THE CAR, WAITED ~1 MINUTE, AND THEN RESTARTED THE CAR. THE CHECK ENGINE LIGHT STAYED ON, BUT THE OTHER LIGHTS WENT OUT. THEN I DROVE THE CAR TO CONTINUE MY GROCERY SHOPPING (SEVERAL STOPS, ~30 MILES IN TOTAL). THE 2ND INCIDENT OCCURRED ON MY WAY HOME. THE SAME SCENARIO EXCEPT THAT I WAS DRIVING AT ~40 MPH AND GOING UPHILL AT THE TIME. THE SUDDEN POWER LOSS CAUSED THE CAR SPEED QUICKLY DROPPED TO ~10 MPH AND PROBABLY LED THE CAR BEHIND MINE TO MAKE A SUDDEN STOP TO AVOID A CRASH. AGAIN, I PULLED OFF TO THE SIDE OF THE ROAD, SHUT OFF THE ENGINE, AND THEN RESTARTED THE CAR WITH THE CHECK ENGINE LIGHT STAYING ON. AFTER GOT HOME SAFELY, I DID SOME SEARCH ONLINE AND FOUND SEVERAL SIMILAR INCIDENTS REPORTED ON HYUNDAI SANTA FE SUVS BEFORE (SEE THE ATTACHED LINKS BELOW). SO I DECIDED TO REPORT THIS SERIOUS ISSUE. THE LINK OF WEBSITES WITH SIMILAR INCIDENTS REPORTED: 1. HTTP://WWW.JUSTANSWER.COM/HYUNDAI/47Z2R-HYUNDAI-SANTA-FE-LIMITED-HI-HYUNDAI-SANTA-FE-AWD-2008.HTML 2. HTTP://FORUMS.EDMUNDS.COM/DISCUSSION/9216/HYUNDAI/SANTA-FE/HYUNDAI-SANTA-FE-ENGINE-PROBLEMS/P2 (ALTOSTEPH POST) 3. HTTP://WWW.HYUNDAIFORUM.COM/FORUM/HYUNDAI-SANTA-FE-20/4WD-SYSTEM-WARNING-LIGHT-BLINKING-LOSS-POWER-12357/ *JS

I FILLED UP WITH GAS WHEN I LEFT THE GAS STATION MY GAS GAUGE REGISTERED EMPTY AND MY GAS LIGHT CAME ON AND I JUST FILLED THE TANK WITH GAS. MY TRIP ODOMETER WAS GOING CRAZY COULD NOT RESET IT, THEN MY CHECK ENGINE LIGHT CAME WHICH GOT ME CONCERNED I TOOK IT TO AUTO ZONE THEY PUT IT ON THERE MACHINE AND THE CODE CAME UP FOR FUEL SENSOR, THIS SEEM TO BE A PROBLEM WITH ALOT OF THESE SANTA FE MY DAUGHTERS 2007 SANTA FE DID THE SAME THING COST HER 600.00 DOLLARS TO HAVE FIXED. *TR

6/25/14, ON INTERSTATE WITH CRUISE CONTROL AT 65MPH. DEPRESSED THE THROTTLE PEDAL TO PASS A VEHICLE. THROTTLE STUCK WIDE OPEN. APPLIED BRAKES BUT KEPT ON INCREASING SPEED. DEPRESSED THROTTLE PEDAL SEVERAL TIMES BUT NO CHANGE. TURNED CRUISE CONTROL OFF, NO CHANGE. TURNED KEY TO ACC AND THEN BACK TO ON BUT NO CHANGE. TURNED KEY TO ACC AND WAITED SEVERAL SECONDS THEN BACK ON. THROTTLE PEDAL STARTED TO RESPOND. PULLED OVER AND CHECKED IF FLOOR MAT WAS JAMMING THROTTLE PEDAL. NO PROBLEM, NO JAMMING. PROBLEM REPEATED AGAIN. CONTINUED TO DESTINATION AND TRIED CRUISE CONTROL BUT IT WOULD NOT SET. TURNED CRUISE CONTROL OFF. SUV WAS PARKED OVERNIGHT AT DESTINATION. ON RETURN TRIP THROTTLE AND CRUISE CONTROL WORKED FINE. 6/30/14, TOOK SUV TO RAY BRANDT HYUNDAI, THEY FOUND NO CODES SET AND COULD NOT DUPLICATE THE PROBLEM. IT SEEMS IF BOTH THE THROTTLE IS WIDE OPEN AND THE BRAKES ARE BEING APPLIED THEN A CODE SHOULD BE SET.THIS IS A MAJOR SAFETY PROBLEM! THE SITE BELOW DOCUMENTS 3 ADDITIONAL OCCURRENCES: HTTP://WWW.CARPROBLEMZOO.COM/HYUNDAI/SANTAFE/2008/ACCELERATOR-STUCK-PROBLEMS.PHP. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE VEHICLE FAILED TO DISPLAY THE ACCURATE FUEL LEVEL READINGS. THE CONTACT MENTIONED THAT AFTER REFUELING THE VEHICLE, THE LOW FUEL WARNING LIGHT WOULD CONTINUOUSLY ILLUMINATE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

THE DASH LIGHTS STARTED FLASHING, THE WIPERS STOPPED WORKING IN THE MIDDLE OF A DOWN POUR, THE LIGHTS WENT DIM. THE TRACTION SYSTEM STARTED DETUNING THE ENGINE. ALL DASH LIGHTS ON. WE FIND THAT IT IS A LEAKY VALUE COVER GASKET. DRIPS ON THE ALTERNATOR AND CAUSES IT TO GO BAD. THE SERVICE MANAGER SAID "THEY ARE ALL STARTING TO HAVE THIS PROBLEM AND IT'S $700.00. IF I WAS THE ORGINAL OWNER HYUNDAI WOULD REPLACE THE GASKET, BUT I WOULD NEED TO PAY FOR THE ALTENATOR. $600.00 UHGG!!! NOW FOR THE FUEL GUAGE. TWO SENSORS UNDER THE BACK SEAT AND GOOD AS NEW. $200.00. *TR