2007 HYUNDAI SANTA FE Complaints

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STARTED TO SHUDDER AND DECELERATE. THE CONTACT MENTIONED THAT THE ELECTRONIC STABILITY WARNING LAMP ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE THROTTLE POSITION SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

FAULTY FUEL GAUGE. THE FUEL GAUGE WILL REGISTER EMPTY AND THE FUEL LIGHT WILL COME ON AFTER FILLING UP THE TANK. THE GAUGE WILL WAVER AND GIVE FAULTY REGISTERS WHILE DRIVING, EVEN CLIMBING BACK TO FULL AFTER REGISTERING "EMPTY" SECONDS BEFORE. *JS

THE PASSENGER SIDE SUNVISOR BROKE CAUSING THE SUNVISOR TO FALL OFF AND BLOCK VISION. ONE YEAR EARLIER THE DRIVER SIDE BROKE. THIS IS A SAFETY ISSUE AS VISOR CAN BREAK WHILE DRIVING AND OBSTRUCT VISION. THE PLASTIC CLIP ON THE PIVOT BREAKS CAUSING THE FAILURE. THE VISOR WILL HANG BY THE ELECTRICAL CORD AND CAN NOT BE REMOVED UNLESS YOU UNSCREW AND DISMANTLE THE ENTIRE HOUSING ASSEMBLY-WHICH ISN'T POSSIBLE TO DO WHILE DRIVING. YOU WILL GET STUCK HOLDING THE VISOR OUT OF VIEW UNTIL YOU CAN PULL OVER AND EITHER RIG IT BACK UP TEMPORARILY OR GET LUCKY ENOUGH TO HAVE SOME SCREWDRIVERS WITH YOU TO FIX IT. *JS

THE DRIVER SIDE SUNVISOR BROKE CAUSING THE SUNVISOR TO FALL OFF AND BLOCK VISION. ONE YEAR LATER THE PASSENGER SIDE BROKE AND FELL WHILE DRIVING. THIS IS A SAFETY ISSUE AS VISOR CAN BREAK WHILE DRIVING AND OBSTRUCT VISION. THE PLASTIC CLIP ON THE PIVOT BREAKS CAUSING THE FAILURE. THE VISOR WILL HANG BY THE ELECTRICAL CORD AND CAN NOT BE REMOVED UNLESS YOU UNSCREW AND DISMANTLE THE ENTIRE HOUSING ASSEMBLY-WHICH ISN'T POSSIBLE TO DO WHILE DRIVING. YOU WILL GET STUCK HOLDING THE VISOR OUT OF VIEW UNTIL YOU CAN PULL OVER AND EITHER RIG IT BACK UP TEMPORARILY OR GET LUCKY ENOUGH TO HAVE SOME SCREWDRIVERS WITH YOU TO FIX IT. *JS

LAST MARCH I NOTICED THE CHECK ENGINE LIGHT ON AND THE VEHICLE HESITATING TO STALLING OUT WHEN COLD AND ACCELERATING. THIS IS WORSE THE COLDER IT GETS OUTSIDE. ALSO WHEN DRIVING YOU CAN FEEL A HESITATION/MISSING GOING ON, ALMOST LIKE THE GAS ISN'T FLOWING STEADILY INTO THE ENGINE. AND RECENTLY MY GAS GAUGE IS NOT SHOWING ACCURATELY WHAT IS IN THE GAS TANK. I'LL FILL UP AND IT STILL READS EMPTY WITH THE LOW FUEL LIGHT ON AND CHECK ENGINE LIGHT ON. IT'LL EVENTUALLY AFTER FEW START UPS START TO "SUPPOSEDLY" DISPLAY THE CORRECT GAS AMT ON THE GAUGE. I RESET MY TRIP METER TO MEASURE HOW MANY MILES ON THE TANK SO I DON'T RUN OUT. BUT THE STALLING ON ACCELERATION IS A BIG ISSUE. THIS COULD HAPPEN AT A LIGHT OR STOP SIGN AND END UP CAUSING AN ACCIDENT. I'VE READ ON THIS SIGHT OTHERS HAVING SAME PROBLEM.. I HAD SAME PROBLEM WITH A GMC ENVOY, ABOUT THE SAME YEAR AS MY HYUNDAI, GMC MADE GOOD ON THE PROBLEM AND COVERED THE EXPENSES AS THEY HAD A "SILENT" RECALL ON THAT ISSUE. HOPEFULLY HYUNDAI WILL BE DOING THE SAME, WE'LL SEE AFTER THURSDAY NIGHT.

DRIVER SIDE SUN VISOR MOUNT FAILED UNEXPECTEDLY, CAUSING THE SUN VISOR TO FALL DOWN AND DANGLE IN FRONT OF THE DRIVER BY THE ELECTRIC WIRE THAT RUNS INSIDE THE HINGE. THE VISOR DANGLED IN FRONT OF THE DRIVER BLOCKING THE VIEW, AND STARTLING THE DRIVER. HAD TO DISASSEMBLE THE VISOR HINGE TO REMOVE THE VISOR BEFORE THE VEHICLE COULD BE SAFELY DRIVEN. UPON INSPECTION IT IS CLEAR THAT THE VISOR HINGE / BALL JOINT IS POORLY DESIGNED, WITH A PLASTIC TUBE LESS THAN 0.5MM THICK HOLDING THE ENTIRE VISOR AND FORCES WHILE IT IS MANIPULATED BY THE DRIVER. IT IS A MATTER OF TIME BEFORE THEY ALL FAIL. WHILE PASSENGER SIDE FAILURE IS LESS DANGEROUS, DRIVER SIDE IS VERY DANGEROUS AND STARTLING IF OCCURS WHILE DRIVING. A GOOGLE SEARCH DEMONSTRATED THIS TO BE A COMMON PROBLEM EXPERIENCED BY MANY HYUNDAI OWNERS OF VARIOUS MODELS. THIS IS A DEFECTIVE PART DESIGN, AND VEHICLES SHOULD BE RECALLED SO MANUFACTURER CAN REPLACE THE VISORS WITH BETTER DESIGNED VERSIONS. *TR

FUEL DOOR LATCH SWITCH ON DRIVER-SIDE DOOR WILL NOT UPEN FUEL DOOR ON OCCASION. HAPPENING MORE FREQUENTLY LATELY. ON-LINE SEARCH SHOWS THIS IS A COMMON PROBLEM W THIS MODEL. IS ANYTHING BEING DONE BY MANUFACTURER TO FIX THIS? *TT

SIMILAR FUEL GAUGE PROB I HAVE READ ON THIS SITE-----FUEL GAUGE SHOWS EMPTY AND INDICATOR LIGHT IS ILLUMINATED WHEN TANK GETS BELOW HALF FULL. *TT

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER'S SIDE SUN VISOR FRACTURED AND WOULD HANG ABNORMALLY, BLOCKING THE DRIVER'S VISION OF THE ROADWAY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 130,000.

TWO WEEKS AGO, I STARTED MY CAR AND WAS SHOCKED TO SEE THE FUEL GAUGE WAY BELOW "E" AND THE LIGHT HAD TURNED ON, ALONG WITH THE "CHECK ENGINE" LIGHT. I WAS AFRAID I HAD NEGLECTED TO GET GAS, EVEN THOUGHT I WAS PRETTY SURE THAT WHEN I LEFT THE CAR THE NIGHT BEFORE I WAS OVER A 1/4 OF A TANK. I MADE IT TO THE GAS STATION AND FUELED UP. I ONLY PUT $20 IN AT THE TIME, BECAUSE I WAS IN A HURRY. I GOT IN, STARTED THE CAR AND I WAS UP ALMOST FULL, WHICH IS NEARLY IMPOSSIBLE ON $20 IN A SANTA FE. IT TURNS OUT I HAD PLENTY OF GAS IN THE TANK AND THE GAUGE WASN'T REGISTERING IT PROPERLY. THIS HAS HAPPENED SEVERAL TIMES IN THE LAST TWO WEEKS. IT'S ALMOST LIKE THE CAR NEEDS TO "WARM UP" BEFORE THE FUEL GAUGE ACTUALLY REGISTERS THE AMOUNT OF GAS CORRECTLY. AND THE CHECK ENGINE LIGHT CONTINUES TO GO ON AND OFF INTERMITTENTLY. I AM CONCERNED THAT PROBLEM COULD WORSEN WITH TIME AND WILL EFFECT OTHER SYSTEMS IN THE CAR. I AM ALSO CONCERNED THAT I MAY ACTUALLY RUN OF OUT GAS AND BE STUCK SOMEWHERE WITH MY CHILD BECAUSE THE GAUGE ISN'T ACCURATE AND LIKE ALL HUMAN BEINGS..I CAN'T ALWAYS REMEMBER THE LAST TIME I FUELED UP. *TR