2017 HYUNDAI SANTA FE Complaints

The engine head has cracked. It is very difficult to find a motor because it is such a common problem.

I was driving on the highway, and suddenly oil and battery light came on and engine stopped and I had to pull over. The only warning was the check engine light came on when I started it 10 minutes before the engine died.

The engine had oil consumption issues that were addressed with dealership. The engine then just seized up and stopped working one day while driving down the road.

While I was stopped at a stoplight turn lane in my 2017 Hyundai Santa Fe sport, smoke started to come out of my engine. I removed myself from the turn lane and got my car into a parking lot, and within a minute, flames appeared from the engine. I do not recall a warning light alerting me, as I was focused on getting the car to a safe place. I called 911 and the fire dept put out the flames as it consumed the front of my car. The whole engine area is toast, so not sure of the cause, and insurance will be processing the claim as a 100% loss. I was up to date on my service/recalls and the car had just hit 90,000 miles. We had recently checked fluid levels, so that was fine, but I did notice when driving the day before and that morning on my way to my destination, that the engine/ car seemed to be a little off or running a little rough. That may have been the precursor to the engine fire I experienced.

Without any warning the car stopped running was able to pull over. Called for tow to dealership who after 30 days said it was the engine. Less than 50,000 miles

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated while driving approximately 35 MPH, the vehicle started losing motive power with the check engine warning light illuminated. The contact depressed the accelerator pedal; however, the vehicle failed to respond as needed. The contact stated that the vehicle lost motive power and stalled. The contact had the vehicle towed to the residence and was later able to drive the vehicle to the local dealer. The dealer diagnosed the vehicle and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 110,000.

Engine failure at 145,000 miles. Has been having extreme oil consumption and taken to the dealership a dozen times. Repeatedly told there is not an issue. Car shut off at 70 miles per hour on the highway with myself and three passengers inside. The check engine light came on mere seconds before cutting off. Dealership now states there are two holes in cylinder 2.

My vehicles 3.3l engine suddenly seized while pulling out from a stop sign in the intersection. Thankfully a group of guys saw this and were able to assist me in moving the vehicle out of traffic. Prior to this occurring I had noticed that it had begun to burn a bit of oil but I routinely checked it. Sounds similar to issues that Hyundai has had with some of their other engines that are now being covered under an extended warranty.

When driving front right brake caliper locked up and would not release, after replacing brake pads, rotors and calipers on both front right brakes. I drove my car about a week and car brakes locked up again…I then had to have my car towed to the mechanics. Where they discovered that the ABS module was bad, this is the same part that is causing fires in many others Hyundai vehicles but somehow my car was exempt from the recall and after having issues with getting the part and having to rent a car and borrow a car for several weeks I finally got my car fixed almost $3000.00 later. Seems to me this part is a common problem for many people. Thankfully I was not in an accident due to the brake locking up, I will say I had a little fear when driving my car for several weeks after the 2 incidents.

The engine oil drained out almost all at once. An independent mechanic found a hole in the valve cover. He said it would be expensive to take the entire engine apart but that something had clearly come apart and flown through the engine, causing a large crack. Oil had splashed all over the top of the engine. There was no fire, but there could have been. We stopped driving it right away. We have not yet brought it in to the manufacturer, but we have read that there are many failures of this engine (3.3 liter) around this mileage (124,000). The emission control warning light had come on a few days earlier, but not the engine oil warning light.