2007 HYUNDAI SANTA FE Complaints

PROBLEM WITH CALIPERS ON VEHICLE STICKING AND NOT RELEASING THE BRAKES FROM THE ROTOR, CAUSING THE ROTOR AND TIRE RIM TO REACH TEMPERATURES OVER 300 DEGREES. *TR

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. WHILE DRIVING 35 MPH, THE CONTACT SMELLED A FOUL ODOR INSIDE THE VEHICLE. HE PULLED THE VEHICLE OVER AND ATTEMPTED TO IDENTIFY THE SOURCE OF THE SMELL. HE INSPECTED THE VEHICLE AND NOTICED THAT THE ODOR WAS COMING FROM THE PASSENGER SIDE REAR TIRE. HE ALSO NOTICED A SEVERE HEAT WAVE FROM THE TIRE. THE CONTACT STATED THAT THE TIRE ITSELF WAS EXTREMELY HOT. HE TOOK THE VEHICLE TO THE DEALER AND THEY STATED THAT THE PADS WERE RUBBING UP AGAINST THE ROTORS. THE DEALER CLEANED AND GREASED THE CALIPERS, WHICH CORRECTED THE FAILURE. THROUGH RESEARCH, THE CONTACT FOUND NUMEROUS COMPLAINTS REGARDING THE SAME FAILURE HE WAS EXPERIENCING. HE BELIEVES THAT A RECALL SHOULD BE ISSUED SINCE THE FAILURE APPEARED TO BE A MANUFACTURER DEFECT. THE CURRENT AND FAILURE MILEAGES WERE 11,700. UPDATED 07/17/09 *BF THE CONSUMER STATED THE ODOR FROM THE OVERHEATING PASSENGER SIDE REAR WHEEL WAS ONLY NOTICED AFTER EXITING THE VEHICLE. THE DEALER STATED THE CAUSE WAS DUE TO THE PADS FREEING UP AGAINST THE ROTORS DUE TO CORROSION AT THE PLACE WHERE THE PADS SET IN THE BRAKE CALIPER. UPDATED 07/17/09.*JB

REAR BRAKES SEIZED UP DUE TO RUST BUILD UP ON ROTORS. THIS CAUSED THE ROTORS TO GET VERY HOT. WE FEEL THAT THIS WAS DUE TO FAULTY METAL USED FOR THE ROTORS> HYUNDAI SAID IT WAS A ENVIRONMENTAL ISSUE. WE FEEL IT IS A SAFETY ISSUE. HYUNDAI REPORTS A LOT OF PROBLEMS WITH THIS ISSUE. *TR

PASSENGER AIR BAG RANDOMLY DISABLES AND ENABLES WHILE PASSENGERS ARE SITTING IN THE SEAT. THIS INDICATES THAT THE PASSENGER AIR BAG IS NOT WORKING PROPERLY AND IS A SIGNIFICANT SAFETY HAZARD. *TR

TL*THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE BRAKES WERE WORN. THE CALIPER IS RUSTED SHUT AND THE ROTORS AND PADS WERE DESTROYED. HE MUST PURCHASE NEW CALIPERS, RODS, AND ROTORS AT THE COST OF $405. THE MANUFACTURER WOULD NOT ASSIST AND STATED THAT THE CONTACT MUST PAY FOR THE REPAIRS, EVEN THOUGH THEY ARE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 30,127. UPDATED 06/25/09 *BF UPDATED 06/26/09.*JB

NOISE FROM DRIVERS SIDE REAR BRAKES IN LATE APRIL 2009. CHECKED BRAKES ROTORS EXTREMELY HOT-REAR ONLY. FRONT BRAKES FINE;HOWEVER, REAR WORN ALMOST TO METAL. MADE APPOINTMENT WITH DEALER FOR MAY 13. CAR IS ONLY 17 MO OLD, 15,000 MILES (MOSTLY HIGHWAY DRIVING). DEALER WILL REPLACE PADS BUT WILL CHARGE A REAR BRAKE SERVICE$150. I BELIEVE THERE IS A BRAKE DESIGN FLAW. DEALER WANTS $160/AXLE EVERY 15000 MILES TO "SERVICE" BRAKES- CLEAN CALIPERS. BRAKES SHOULD LAST LONGER THAN 15,000 MILES. *TR

MY 2007 HYUNDAI SANTE FE WAS EXPERIENCING BRAKE OVERHEATING FROM DRIVERS SIDE REAR BRAKE AND MILD HEATING WITH PASSENGER SIDE REAR BRAKES. AT 28K MILES I HAD TO TAKE IT TO THE DEALER FOR THIS SITUATION. THE BRAKES HAD FAILED VERY PREMATURELY DUE TO THIS CONDITION. THE DEALER RESURFACED THE ROTORS AND CLEANED AND LUBED THE BRAKE SLIDES, AND REPLACED THE OVERHEATED DAMAGED PADS TO THE TUNE OF $389. I WAS ADVISED THAT THEY WERE NOT COVERED UNDER THE 3YR 36K MILE BUMPER TO BUMPER WARRANTY AS THERE WAS AN EXCEPTION TO THIS FOR THE BRAKES, THEY WERE ONLY 1 YR 12K FOR THE WARRANTY AS I AM IN A "SEVERE" OPERATING ZONE IN UPSTATE NY. I HAVE CHECKED MANY OTHER FORUMS ON THIS SUBJECT AND HAVE FOUND MANY OTHERS TO BE EXPERIENCING THIS SAME PREMATURE FAILURE WITH THE BRAKES AND ALMOST ALWAYS IT IS THE DRIVERS SIDE REAR CALIPER THAT FAILS. I FEEL THIS IS A DESIGN PROBLEM AND A SEVERE SAFETY PROBLEM AS THE BRAKES ALMOST CAUSED A FIRE WITH MY VEHICLE. THIS HAS BEEN GOING ON FOR QUITE A WHILE AND HAS NOT BEEN ADDRESSED BY HYUNDAI AMERICA. I PLACED A COMPLAINT WITH THEM AND WAS TOLD THAT BASICALLY THERE WAS NOTHING THEY COULD DO ABOUT IT. I DO NOT HAVE THE OLD PARTS AS THEY SAID THEY DISPOSED OF THEM PRIOR TO MY ARRIVAL. I HAVE ALWAYS SERVICED MY VEHICLE MYSELF ACCORDING TO MANUFACTURER RECOMMENDATIONS AND NO WHERE DOES IT STATE THE BRAKES NEED TO BE LUBRICATED. *TR

2007 HYUNDAI SANTA FE LIMITED 27,300 MILE THE REAR DRIVER SIDE CALIPER IS STICKING TO THE DISC BRAKE CAUSING BURNING SMELL AND HEAT. *TR

BRAKE FAILURE ALMOST CAUSED ME TO SKID THROUGH A RED LIGHT THAT WAS AT 50 MILES A HOUR HIGHWAY INTERSECTION. THE CAR WAS PURCHASED NEW 7/18/2007, AND WAS RECENTLY INSPECTED BY THE DEALER AS PART OF A 15,000 MILE CHECK UP AT THAT TIME I EXPRESSED A CONCERN ABOUT THE CAR'S HESITATION UPON ACCELERATION NOVEMBER 5, 2008 I WAS TOLD THAT MY 2007 HYUNDAI SANTA FE HAD IT'S REAR BRAKES LOCKED ON AND THE WHOLE REAR BRAKE SYSTEM NEEDED TO BE REPLACED AND I SKIDDED BECAUSE THEY HAD FAILED AND MY FRONT BRAKES WERE DOING ALL THE WORK. I WAS TOLD BY MANY CAR SPECIALISTS THAT THIS SHOULD NOT HAVE HAPPENED WITH A VEHICLE UNDER 18 MONTHS WITH ONLY 15,198 MILES AND THAT IT IS A PROBLEM WITH HYUNDAI'S INFERIOR BRAKE SYSTEM AND THAT IT WILL HAPPEN AGAIN! I FEAR THAT NEXT TIME, I WON'T BE ABLE TO STOP AND LOST OF LIFE MAY OCCUR. *TR

FRONT GLASS HAS A CRACKED LINE IN IT FROM THE RIGHT FRONT PILLAR. NO INDICATION OF ANYTHING HITTING GLASS. NO PITS. IT IS ON GLASS ABOUT HALFWAY UP WENT LIKE A UTURN 6-12 INCHES FROM PILLAR. NO REPAIRS DONE. SUV PURCHASED 2007. NO ISSUE TILL NOW. *TR