2017 HYUNDAI SANTA FE Complaints

The engine failed and is available for inspection upon request. The failure caused the vehicle to stall dangerously on the interstate and almost crashed. The problem was due to engine bearing (as diagnosed by third party repair shop) and matches a safety recall (17V578000) for Hyundai 2017 Santa Fes. The VIN, however, does not fall under this safety recall. But it should and I wish to dispute. The vehicle now is at the Courtesy Hyundai of Tampa. No warning messages appeared before stalling to my knowledge. This happened 4-5 weeks ago and has been in the shop since. There was a delay in reporting a safety problem because I tried working with the manufacturer directly. There was miscommunication and they submitted a case on my behalf to check the car for warranty but not to investigate the safety recall. Repair invoices yet to be provided. Courtesy Hyundai of Tampa should have more information: 813-356-7576

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated while driving 25 MPH, the steering wheel began to turn independently to the left and right. The contact stated no warning light was illuminated. The contact was able to park the vehicle on the side of the road and she started to smell a burning odor. The vehicle was not drivable. The contact towed the vehicle to the local dealer. The vehicle was not diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 110,000.

Vehicle: 2017 Hyundai Sante Fe Sport - While driving down the highway, the day before Thanksgiving, 11/23/22, the Sante Fe began to knock and immediately began to decelerate leaving my youngest sister stranded on a dark backroad in NC in the middle of the night! She pulled over into a local church that was thankfully in the area and had to wait alone for a while. This is extremely dangerous as the road she was on was a winding road, 55 mph speed limit, steep shoulders, and the vehicle gave her no warning prior that something was wrong. After getting the car towed to a repairman we got the news that the engine has failed and that the engine rebuild alone is $10,000 (low estimate). This is not the Hyundai that I know and something must be done to rectify this.

Vehicle spontaneously caught on fire in the engine compartment while driving in a parking lot. Within 30 minutes, the vehicle was incinerated down to the frame. Prior to this incident, a warning had flashed on the message center that the adaptive cruise control system was being disabled. It is pending insurance inspection and we are trying to contract Hyundai. The police report is not available yet, but is with the Faribault, MN, Police Department and is #[XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Failure of Oil Pressure Switch Assembly resulting in oil leak. Not covered by warranty. Dealer repair resulted in cost of $544.94 to owner. Vehicle mileage: 63591 miles. Appears as wide spread problem with this engine type from Hyundai/Kia.

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer and the contact was informed that there was a hole in the engine block. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and stated that the vehicle was out of warranty. The failure mileage was 105,000.

I was accelerating on the highway and my RMPS shot the whole way up over 7,000 then bottomed out. I lost speed so I pulled over. Another car pulled over to inform me my car was on fire. I turned the car off and the fire went out. The car was towed to Blaise Alexander (dealership) in Altoona, PA. The mechanic reported that a connector rod went through the oil pan, engine block, and brake starter. He kept repeating to me "I've never seen anything like this before". He reached out to Hyundai to ask if they would cover repairs (starting at $13,790). Hyundai said no. I believe this incident was more than mechanical, and is related to the open recall. I attempted twice to have my car repaired under the recall but the dealership "didn't have the part".

I was on my way home from work in the interstate, I started to exit the interstate and my car would not accelerate, and just died. I was going around 45 mph and there was no indication till it happened and then the check engine light came on. I couldn’t get into Hyundai since they have so many broken cars so I took it to 2 mechanics who both told me the car is immaculate condition and should not have had no oil in it unless there was a malfunction with the engine. Both mechanics told me to get it to Hyundai because my car is doing exactly what the 4 cyl that they are recalling is doing. I made apt and got car in last week. Dealer is telling me that it’s out of warranty so they won’t do anything. My daughters car is same year (different model) with same mileage and he’d engine also went out 2 months later. Something is not right with this brand of vehicles and will cause serious injuries.

Engine stopped working while driving; left stranded and without a vehicle after this incident and was asked to pay $11,000 to replace engine with an used engine after denied good faith repair. This is an extremely common issue with Hyundais.

The contact owns a 2017 Hyundai Santa Fe Sport. The contact stated that while operating the vehicle, the ABS warning light illuminated, and the vehicle shut off. Additionally, the vehicle had experienced several electrical failures including the headlights randomly turning off and on and the vehicle not immediately starting. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The vehicle was not repaired. The contact later received notification of NHTSA Campaign Number: 22V056000 (Service Brakes, Hydraulic). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 88,000.