2013 HYUNDAI SANTA FE SPORT Complaints

Engine seizure. Driving 80mph on i90, pop sound from under the hood happens & check engine light came on; immediately pulled over & the oil and battery light came on; turned car off & it would not start again. Smoke then came from engine while trying to restart. Code 1326

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that while driving at an undisclosed speed, the engine seized. Several unknown warning lights were illuminated. The vehicle was driven to the shoulder of the roadway. The vehicle was then towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact stated that the repair coverage was denied because of the maintenance record of the previous owner of the vehicle. The failure mileage was approximately 200,000.

Official Dealer Refusal to Perform Critical Safety Recall (VIN: [XXX] ) Description: I am reporting a formal refusal by the official Hyundai distributor in the Dominican Republic (Magna Motors) to perform critical safety recalls on my US-spec vehicle. Pending Recalls: Recall #251 (NHTSA 23V651000): ABS module fire risk. Campaign #953: KSDS software update. The dealer (Magna Motors) refuses to perform the service, claiming a "lack of tools," and has declined to provide a written explanation for this denial. This is a severe violation of safety regulations regarding life-threatening defects (Fire Risk). As the vehicle is a US-spec unit, I request NHTSA’s intervention to ensure the manufacturer (Hyundai) compels its local representative to complete these repairs immediately at no cost. PLEASE NOTE: I am using a US mailing address only to complete this form. The vehicle and I are physically located in the Dominican Republic. The local official distributor, Magna Motors, is failing to honor these NHTSA safety recalls." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I requested Engine oil consumption tests on November 12, 2020 and March 27,2021 at Vandergriff Huyndai, Arlington, Tx. Nothing was resolved,. I have been adding oil myself and getting oil changes regularly since. At 146,000 miles it's been worse. After just 2,000 miles after an oil change it was below low, my mechanic topped it off 3 weeks ago and I've had to add oil since. Took my car to Jerry's Huyndai, Weatherford, Texas on December 29,2025. Due to oil consumption, smoke, smell, and I'm wondering if the vibrating is from the engine or if I need new spark plugs. I was told that my valve cover gasket needs to be replaced. I feel like I'm still getting the run around and the car can't keep oil above low level. I've never seen oil under the car and when i took the car to Vandergriff in 2020 and 2021 they didn't see a leak they said. I also took my car in 8/21 and had the ABS repaired and as of recent its out again. I took my car into an independent mechanic shop today 1/2/2026 and he said he felt that the valve cover gasket is not the main problem he feels it would be a waste of money until the engine is replaced. I also heard a new noise today not knocking but tapping noise while driving. My car has hesitated recently, but Jerrys huyndai didnt have that happen while driving it. My car would be available for inspection any time requested. I am just concerned about the smoking if it will get worse, is there a risk of fire and I'm disabled, so I'm concerned if I will have a problem getting out of the car in time if that were to happen or if the car would stop in the middle of the street. This is my only car and I care for 2 sons that are disabled. I need a safe car. Also, the car manager Rachel at Jerry's Huyndai seemed focused that I would be charged 225.00 if it was not the rod bearings. It just seemed like she more focused on that instead of finding the problem. The only lights on is the ABS.

The knock sensor recall was done. Currently engine started knocking and became undrivable. This vehicle qualifies for the Hyundai engine replacement recall, but they denied my claim

As driving, the passenger side rear wheel disconnected from the subframe. A lot of suspension parts (e.g. rear suspension mounting bolt is absent from the subframe; rear control arm toe link detached from its mounting point; severe corrosion present on subframe control arm And bushing sleeve; rusted and degraded mounting hole) were subsequently affected which significantly impacts driver and passenger safety as well as other surrounding vehicles. The mechanic indicated that if we were on the highway at a higher speed this would of caused a major accident with potential several deaths.

The door latch assembly. It continues to show warning lights that my doors are still open when they are not. As well as my key fob when pressed twice, my car will not make any audible sounds. It continues to drain my power and kill my batteries. Have had my engine replaced due to engine recall. I have also had my hood latch replaced from a recall. My car sound be eligible for the door lock assembly recall. I have two children under 6 years old and safety of the door being shut properly is of the utmost importance to me. I have already taken the vehicle to the dealership and they have quoted me the problem as stated above. I can provide the quote! There is also a TSB 14-01-004-1. Which my car should be able to qualify for. Thank you.

The engine in my 2013 Hyundai Santa Fe 2.0T shut off suddenly while driving and would not restart. The dealership confirmed the engine is seized, has bottom-end knocking, and FAILED the BCT (bearing clearance test). Hyundai denied assistance claiming ‘maintenance neglect,’ but the mechanical failure is consistent with known Hyundai GDI engine defects. This presents a serious safety hazard because the vehicle lost power unexpectedly while in motion and could have caused a crash.

Number 4 piston developed a hole in it. Also the engine has been going through a lot of oil

The contact owns a 2013 Hyundai Santa Fe Sport. The contact stated that while driving approximately 35 MPH, the vehicle intermittently lost automotive power. No warning light was illuminated. The vehicle was taken to a local independent mechanic, and the starter was replaced. Upon further investigation, the contact related the failure to an unknown NHTSA Campaign. The local dealer was contacted; however, it was unclear if the vehicle had been diagnosed. The vehicle was not repaired. Prior to the failure, the vehicle was towed to the same local independent mechanic, where the alternator was replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 192,000