2014 HYUNDAI SANTA FE SPORT Complaints

I closed my door and the driver door latch became stuck and will no longer open from the inside or outside. I have tried to open it myself, ask a mechanic and a locksmith and no one can open the door without damaging the door.

Engine failure and metal debris and timing belt slipped time. Loss of power and we parked it flashing engine light. Massey Hyundai said it’s not a recall but when I research there’s a lot of engine failure recalls so I’m not quite understanding what the situation is and we still owe money on the vehicle. They basically told us to junk it. This has been the worst situation I have ever went through with a vehicle. I’ve never owned a Hyundai and I probably never will ever buy another Hyundai. I just wanna know why my engine failed and nobody can tell me why Massey hundai cannot tell me why. they just want me to remove it from their service center or they’re gonna charge me $500 to dispose of it. I’ve never heard of such stuff in my life. This is too overwhelming, especially when it happened. My daughter just had reconstructive foot ankle surgery and has pins in her foot. We were stranded an hour and a half away from home at a doctors appointment for a check up for her foot. Our Insurance towed it, but left us standing and hundred degree weather which was a complete nightmare, especially when you have someone that can’t walk and just had surgery not that that’s any of your fault. I just want to know why my engine failed why there was metal debris why can’t no one tell me. $10,000 for a new motor or charge you $500 to remove it from our lot. I can’t even lie about this stuff. It’s insane. I still owe money on the vehicle. I had to refinance it during Covid. If you could just like, give me some sort of information I don’t even know where to turn to at this point and if I can’t turn to the dealership, who do I turn to.

On June 22 2025 while driving on Interstate 17, the vehicle engine started to lose power and the engine light started to flash on and off. Pulled over and the vehicle stalled and was not able to turn on again. The vehicle is available for inspection. Safety was a concern as we had to change over 3 lanes as we were losing power. The problem has been confirm that the engine has failed and they are numerous TSBs out for engine failure on the Theta II engines, vehicle also qualifies for 15yr/150K engine warranty. The vehicle engine is branded which is a manufacturer defect and never was replaced. The vehicle was towed by AAA to a AAA repair shop and said diagnosis was given thereafter vehicle was towed to dealership which it currently sit at. However Hyundai denied claim because service record was not provided (I was not the owner of vehicle on the years they are requesting) I do have my records from when I owned the vehicle however service advisor stated I did not need to provide my records since they dated back to where I didn't owned vehicle. I purchase vehicle from a dealership. If any more information is needed please advis. I would just like my engine replaced.

Seat belt has been fraying for years and has not return to original position on the I-beam when not being used. Repair shops say it’s normal for vehicle.

My 2014 Hyundai Santa Fe Sport 2.0 Turbo suffered a complete engine seizure while driving due to a blown head gasket, which caused all coolant to leak out. The engine locked up suddenly while my daughter was operating the vehicle, creating a serious safety hazard. She was fortunate to pull over safely, but this type of failure could have resulted in a crash. I was forced to pay over $9,000 for a full engine replacement. This engine is the Theta II 2.0L Turbo GDI, which is part of multiple class action lawsuits and safety recalls due to engine seizure, bearing failure, and fire risk. Hyundai Customer Care has refused to assist or reimburse me. This failure involved no prior warning signs, and the gasket failure appears to be consistent with design flaws already documented in these engines. I am submitting this complaint as I believe this is a defect that poses a safety risk, especially given how suddenly the engine failed during normal driving.

I was on an expressway with 70 mph speeds and could only drive at 55 mph. A flashing motor light came on and then a thunking/clicking sound. It would not accelerate and also lunging. Towed to an independent mechanic close to where I was who confirmed blown engine. Having towed to Hyundai dealership.

Engine is burning oil at a rapid rate. Completed oil change on 12/6/2024 at 94380 miles. On [XXX] check engine light came on at 96684 miles. Dipstix Oil Change checked oil level and level was at least 2 quarts low. Dipstix Oil Change filled oil reservoir. On [XXX], check engine light came back on. SUV was taken to AutoZone and computer said light was due to bad oxygen sensor. Deal's Auto changed oxygen sensor for $557 on 2/24/2025 at 96708 miles. On [XXX], check engine light came back on and engine had a knocking noise. Vehicle was towed to Hyundai in Batesville, MS on 4/17/2025 for $498. Engine was checked by Hyundai on 5/23/2025. Oil level was at least 2 quarts low and dealership recommended an oil change (paid by me) to see if there is oil consumption. I live 8 hours from dealership and already know there is oil consumption. Dealership wants to simply get the vehicle off their hands and is placing consumer at risk with lazy diagnosis. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am submitting this complaint regarding a serious engine defect in my 2014 Hyundai Santa Fe, which suffered rod bearing failure and now requires a full engine replacement at a cost of approximately $8,600. This failure occurred on April 13, 2025, despite regular oil changes and proper maintenance throughout my 1 year and 7 months of ownership. According to my certified mechanic, the vehicle was evaluated using Hyundai’s own rod bearing clearance test protocol, which it failed. The results were submitted to Hyundai by the repair shop, but the manufacturer denied the claim—despite their own diagnostic test confirming the issue. I later discovered that my vehicle may fall under NHTSA Campaign Number 17V226000 (Recall 162), which addresses machining errors in the Theta II GDI engine that can cause premature bearing wear. I am requesting that NHTSA investigate whether my vehicle should be formally included in this recall or covered under Hyundai’s extended warranty program for rod bearing failures. This issue represents a serious safety risk. The engine began knocking suddenly, without any warning lights or codes, and still had another month or 1,419 miles left till next service and oil level was normal. Vehicle had to be towed to a service facility. A failure while driving could have resulted in a complete engine seizure, placing my family and others at risk. I respectfully request that NHTSA review this issue and investigate Hyundai’s handling of such claims, especially where their own testing confirms a known defect.

I own a 2014 Hyundai Santa Fe Sport 2.0T which has had door latch issues.  Recently, the front passenger side door latch needed to be fully replaced due to a failure which caused the door to be loose latching and the latch sensor always showing open.  I paid out-out-pocked for this repair as the Hyundai dealership said there are models which this exact issue was identified, but they said the parts extension had not been placed for my exact vehicle.  They were also confused as to why this was not being covered as they see so many of these same repairs. Now, less than one month later, the front driver's side door is now experiencing lock issues in which a loud grinding noise is occurring when the vehicle attempts to lock or unlock the door.  Additionally, the door does not unlock some of the time from the external and the manual door handle on the interior is getting harder and harder to open.  Both of these issues are consistent with other recalls for other Hyundai models and consistent with the door latch module and actuator failure.  I would like to file a complaint regarding this issue as it seems to be a common issue with Hyundai models using this door latch module.  I believe the parts extension and repairs for these door latches should be covered by Hyundai especially as this becomes a large safety issue with driving the vehicle with concerns of door latch stability and security.

Parts of the ABS system under the hood burned, while the vehicle was parked in my garage, affecting electrical and other parts. I found information online about a recall for this same problem. I have never received a notification of this recall before. I went that same day [XXX] to my local dealer. They gave me an appointment for service for the next day and left the vehicle with them on 04/03/2025. I called the dealer after one week and they told me they already verified the vehicle and notified Hyundai company and are waiting for them to approve the repair. I called the dealer again today 04/23/2025, after 3 weeks and the they told me they are “still waiting for Hyundai Company to approve the repair. That they don’t know how much time this may take and that it may take a lot more time”. In the meantime, and after the bad and risky experience, I have one car less in my house. I understand this is a process but also, considering that this was caused by a factory defect I understand they should be responsible and solve the problem in a timely manner. Thank you. [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)