2004 HYUNDAI SONATA Complaints

INSIDE DOOR HANDLES THIN COVERING (APPEARS TO BE ALUMINUM) IS PEELING APART AND I HAVE CUT MY HAND ON THE SHARP EDGE WHICH CAME APART. DEALER WILL NOT REPLACE THE HANDLE BECAUSE HYUNDAI HAS NOT RECALLED THE 2004 MODELS WHICH HAS THE ***SAME PROBLEM**AS THE 2003 MODEL. *TR

2004 HYUNDAI SONATA GLS DIES RANDOMLY WHEN STOPPED AT A RED LIGHT OR TURNING AT A LOW RATE OF SPEED, THEN STARTS RIGHT UP AND MAY NOT DO IT AGAIN FOR A MONTH OR A FEW DAYS. CHECK ENGINE LIGHT DOES NOT COME ON AND VEHICLE RUNS GREAT BESIDES DYING IN TRAFFIC WHICH COULD CAUSE A CRASH. *TR

CHROME IS PEELING OFF THE INTERIOR DOOR HANDLES CAUSING CUTS TO HANDS/FINGERS ON MY 2004 HYUNDAI SONATA. *TR

I ENTERED MY CAR AND STARTED UP THE IGNITION AND THE AIRBAG LIGHT WENT ON. MY CAR IS A 2004 HYUNDAI SONATA. I TOOK MY CAR TO A MECHANIC AND HE USED A DIAGNOSTIC TOOL IN AN ATTEMPT TO LOCATE THE PROBLEM. THE TOOL REPORTED THAT THERE WAS NO PROBLEM, HOWEVER, THE AIRBAG LIGHT WAS STILL ON. I TOOK MY CAR TO THE LOCAL HYUNDAI REPAIR DEPARTMENT AND WAS TOLD THE PPD SENSOR WAS BAD. MY CAR HAS 53, 965 MILES ON IT. I WAS CHARGED $375 TO REPLACE THE PPD SENSOR. WHEN I WENT ONLINE TO READ ABOUT THE SENSOR, I LEARNED IT IS A COMMON PROBLEM IN THE SONATA AND ELANTRA MODELS MANUFACTURED BY HYUNDAI MOTOR CO. *TR

2004 HYUNDAI SONATA. BUILT IIN FEBRUARY 2004, THE CHROME PLATING OF THE INTERIOR DOOR HANDLE CAME LOOSE. OUR HANDS HAVE BEEN CUT SEVERAL TIMES BY THE SHARP EDGES OF THE CHROME THAT IS PEELING BACK. FINALLY HAD TO PEEL THE CHROME OFF AND SAND THE EDGES. *TR

AIR BAG LIGHT. PLEASE HELP ,I HAVE REPORTED THIS TO YOU BEFORE. MY AIR BAGS ARE DEFECTED. THE DEALER SUPPOSE TO HAD REPAIRED THEM AT LEAST 7 TIMES. EVERYTHING HAS BEEN REPLACED EXCEPT THE AIR BAGS ITSELF. I CAN NOT GET MY CAR INSPECTED BECAUSE OF THIS.SOMEBODY IS GOING TO DIE BECAUSE OF THE AIRBAGS.*TR

EMERGENCY FLASHERS BEGAN FLASHING FOR NO APPARENT REASON AND WOULD NOT BE TURNED OFF. THEN TRYING TO USE THE KEYLESS ENTRY DOOR OPENER, THE LOCKS BEGAN LOCKING AND UNLOCKING. WHEN THE CAR WAS RUNNING THIS STOPPED. WE TOOK IT TO THE DEALER AND THEY REPLACED THE ETAC MODULE, THEN THE ENTIRE FUSE BOX. AFTER RETURNING HOME, THE HAZARD LIGHTS AGAIN BEGAN FLASHING WHILE THE CAR WAS PARKED. THIS WOULD STOP AND BEGIN AGAIN INTERMITTENTLY. RETURNED TO THE DEALER AND LEFT THE CAR FOR SEVERAL DAYS. FINALLY A SWITCH WAS REPLACED AND THE PROBLEM CEASED. *TR

I HAVE A 2004 HYUNDAI SONATA - SAME PROBLEM AS WITH THE 2002-2003 LISTED BELOW - THIS SHOULD NOT HAVE BEEN CLOSED. RECALL CAMPAIGN 09V171000 HAS 1 RELATED INVESTIGATION(S) NHTSA ACTION NUMBER: PE08071 VEHICLE MAKE / MODEL: MODEL YEAR(S): HYUNDAI / SONATA 2002 MANUFACTURER: HYUNDAI MOTOR COMPANY COMPONENT: LATCHES/LOCKS/LINKAGES:DOORS:LATCH DATE INVESTIGATION OPENED: DECEMBER 15, 2008 DATE INVESTIGATION CLOSED: MAY 29, 2009 SUMMARY: THE MANUFACTURER HAS ISSUED A SAFETY RECALL NOTIFICATION AS A RESULT OF THIS INVESTIGATION. THE RECALL AFFECTS 91,202 MY 2002-2003 SUBJECT VEHICLES PRODUCED FROM JANUARY 28, 2002, THROUGH MARCH 22, 2003. THE VEHICLE RECALL POPULATION WAS DEFINED BY THE MANUFACTURER'S USE OF A NEW SUPPLIER FOR THE CHROME PLATING PROCESS BEGINNING IN JANUARY 2002, AND A PRODUCTION CHANGE IN MARCH 2003 TO IMPROVE ADHESION OF THE PLATING TO THE DOOR HANDLE. VEHICLES BEING RECALLED REPRESENT 59 PERCENT OF THE TOTAL MY 2002-2003 PRODUCTION, BUT ACCOUNT FOR 91 PERCENT OF THE CONSUMER COMPLAINTS RECEIVED. THE PROCESS CHANGE FOR MY 2002 VEHICLES RESULTED IN A DRAMATIC INCREASE IN COMPLAINTS (1200 PERCENT ON A PER UNIT RATE BASIS). MY 2003 VEHICLES BUILT AFTER MARCH 2003 PRODUCTION CHANGE SHOWED A SIMILAR DECLINE IN THE COMPLAINT RATE. BASED ON THE MANUFACTURER'S ACTION, THIS INVESTIGATION HAS BEEN CLOSED. *TR

RECALL ON 2004 HYUNDAI. I CALLED 5 DEALERS TO HAVE THEM INSPECT MY CAR, DUE TO THE RECALL I RECEIVED ABOUT POSSIBLE FRAME RUSTING. THE WAIT IS ANY WHERE FROM 10 DAYS TO A MONTH, JUST TO HAVE THEM LOOK AT THE FRAME. I EXPLAINED THAT MY CAR IS SHOWING THE SIGNS OF DAMAGED RUSTED FRAME. I REQUESTED THAT THEY EITHER. PAY FOR MY ROOM OR PAY FOR MY CAR RENTAL. *TR

TL* THE CONTACT OWNS A 2004 HYUNDAI SONATA. IN FEBRUARY 2009, THE TOP EDGE OF THE INTERIOR DOOR HANDLE DEVELOPED CRACKS. AS A CONSEQUENCE SHE INJURED HERSELF WHILE OPENING THE DOOR. SHE TOOK THE VEHICLE TO THE DEALERSHIP TO BE INSPECTED AND WAS TOLD THAT THE PART FOR THE REPAIR WOULD COST $70.00. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. HER MODEL YEAR WAS EXCLUDED FROM RECALL# 09V171000 & 09V317000 (LATCHES/LOCKS/LINKAGES:DOORS:LATCH). THE CURRENT MILEAGE WAS APPROXIMATELY 36,000. THE FAILURE MILEAGE WAS APPROXIMATELY 34,000.