2000 HYUNDAI SONATA Complaints

THE CRANKSHAFT POSITION SENSOR IS FAULTY. I DON'T UNDERSTAND HOW HYUNDAI CAN HAVE A RECALL FOR THIS ITEM IN THEIR KIA OPTIMAS AND SANTA FE 2.5L V-6 ENGINES, BUT NOT IN THE 2.5L V-6 SONATAS. THE LEAST OF THE PROBLEMS IS DIFFICULTY STARTING, WHICH SEEMS TO BE THE CULMINATION OF THE PROBLEM. THE BEGINNING OF THE PROBLEM IS THE LOSS OF POWER AND STALLING, INCREDIBLY DANGEROUS WHILE ON THE HIGHWAY TRAVELING AT 60 MPH AND WITHOUT WARNING THE CAR LOSES POWER. LAST YEAR I SPENT OVER $500 FOR A TUNE UP AND SPARK PLUG WIRES. THE CHECK ENGINE JUST CAME ON TODAY AFTER HAVING TROUBLE GETTING STARTED AND HAD IT DIAGNOSED AS A P0335 CRANKSHAFT POSITION SENSOR A CIRCUIT MALFUNCTION. I CALLED SEVERAL DEALERSHIPS AND THE REPAIR IS IN EXCESS OF $400 FOR LABOR PLUS PARTS. *JB

TL*- THE CONTACT OWNS A 2000 HYUNDAI SONATA GLS, WITH A CURRENT MILEAGE OF 134,000 MILES. SHE STATED THAT THE VEHICLE LOST POWER WHILE DRIVING AT A LOW SPEED. WHENEVER THE VEHICLE LOST POWER SHE PULLED THE VEHICLE TO THE SIDE OF THE ROAD TO RESTART IT. AFTER RESTARTING THE VEHICLE IT WOULD ACCELERATE AT A LOW SPEED. THE FAILURE MILEAGE WAS 102,000. THE DEALER PERFORMED A TUNE UP, AND INFORMED HER THAT THE SPARK PLUG WIRES WERE BURNED. THERE IS A RECALL FOR THE ELECTRICAL SYSTEM WIRING RECALL # 00V259001. AS OF 4-18-07 THE FAILURE OCCURRED 25 TIMES .

TL*- THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CURRENT MILEAGE WAS 98,140. WHILE DRIVING 60 MPH ON THE FREEWAY DURING DRY WEATHER CONDITIONS, THE VEHICLE LOST POWER WITHOUT WARNING. SHE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO DEALER, WHO STATED THAT IT WAS THE MASS AIR FLOW SENSOR THAT CAUSED THE ENGINE TO FAIL. THE DEALER STATED THAT THERE WAS RECALL 00V259001 FOR THE MASS AIR FLOW, BUT THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL DUE TO THE VIN. THE CONTACT COULD NOT RECALL THE NAME OF THE DEALER WHERE SHE PURCHASED THE VEHICLE. *AK

VEHICLE OWNER WAS DRIVING HER 2000 HYUNDAI SONANA GLS WHEN VEHICLE HIT A POLE. THERE IS EXTENSIVE FRONT END DAMAGE AND SHE HIT THE STEERING WHEEL HARD CAUSING INTERNAL INJURIES. THE CAR IS EQUIPPED WITH FRONT AIRBAGS AND SIDE IMPACT AIRBAGS BUT NONE DEPLOYED. *AKOWNER QUESTIONED WHY AIRBAG (S) DID NOT DEPLOY. *AK

FRAME OF 2000 HYUNDAI SONATA WAS FOUND DURING OIL CHANGE TO BE SEVERELY RUSTED TO THE POINT WHERE VEHICLE WAS UNSAFE TO DRIVE. WENT TO DEALERSHIP WHERE WE WERE TOLD TO CONTACT HYUNDAI CORP. AFTER 2 WEEK PERIOD WE WERE TOLD HYUNDAI WOULD DO NOTHING TO CORRECT PROBLEM. WENT BACK TO DEALERSHIP AND AFTER 3 DAYS WERE AGAIN TOLD NOTHING WOULD BE DONE TO FIX PROBLEM. THE CAR ONLY HAD 88,000 MILES ON IT WHEN PROBLEM WAS DISCOVERED AND STILL HAD ORIGINAL MUFFLER. DOES FRAME USUALLY RUST OUT BEFORE MUFFLER? EVENTUALLY BECAUSE OF NEED FOR VEHICLE WERE FORCED TO HAVE VEHICLE FIXED OUT OF POCKET. REPAIR SHOP TOLD US THEY HAD REPAIRED SEVERAL HYUNDAI SONATAS OVER THE LAST YEAR WITH RUST ALL IN THE SAME SPOT ON THE FRAME AND THAT SOME COULDN'T EVEN MAKE IT TO THE SHOP WITHOUT A TOW. WE PAID TO HAVE A REFURBISHED FRAME PUT ON THE CAR, AT THE COST OF $1150, NOT TO MENTION THE INCONVENIENCE CAUSED OVER THE COURSE OF 3 MONTHS IT TOOK TO GET IT FIXED. WE HAD PICTURES TAKEN OF THE FRAME ON THE CAR AND AS IT CAME OFF. *JB

WHILE DRIVING APPROX 30 MPH MY FRONT RIGHT WHEEL FOLDED BACK AGAINST THE FENDER, BRING ME TO AN ABRUPT STOP. ONCE I HAD THE VEHICLE TOWED TO A LOCAL SHOP WE FOUND THAT THE SUB FRAME HAD RUSTED THROUGH AND THAT THE CONTROL ARM HAD COMPLETELY BROKEN OFF OF THE SUB FRAME. I HAD TO REPLACE THE COMPLETE SUBFRAME ON THIS 6 YEAR OLD VEHICLE WITH ONLY 77000 MILES ON IT. *JB

THE ALIGNMENT APPEARED TO BE OFF ON MY 2000 HYUNDAI SONATA. ON OCT. 1, 2006, THE VEHICLE WAS INSPECTED AT A LOCAL FIRESTONE STATION. THE MANAGER SHOWED ME THE CAUSE OF THE MIS-ALIGNMENT: THE ORIGINAL ENGINE CRADLE HAD NEARLY RUSTED THROUGH ON THE PASSENGER SIDE OF THE CAR. THERE WAS A RUSTED OUT HOLE IN THE ENGINE CRADLE THAT MY HAND COULD HAVE FIT THROUGH. THE VEHICLE WAS SUBSEQUENTLY TOWED TO A HYUNDAI DEALER'S SERVICE CENTER. DUE TO THE PRICE OF THE REPAIRS COMPARED TO THE VALUE OF THE CAR, I ELECTED TO FORGO REPAIRS. THE CAR WILL BE SOLD TO A SALVAGE YARD FOR PARTS. THE CAR HAD BEEN AT A HYUNDAI DEALER FOR REPAIRS IN OHIO IN MARCH AND MAY 2006. AT NEITHER TIME WAS RUST IDENTIFIED AS A THREAT TO THE INTEGRITY OF THE VEHICLE. THANKFULLY, THE DEFECT WAS DISCOVERED BEFORE ACCIDENTS OR INJURIES OCCURRED.

2000 HYUNDAI SONATA - MASS AIR FLOW SENSOR FAILED AT 45,000 MILES - WAS THIS ITEM REPLACED IN 2000 RECALL? *NM

DT*: THE CONTACT STATED THE AIRBAG WARNING ILLUMINATED CONSTANTLY. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER FOR RECALL #01V347000 BUT THE AIRBAG WARNING LIGHT CONTINUED TO ILLUMINATE.

I WAS TRAVELING DOWN THE HIGHWAY WHEN WITHOUT WARNING MY ENGINE SIMPLY SHUT OFF, AND THE POWER ASSIST TO THE BRAKES AND STEERING WAS STOPPED. I TRIED MOVING FROM THE CENTER LANE OVER TO THE SHOULDER AND WAS ALMOST REAR-ENDED BY A VEHICLE IN THE RIGHT LANE. I WAS ABLE TO PULL THE CAR OFF ON THE RIGHT SHOULDER AND STOP. THE VEHICLE WOULD NOT RESTART AND I HAD TO HAVE IT TOWED TO THE NEAREST DEALER IN THE AREA, PUGI HYUNDAI IN DOWNERS GROVE, IL. THEY TOOK THE VEHICLE IN FOR SERVICE AND LATER IN THE MORNING INFORMED ME THAT THE CRANKSHAFT POSITION SENSOR HAD FAILED. THE COST OF REPAIR WILL BE A MINIMUM OF $600, AND POSSIBLY MORE, DEPENDING IF THEY DETERMINE THE ENGINE NEEDS ADDITIONAL REPAIR PARTS. *NM