2014 HYUNDAI SONATA Complaints

Engine caught fire due to recall not complete, after taking it to mechanic to replace the fire damaged fuel line and engine wire harness, engine somehow lost compression and wouldn't start. Oil level and oil were good, engine started making knocking noise before catching fire. Manufacturer is refusing recall for the engine.

I WAS DRIVING 70 MILES PER HOUR WHEN MY CAR STARTED SLOWING DOWN AND THE CHECK ENGINE LIGHT WENT ON. I COULD NOT GO MORE THAN 40 MILES PER HOUR ON THE FREEWAY. MY ENGINE STARTED MAKING A KNOCKING NOISE THAT EVENTUALLY CUT THE ENGINE OFF. I was told that the engine has a lifetime warranty according to the Hyundai Motor America and Kia Motors America Resolve Engine Litigation [https://www.hyundainews.com/en-us/releases/2883]. I am unable to get in contact with Hyundai.

Break light harness was burning around the socket. Caught on time could of caused a fire and serious injury to me and my children. This should be recalled as it is known to be an issue with most of this model vehicle.

My brake light went out and it must of caused a shirt cause it then melt a portion of the plastic from the light assembly.

on 06/29/21 10am, I was entering Hwy 287 NO. from Hwy 80's Mawah exit. I accelerated from 50 MPH to 65 MPH, the engine shuts down. I was able to pull over to the shoulder. After a few minutes, I put the car in park and the engine restarted. I drove the car towards the next exit, then the engine shuts off again. I called AAA and I am waiting right now for the car to be towed. This is a very dangerous safety issue.

On 06/11/2021, I visited Hyundai Harrisonburg, VA service center to perform some recalls as per the attached documents. I was told that the engine is covered by a lifetime warranty and they didn't charge me anything. They performed recall #162 for the engine problem & installed a special software to monitor the knocking problem. They didn't open the engine to check the crank or the bearing wear. They asked me to keep an eye on the engine and if any thing happens, I could return back immediately to them. Only after 6 days, smoke started to go out of the exhaust and I couldn't drive the vehicle over 40 MPH. I drove the vehicle to them and left it for a week. After a week; when I called them, they told me that the engine needs to be changed with a new one but they couldn't contact Hyundai USA to send them a new engine because the car was driven more than 120K miles as per Hyundai rule (10 years/120K miles). I told the service center manager that it's a lifetime warranty according to the Hyundai Motor America and Kia Motors America Resolve Engine Litigation [https://www.hyundainews.com/en-us/releases/2883] He said that Hyundai should approve it to replace the engine and I should contact them for approval. So I contacted NHTSA to get me that approval instead of wasting my time explaining the litigation. I couldn't drive the vehicle since then because of the heavy smoke. I towed it from the Service Center to my home and submitted the complaint. I consulted 2 mechanics who advised me not to drive the vehicle to avoid engine explosion or an accident. It's not safe to drive the vehicle for me and for others in the street. The litigation is very clear that engine warranty is lifetime and the problem that happened to it is what that warranty covers. Smoke and low speed driving mode are some of many symptoms of that issue. I am waiving my right of compensation for towing or rentals and I don't want any compensation other than engine swap ASAP. I want them to tow it back. Thanks

Dash cracking severely over Airbags...Hyundai refuses to address the problem even though they had a PRIOR RECALL for the Same Issue. The Spiderweb Cracking is severe enough I am concerned my airbags will deploy without warning. Leather in Limited Model Seats Cracks and Disintegrates so badly the Power Motor and Components are exposed and compromised.

2014 Hyundai Sonata, 65500 miles. Engine seized while driving on the highway. Complete loss of power. Car would not start after the incident. Hyundai dealership won't have time to diagnose the car for 1.5 to 2 months and won't provide a loaner or rental car. Likely several additional months after they look at it to get a new engine.

3rd Brake light. The tailgate light that is in the rear middle inside the vehicle goes off and the bulb base is melting due to heat. It's available for inspection upon request. Moreover, it's a known problem in many models of my vehicle. This light is a part of the safety inspection in my state VA which means it's important to have it working all the time. If the vehicle driver behind me doesn't notice that I'm in a stopping process or pressing on the brake paddle, both of us will be at risk especially on the high way. Yes the problem was confirmed by Hyundai and many service centers confirmed it. There was also a recall regarding this problem but didn't solve it permanently. It happened again and service centers don't fix those affected vehicles again. Since there was a recall before, this component was inspected and confirmed by the manufacturer. They should keep fixing it till they find a permanent solution or change the part with a better one like LED for example to reduce heat. There was no warning lamp, message, or other symptoms of the problem prior to the failure. It's discovered when someone behind the affected vehicle warns me or the traffic police stops me. This is the most important brake light because at night it's the only light that warns other vehicles drivers behind me that's I'm reducing the speed or in a stop status since other right and left stop lights are shared with normal tailgate lights and might not warn others. This 3rd brake light is high enough to be seen by all vehicles behind my vehicle.

Break lights continue to burn out. In the 5 yrs I've had the vehicle this is a constant issue. I've taken the vehicle to Balise Hyundai replacing the Bulbs multiple times and replaced one Harness. Today both break lights had to have a full assembly replacement, including harness and the bulbs melted the plastic. The passenger break light even exploded that's how overheated it became. There have been no indication when these lights burn out. I've always had a stranger, neighbor, family or friend alert me that one of my lights were out. 4/26/21 a stranger driving behind pulled up next to me to alert me my tail lights were out. Not knowing break lights out is a safety hazard whether driving on street or highway. The back window has an additional light that has continued to work. In the last 3 years my driving was reduced more than 60% as I relocated to work from home. The vehicle was serviced today 6/2/21 at Hiley Hyundai who performed the most recent inspection and diagnostic on the vehicle, as well as performed the repairs.