2004 HYUNDAI SONATA Complaints

SUB FRAME ON FRONT PASSENGER RUSTED AND CORRODED. CAUSED DAMANGE TO CV AXLE ON SAME SIDE. CAUSED ALIGNMENT ISSUES ON FRONT END. CAUSES TIRES TO WEAR QUICKLY, WITHIN A WEEK. ANTI THEFT SYSTEM LOCKS THE CAR WHILE DRIVING AND CAUSES ALARM TO SOUND WHILE DRIVING AND MUST OPEN OTHER DOORS AND STOP DRIVING TO STOP THE ALARM FROM GOING OFF, HEADLIGHTS AND DASH LIGHTS AND TAIL LIGHTS COME ON WHEN BRAKE IS PRESSED AND GO OFF WHEN BRAKE IS RELEASED BUT THIS PROBLEM ONLY HAPPENS WHEN HEADLIGHTS ARE NOT IN USE

LEAKING VALVE COVER IS ALLOWING OIL TO LEAK DOWN ONTO THE ALTERNATOR. CAR CAN BE STATIONARY OR RUNNING. MOST NOTABLE WHEN CAR ENGINE IS RUNNING. OIL LEAKING ONTO ALTERNATOR CAN CAUSE ALTERNATOR TO SHORT. ALTERNATOR FAILED AND CAR BATTERY COULD NOT CHARGE BATTERY. CAR DIED WHILE MY WIFE WAS DRIVING AND SHE HAD TO PULL QUICKLY OFF TO THE SIDE OF THE ROAD.

THE CONTACT OWNS A 2004 HYUNDAI SONATA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE DUE TO STEERING ISSUES AND FRONT END NOISE AN INDEPENDENT MECHANIC DIAGNOSED THAT THERE WAS EXTENSIVE RUST AND CORROSION CONCERNING THE FRONT CRADLE FRAME NEAR THE FRONT PASSENGER SIDE TIRE AND NEAR THE CONCENTRIX BRAKE ADJUSTMENT FOR BOTH REAR TIRES PERTAINING TO THE SUBFRAME. THE INDEPENDENT MECHANIC ADVISED THE CONTACT TO CONTACT THE LOCAL DEALER FOR THE MANUFACTURER FOR A RECOMMENDATION.DEALER RECOMMENDS THE ENTIRE CRADLE BE REPLACED AS IT WILL NOT LAST MUCH LONGER AND CAN BE DANGEROUS TO DRIVE AS IT IS ALMOST RUSTED THROUGH AND THE REAR BRAKES CANNOT BE ADJUSTED DUE TO RUST. THERE IS A RECALL 09V124000 FOR THIS FOR CARS FROM THE RUSTBELT STATES BUT I AM IN TN AND IT IS NOT COVERED. I AM IN THE MOUNTAINS OF NORTH EAST TN AND IT SHOULD BE COVERED AS WE ALSO GET SNOW AND THEY SALT THE ROADS. THIS CAR IS DANGEROUS TO DRIVE IN ITS PRESENT CONDITION AND HYUNDAI NEEDS TO HAVE THIS FIXED AS OBVIOUSLY FROM THE COMPLAINTS THERE IS LOTS OF THIS. MFG IN SEPT OF 2003 SO IT IS WITHIN THE TIME FRAME

TL* THE CONTACT OWNS A 2004 HYUNDAI SONATA. WHEN THE VEHICLE WAS SHIFTED INTO DRIVE, IT ACCELERATED ON ITS OWN. THE CONTACT HAD TO TAP THE ACCELERATOR PEDAL A FEW TIMES OR SHIFT INTO PARK FOR THE VEHICLE TO OPERATE NORMALLY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 215,000.

TL* THE CONTACT OWNS A 2004 HYUNDAI SONATA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, AN INDEPENDENT MECHANIC DIAGNOSED THAT THERE WAS EXTENSIVE RUST AND CORROSION CONCERNING THE FRONT FRAME, REAR FRAME, NEAR THE FRONT PASSENGER SIDE TIRE, AND NEAR THE FRONT REAR TIRE TIE RODS PERTAINING TO THE SUBFRAME. THE INDEPENDENT MECHANIC ADVISED THE CONTACT TO CALL THE MANUFACTURER FOR A RECOMMENDATION. THE MANUFACTURER HAD KEY HYUNDAI OF SALEM (470 S BROADWAY, SALEM, NH 03079, (603) 841-3099) SCHEDULE AN APPOINTMENT ON AUGUST 28, 2018 TO DIAGNOSE AND REPAIR THE VEHICLE. THE CONTACT WAS NOT INCLUDED IN NHTSA ACTION NUMBER: EA08016 (SUSPENSION, STRUCTURE) AND NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION). THE MANUFACTURER PROVIDED NO REMEDY AND ADVISED THAT THE DEALER REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 HYUNDAI SONATA. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN TO WOBBLE VIOLENTLY AND AN ABNORMAL SQUEALING SOUND WAS HEARD. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT LOST CONTROL OF THE VEHICLE AS IT CAME TO A STOP BY THE CURB. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED INVER GROVE HYUNDAI AT (888) 706-5928 (LOCATED AT 1290 50TH ST E, INVER GROVE HEIGHTS, MN 55077), BUT NO ASSISTANCE WAS PROVIDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 175,000.

THERE IS A RECALL ON THE 2004 HYUNDAI SONATA NHTSA VEHICLE SAFETY RECALLS RECALL NUMBER 09V124000 BUT, HYUNDAI SAYS MY CAR MISS BY 2 WEEKS CUT OFF IS NOV. 20 2003, MY VEHICLE DATE IS DEC. 19 2003

MY CAR HAS FAILED THE STATE SAFETY INSPECTION DUE TO A RUSTED SUB-FRAME. HYUNDAI HAS RECALLED MAY OF THESE CARS (SAME YEAR, MAKE AND MODEL) DUE TO THIS ISSUE YET REFUSES TO COVER MINE AS THEY SAY IT WAS NOT PART OF THE RECALL. IT HAS THE SAME EXACT ISSUE AS THOSE THAT WERE RECALLED. I HAVE TRIED TWICE UNSUCCESSFULLY TO HAVE THEM CORRECT THIS SAFETY ISSUE. THERE ARE 2 CASE NUMBERS, 11190286 & 100927.

FUEL SYSTEM CANNOT FUEL VEHICLE PROPERLY DUE TO POOR VENT RECOVERY EQUIPMENT.... NONE OF IT IS REPLACEABLE AS REPLACEMENT PARTS ARE NOLONGER AVAILABLE...

THE 2004 HYUNDAI SONATA HAS A RECALL FOR THE FRONT SUB FRAME RUSTING TO THE POINT WHERE THE FRONT SUSPENSION MOUNT RUST TO THE EXTENT THAT THE LOWER CONTROL ARM SEPARATES FROM IT'S MOUNTING BRACKET WHICH CAN CAUSE LOSS OF CONTROL AND POSSIBLE ACCIDENT. THERE IS A RECALL FOR THIS FOR CARS THAT WERE SOLD OR REGISTERED IN THE SALT BELT STATES. EVERY STATE IN MY AREA ARE LISTED EXCEPT MY STATE OF VIRGINIA. MY CARS SUB FRAME COMPLETELY RUSTED THROUGH TO WHERE THE LOWER CONTROL ARM SEPARATED FROM IT'S BRACKETS WHILE MOVING ENTERING AN EXIT ONTO A MAJOR HIGHWAY I95 CAUSING SEVERE DAMAGE WHICH ISN'T COVERED. THE RECALL IS 09V124000. I BELIEVE VIRGINIA SHOULD BE ADDED TO THIS RECALL DUE TO IT BEING IN THE SAME AREA AS THE OTHER STATES WITH THE SAME WEATHER PATTERN.