2015 HYUNDAI SONATA Complaints

The contact's son owns a 2015 Hyundai Sonata. The contact stated that while the vehicle was being driven at 40-50 MPH, the vehicle began to jerk. The check engine light was illuminated. The vehicle was taken to an independent mechanic who determined the failure was related to the engine. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 102,198.

On 5/27/2026 I was driving home from work. Had just gotten off the frwy , was driving around 35-40mph, all of a sudden , engine turned off, after coming to a stop, holding up traffic, i put in park, and nothing, not crancking, a new battery was imstalled, 3 weeks prior, have recoreds of all maintenance! Checked oil level was good, radiator, had fluid, and fas tank was 1/2 full! Pushed to a side street ,Uberd, back home, later that evening , had car towed approx 5 miles to my house. Checked all fuses, ignition, and starter! Spoke with Local Hundai Dealership, scheduled a maintenance diagnostic to be performed! Could have been an accident, first time, ever experienced, such an issue!

I have the 2015 Hyundai sonata with the 2.5 GDI engine that eventually will seize due to internal damaged caused by manufacture design flaws. My Hyundai threw a P0010 code which causes my car to idle high and causing low vacuum affecting my brakes. I had a diagnostic test done at a Hyundai dealership that told me it was a cvvt cam sprocket issue and that it was the beginning of the end of the engine, They quoted me 3700.00 but the engine was to far gone and this repair would only accelerate the engine to seize. They said since the engine isn't seize Hyundai will not cover the cost to repair or exchange the engine, I contacted the Hyundai customer service who stated since the repair that is needed wasn't the root cause of the problems associated with the engine swap warranty they were not going to help me even though I explained to them that the cars high accelerating and the braking system been jeopardized and been told the engine is beyond repairs I feel Hyundai should reconsider their decision and help a loyal customer. I have purchased 12 Brand New Hyundaj since 2001. The customer Representative was Extremely un Professional even suggesting I scrap my car, Also I contacted My Hyundai service Technician who said Hyundai customer service never contacted them about my car, When they said they spoke with the technician. Also I received an Extended warranty on the 2.4 GDI engine from Hyundai who many Hyundai customers are or have dealt with.I also purchased an Extended warranty Which I believe should have been extended as well Thank You

Engine – connecting rod bearing failure. Theta II engine. Hyundai confirmed the defect via Bearing Clearance Test (BCT) on October 3, 2025. The engine can seize without warning, causing sudden loss of power while driving – a clear safety risk. The problem has been confirmed by an authorized Hyundai dealership (Hertrich Hyundai of New Castle). The manufacturer issued Technical Service Bulletin 22-EM-001H (TXXI lifetime warranty) covering this exact defect. Despite confirming the failure, the manufacturer has refused to repair the engine. The vehicle is available for inspection upon request. No crash, fire, or injury occurred. Warning signs included engine noise and illumination of check engine light before failure.

My infotainment unit stoped working after an update that was pushed to the car by Hyundai. My battery was beginning to show signs that it needed replacing (not cranking in the cold temps or needing a few tries to start), so I went to Advance Auto to have the battery replaced. Once back in the car, everything was working fine (radio with sirius XM, back up camera, Navigation, Android and Apple car plan, the clock, everything). When I went to reset the clock, the car showed a software update was availabe and needed to be downloaded. Never before, had I seen this. So, I selected update. After 30 minutes of seeing it say downloading, it then started to say install. It gets to where it says, the radio needs to be restarted to complete the update and then gives error code 604. Now the telematics or infotainment works. I reached out to mapit, Hyundia and Bluelink who all say, "to bad for you, buy a new one for $1600". I did not ask for the update, I did not go looking for the update and I did not push the update to my vehicle, Hyundia did and me and the other 2000 owners who are going through this should not have to pay that kind of money to have it repaired. If they new they were shutting down 3G service, then don't push the update to my car. Hyundia has admitted the issue for Hyundia Tusons and a few other vehicles but not for 2015 model Sonata's. So for Tusons they send out 3 SD cards to fix the issue, but refuse to do so for all the cars they pushed an update to that as they called it Bricked the head of the unit. I am looking for help to get this fix without me paying $1600. If Hyundia recognizes the problem in some cars and not others thats an issue. One that we the public would love help addressing.

since i have owned this car they have replaced the knock sensor twice. there is a recall on the engine for crank bearing wear, my car now is burning through 5 quarts of oil every 2 weeks with no oil leak spots on the ground. i would like them to replace the engine as per the recall. the knock sensor should be an indication of the bearings going bad. i have been getting the run around from the dealer in Salem, Oregon. so, i would like some assistance with this problem thank you for your time.

Component Involved: Hybrid Propulsion System High Voltage Battery / EV Battery Electrical System Power Train Incident Summary: I am reporting a serious and repeated safety defect involving my 2015 Hyundai Sonata Hybrid. This vehicle has experienced three separate incidents where warning messages related to the EV/hybrid battery system appeared, followed by a sudden loss of forward propulsion. During these events, the vehicle would not move properly or lost the ability to accelerate safely. This defect creates a major safety hazard because it can occur while driving, increasing the risk of being rear-ended, stranded in traffic, collision, injury, or property damage. I transport my small children in this vehicle and no longer feel it is safe. Detailed Timeline: Initial Incident: Vehicle displayed warning messages involving the EV/hybrid battery system and lost the ability to move forward properly. Vehicle had to be shut off and restarted. Independent Mechanic Inspection: Vehicle was inspected by an independent mechanic who advised the hybrid battery system likely needed repair or replacement and recommended service through Hyundai dealership. Dealer Visit #1 – Stew Hansen Hyundai (3/18/2026): Vehicle was taken to authorized Hyundai dealer for diagnosis. Dealer stated they could not duplicate the issue and no repair was made. Second Failure: After release from dealer, same dangerous loss-of-power condition occurred again, resulting in towing and additional inconvenience. Dealer Visit #2 – Stew Hansen Hyundai (4/8/2026): Vehicle returned to dealer for same issue. Dealer performed software update and stated this should correct problem. Dealer advised vehicle had been driven approximately 40 miles and was safe to release. Third Failure (4/12/2026 approx.): Only two days after picking vehicle up on 4/10/2026, same warning messages and propulsion failure occurred again. Safety Concern: This repeated loss of propulsion without warning is extremely dangerous.

CAR STOPPED ON THE ROAD LAST WEEK 4/6/26 COULD NOT START HAD TO GET TOWED MECHANIC SAYS NO OIL IN ENGINE RECEIVED OIL CHANGE LAST MONTH

?I will take ?10k$ for the car or a new engine and steering, damages fixed. . I also need a rental by April 10th and $300 for inconvenience thus far. ?The engine ?stalled ?twice? when driving over 2 months! The lawyer won't be forgiving.

Engine seized driving down the interstate doing 65 MPH in rush hour traffic could have been rear ended or hit vehicles around me trying to get off the road. Complete loss of power. Power steering was still active brakes were barely working. No warning lights (I had the knock sensor recall performed). Engine simply locked up solid. I was able to safely make it to the disabled vehicle lane and put the car in park. Engine had no sludge buildup and looked excellent once it was disassembled by the dealer. All engine bearings had spun. Engine was completely replaced under the extended warrenty.