2015 HYUNDAI SONATA Complaints

The vehicle has a very strong smell of gasoline and has been taken to the repair shop after spark plug flooding. Vehicle still smells like gas after repair but runs now.

Major oil consumption going on for years. Took in to dealer two years ago, they know there is a problem. They told me I could spend thousands of dollars to tear it apart to find out what is going on, and also told me to call corporate. I got no where with either, even though they recalled the engine in other Sonata cars, just not our ECO model. Slowly started having throttle issues at 4 to 5 year mark. Informed dealer service center that it wasn't moving like it should when gas was pressed. Now, the car is having major problems with acceleration. Barely would go in reverse, drove 1.5 blocks, speed not matching to throttle, press on gas, barely moving from a stop, going really slow, had to turn around and take back home. Our problem with the car is the same that others are complaining about. The car is not safe for a 7 year old car that started having problems at the 4 to 5 year mark.

Trunk latch has failed and is impossible to open the trunk. The risk of not being able to change a flat tire or having someone locked in the trunk. There is a recall for same generation of Sonata but recall is not available for the 2015 model.

The contact owns a 2015 Hyundai Sonata. The contact stated that while driving 40 MPH, the vehicle failed to accelerate while the check engine warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the throttle control module needed to be replaced. The vehicle was repaired however, two weeks later the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed that the Voice Coil Motor (VCM) needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 127,828.

My Sonata is burning excessive oil since January 2022 have to add a quart a week but there is no oil leak.

While driving, the following warning appeared: Hybrid System Warning! Safely Stop and Do not Drive. The vehicle was turned off and restarted, due to the fact that this same warning appeared in the summer of 2021, where it was towed to the dealer and they were unable to discover any problem. When the vehicle was taken to the dealer this time they found the code P1B70, high voltage battery to low, there was a flash update for the BMS module to correct the issue. My issue is that you do not always have a appropriate spot where you can stop the vehicle and leave it for a tow. Perhaps this flash update should be installed in all 2015 Hyundai Sonata Hybrids as a recall so as not to leave the drivers in an unsafe condition

1/2022. My vehicle start leaking oil. Vehicle was under warranty. Had multiple things replaced. Thought oil leak was fixed. Not even a month later in 2/2022, vehicle was leaking oil again. Brought it back to dealer & they redid gaskets, seals, etc. 4/22/22, have no even put 3000 miles on vehicle since it was at the dealership & there was a knocking noise coming from under my hood. Called the dealership and they said I needed to get it back to them. Oil consumption test was never done because it was assumed that my oil was low because it was leaking. Both times oil was put in my vehicle. On 4/28/22, I was at work and went outside to check my oil and there was little to no oil on the stick. I immediately added 5 quarts of oil which is required for my vehicle. The knocking did not stop. I left work to run a brief Errand on 4/29/22, and had just pulled out of work onto a very busy four-lane highway. All of a sudden I hear this big boom under my hood, my car locks up and my oil light comes on. I immediately took my foot off of the gas and coasted into the next driveway at a business. There was oil all over the road and pouring out from under my car. It happened to be an auto parts store. A mechanic came outside and looked and said a rod went through my engine block & oil was pouring out of my car. I started to have an anxiety attack and went into shock. Luckily I was not on the interstate because it could have been very bad. I am now without a car. None of the rental car Places have any vehicles available and I have a full-time job & single mom with 2 kids. The dealership was nice enough to have my car towed to them 45 minutes away. They Then tell me about an oil consumption problem with Hyundai and there is a big class action lawsuit. This should have never happened. Apparently the oil consumption was never sent out as a recall or anything else so I was unaware of it to even know to check my car other than regular oil changes.

My 2015 Sonata has been going through at least a quart to a quart and a half of oil every thousand miles. I researched this and found out that the 2015 sonatas have a very common problem where the engine needs to be replaced. There was huge class action suit against Hyundai and I'm worried that this is going to lead to bigger problems for me. I have gone to the dealer for 5 times and they keep telling me I'm not burning enough oil to justify the engine replacement but I'm not comfortable with their report.

There's an oil line to the turbocharger; my guess is to cool the turbo and it came off spraying oil all over the engine compartment and when it hits the turbo the heat from the turbo would create smoke that would get into the passenger compartment and billowing out from under the hood. Hyundai had a recall campaign to fix this issue for the same 2.0T engine but only for Sonata models from 2011-2014 and they deny that this recall applies to my car because it's MY2015. Same car, same engine, same turbo oil feed line and they refuse to honor repair costs for recall campaign 16-01-071. I had to go through this risky incident and then have to pay $720 in repairs that was caused by a design flaw.

Was pulling out of a parking lot and the engine stalled. Would not crank over again. Mechanic took the timing cover off to inspect and found timing chains are all in working order. Will all engine belt driven accessories disconnect and timing cover off. Engine cannot be rotated with a breaker bar. Technician says the bearings are seized.