2022 HYUNDAI TUCSON Complaints

This 2022 Hyundai Tucson stalled in the middle of a busy highway with my wife in the vehicle. The car suddenyly stalled while going 75mph and she was almost killed and got rear ended. Later we were informed by the dealership that there is a inherent issue with the fuel injection system on these vehicles and the fuel injector has gone bad. These people only replaced the faulty injector. Two months back another injector went bad and then i researched and found this is a bad engineering issue. Now Hyundai is trying to hide behind the veil of Texas Leamon law and is not taking any responsibility or buying back the vehicle. Hyundai forums are full of this problem and many people avoided near death experience because of the stall. I can provide reditt and hyundai forum urls for reference if required.

The contact owns a 2022 Hyundai Tucson. The contact stated while driving at various speeds, the vehicle intermittently went into LIMP Mode with several unknown messages displayed on the instrument panel. The contact stated that the failure occurred for approximately 15-20 seconds before the vehicle resumed normal operation. The vehicle was taken to the dealer, but the failure could not be duplicated. The vehicle was not diagnosed. The manufacturer was notified of the failure and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 32,000.

The vehicle experienced a malfunction in the ignition or fuel delivery system, specifically a misfire detected in cylinder 2 (DTC P030200). This component has been documented by the manufacturer’s vehicle service center as an issue and may be available for inspection upon request. The misfire caused reduced engine power and hesitation during acceleration, posing a safety risk, particularly while merging onto highways or attempting to pass other vehicles. The issue has been reviewed and addressed by the manufacturer dealer service center twice (presently going in for a third time); however, the problem returned each time after a few weeks, with less than approximately 5,000 additional miles driven. The vehicle has not been inspected by police, insurance representatives, or other parties. The "Check Engine" warning lamp illuminated when the failure occurred, accompanied by symptoms of rough idling and reduced performance.

2 months ago our engine control system warning light came on with a great decrease in speed while driving on the freeway. Brought to Hyundai dealership and was determined that fuel injector 1 misfired and needed replacement. Just last week exact same issue in fuel injector 4 occurred. They admitted issues with 2022 Tuscon injectors but won’t replace until they fail as no recall. This is a massive safety issue as can be driving at a high rate of speed and speed slows immediately.

While driving down interstate, the panoramic sunroof panel above the driver and front seat passenger spontaneously exploded and shattered. This occurred on a clear sunny morning and there were no other vehicles on the road in the area at the time.

Running lean on bank 1-Dealership states it is a bad fuel injector on cylinder 1says it is not covered under 100,000 mile warranty. Vehicle currently at 80,000 mile. Radio in vehicle is restarting itself and not shutting off when car is turned off. Radio does not respond to commands such as volume adjustment. Dealership performed software update, but it did not work.

Driving 78 mph on the highway, when the car stopped it accelerating, dropped to 67, pulled to shoulder. Car would not restart. Towed to dealer and was told the fuel injector failed and was flooded engine. Check engine came on with code DTC P030400 DTC System POWERTRAIN DTC Sub System EMS

Stopped at a red light, rear-ended and when hit, seat belt malfunction, did not restrain

Warning lights and messages for the Blind Spot Safety System and Rear Cross Traffic Safety System appear in driver information display. Those systems failed to function. Took to dealer for diagnosis/repair. After dealership working on vehicle both systems fail to function.

Here we go again. Last time the #3 fuel injector failed while driving on the freeway. Car started shaking and lost acceleration with "check engine" warning light on. Two months later, #2 fuel injector failed while driving on the street with same symptoms as last time. Fortunately, both incidents did not cause any accident but was terrifying. I requested the Hyundai service dealer replace the remaining fuel injectors and again, was informed that Hyundai will only authorize them to replace a defective injector when it's failed. I do not understand Hyundai's logical thinking. Hyundai is fully aware of this issue and have already sent out TSBs. Are they waiting for someone to be in an accident and have major bodily injury caused by defective fuel injectors before taking this matter seriously? I will also address this matter to Hyundai Corporation for a response.